AME78L09AJAT

AME, Inc. AME78LXX 100mA Positive Linear Regulator n General Description The AME78LXX is a fixed output positive regulator. The regulator can provide local on card regulation, eliminating the distribution problems associated with single point regulation. The AME78LXX can be used in logic systems, instrumentation, HiFi, and other solid state electronic equipments. When used as a Zener diode/resistor combination replacement, the AME78LXX usually results in an effective output impedance improvement of two orders of magnitude, and lower quiescent current. With adequate heat sinking the AME78LXX can deliver 100mA output current. Current limiting is included to limit the peak output current to a safe value. The AME78LXX is available in the plastic TO-92, SO-8 and SOT-89 packages. n Functional Block Diagram Input Current Limiting Amplifier Thermal Protection Output Error Amp. Bandgap Voltage GND n Features l Guaranteed 100mA Output l Fixed Output Voltage l Typical Line Regulation ≤ 18mV l Accurate to Within ± 5% l Internal Short Circuit Current-Limiting l TO-92, SO-8, and SOT-89 Package n Typical Application VIN AME78LXX VOUT n Applications l Post Regulation for Switching Supply l Microprocessor Power Supply l Mother Board I/O Power Supply l Battery Power Circuit l Instrument Note1: Bypass Capacitors are recommended for optimum stability and transient response and should be located as close as possible to the regulator 0.33uF (Note1) 0.1uF (Note1) 1 AME, Inc. AME78LXX 100mA Positive Linear Regulator n Pin Configuration SO-8 Top View 8 7 6 5 SOT-89 Top View AME78LXXAJHA 1. VOUT 2. GND 3. GND 4. N/C 5. N/C 6. GND 7. GND 8. VIN AME78LXXAJFT 1. VOUT 2. GND 3. VIN AME78LXX AME78LXX 1 2 3 1 2 3 4 TO-92 Front View AME78LXXAJAT 1. VOUT AME 78LXX 2. GND 3. VIN 1 2 3 2 AME, Inc. AME78LXX 100mA Positive Linear Regulator n Ordering Information AME78LXX x x x x x Special Feature Number of Pins Package Type Operating Temperature Range Pin Configuration Pin Configuration Operating Temperature Range Package Type Number of Pins Special Feature A (SOT-89) 1 . VOUT 2 . GND 3 . VIN 1 2 3 4 5 6 7 8 . VOUT . GND . GND . N/C . N/C . GND . GND . VIN J: -40OC to 125OC A: TO-92 F: SOT-89 H: SOIC (150 mil) A: 8 T: 3 Z: Lead free A (SO-8) A (TO-92) 1 . VOUT 2 . GND 3 . VIN 3 AME, Inc. AME78LXX 100mA Positive Linear Regulator n Ordering Information (contd.) Part Number AME78L05AJFT AME78L05AJFTZ AME78L05AJHA Marking* A78L05 AJFww A78L05 AJFww 78L05 AJHA yyww 78L05 AJHA yyww AME 78L05 AJAT yyww AME 78L05 AJAT yyww A78L08 AJFww A78L08 AJFww 78L08 AJHA yyww 78L08 AJHA yyww AME 78L08 AJAT yyww AME 78L08 AJAT yyww A78L09 AJFww A78L09 AJFww Output Voltage 5V 5V 5V Package SOT-89 SOT-89 SO-8 Operating Temp. Range -40oC to 125oC -40oC to 125oC -40oC to 125oC AME78L05AJHAZ 5V SO-8 -40oC to 125oC AME78L05AJAT 5V TO-92 -40oC to 125oC AME78L05AJATZ 5V TO-92 -40oC to 125oC AME78L08AJFT AME78L08AJFTZ AME78L08AJHA 8V 8V 8V SOT-89 SOT-89 SO-8 -40oC to 125oC -40oC to 125oC -40oC to 125oC AME78L08AJHAZ 8V SO-8 -40oC to 125oC AME78L08AJAT 8V TO-92 -40oC to 125oC AME78L08AJATZ 8V TO-92 -40oC to 125oC AME78L09AJFT AME78L09AJFTZ 9V 9V SOT-89 SOT-89 -40oC to 125oC -40oC to 125oC 4 Note:yyww represents date code * a line on top of the first letter represents lead free plating such as A78L05. Please consult AME sales office or authorized Rep./Distributor for voltage accuracy and package type availability. AME, Inc. AME78LXX 100mA Positive Linear Regulator n Ordering Information (contd.) Part Number AME78L09AJHA Marking* 78L09 AJHA yyww 78L09 AJHA yyww AME 78L09 AJAT yyww AME 78L09 AJAT yyww A78L12 AJFww A78L12 AJFww 78L12 AJHA yyww 78L12 AJHA yyww AME 78L12 AJAT yyww AME 78L12 AJAT yyww Output Voltage 9V Package SO-8 Operating Temp. Range -40oC to 125oC AME78L09AJHAZ 9V SO-8 -40oC to 125oC AME78L09AJAT 9V TO-92 -40oC to 125oC AME78L09AJATZ 9V TO-92 -40oC to 125oC AME78L12AJFT AME78L12AJFTZ 12V 12V SOT-89 SOT-89 -40oC to 125oC -40oC to 125oC -40oC to 125oC AME78L12AJHA 12V SO-8 AME78L12AJHAZ 12V SO-8 -40oC to 125oC AME78L12AJAT 12V TO-92 -40oC to 125oC AME78L12AJATZ 12V TO-92 -40oC to 125oC * Package Options Part Number AME78LXXXJAT AME78LXXXJAT-1 Package TO-92 Taping TO-92 Bulk Lead Pitch 5.04mm 2.54mm 5 AME, Inc. AME78LXX 100mA Positive Linear Regulator n Absolute Maximum Ratings Parameter Input Voltage TO-92 Thermal Resistance (Junction to Ambient) SOT-89 SO-8 Operating Junction Temperature Range Storage Temperature Range Lead Temperature (10 Sec) TJ TSTG TLEAD θJA Symbol VIN Maximum 20 180 180 124 -40 to 125 - 65 to 150 265 Unit V o C/W o C n Recommended Operating Conditions Parameter Operating Junction Temperature Range (TJ ) Rating -40 to + 125 Unit o C 6 AME, Inc. AME78LXX 100mA Positive Linear Regulator n Electrical Specifications-5V Limits in standard typeface are for TJ=25oC, Io=40mA, CI=0.33uF, CO=0.1uF, VI=10V, unless otherwise specified. Parameter Output voltage Symbol Vo Test Condition 7.0V ≤ VIN ≤ 15V 1.0mA ≤ IO ≤ 40mA (Note1) Line Regulation Load Regulation Quiescent Current Quiescent Current Change Output Voltage Noise Ripple Rejection Peak Output Current RegLINE RegLOAD IQ IQ eN ∆ VIN / ∆ VO IPK IO=5.0mA 8.0V ≤ VIN ≤ 15V 1.0mA ≤ IO ≤ 40mA 10Hz ≤ f ≤ 100kHz (Note2) f=120Hz, 8.0V ≤ VIN ≤ 15V 47 40 62 150 -0.65 7.0V ≤ VIN ≤ 15V 1.0mA ≤ IO ≤ 100mA Min 4.8 * 4.75 18 20 3 Typ 5 Max 5.2 * 5.25 75 60 5 * 1.0 * 0.1 V Units mV mV mA mA µV dB mA mV / oC Average Temperature Coefficient ∆ VO / ∆ T of Output Voltage Minimum Value of Input Voltage Required to Maintain Line Regulation VIN (MIN) 6.7 7 V Note1: Power Dissipation ≤ 0.6W Note2: Recommended minimum load capacitance of 0.01uF to limit high frequency noise. 7 AME, Inc. AME78LXX 100mA Positive Linear Regulator n Electrical Specifications-8V Limits in standard typeface are for TJ=25oC, Io=40mA, CI=0.33uF, CO=0.1uF, VI=14V, unless otherwise specified. Parameter Output voltage Symbol Vo Test Condition 11V ≤ VIN ≤ 18V 1.0mA ≤ IO ≤ 40mA (Note1) Line Regulation Load Regulation Quiescent Current Quiescent Current Change Output Voltage Noise Ripple Rejection Peak Output Current RegLINE RegLOAD IQ IQ eN ∆ VIN / ∆ VO IPK IO=5.0mA 11V ≤ VIN ≤ 18V 1.0mA ≤ IO ≤ 40mA 10Hz ≤ f ≤ 100kHz (Note2) f=120Hz, 11V ≤ VIN ≤ 18V 39 60 45 150 -0.80 11V ≤ VIN ≤ 18V 1.0mA ≤ IO ≤ 100mA Min 7.7 * 7.6 18 20 3 Typ 8 Max 8.3 * 8.4 75 90 5 * 1.5 * 0.1 V Units mV mV mA mA µV dB mA mV / oC Average Temperature Coefficient ∆ VO / ∆ T of Output Voltage Minimum Value of Input Voltage Required to Maintain Line Regulation VIN (MIN) 9.7 V Note1: Power Dissipation ≤ 0.6W Note2: Recommended minimum load capacitance of 0.01uF to limit high frequency noise. 8 AME, Inc. AME78LXX 100mA Positive Linear Regulator n Electrical Specifications-9V Limits in standard typeface are for TJ=25oC, Io=40mA, CI=0.33uF, CO=0.1uF, VI=15V, unless otherwise specified. Parameter Output voltage Symbol Vo Test Condition 12V ≤ VIN ≤ 18V 1.0mA ≤ IO ≤ 40mA (Note1) Line Regulation Load Regulation Quiescent Current Quiescent Current Change Output Voltage Noise Ripple Rejection Peak Output Current RegLINE RegLOAD IQ IQ eN ∆ VIN / ∆ VO IPK IO=5.0mA 12V ≤ VIN ≤ 18V 1.0mA ≤ IO ≤ 40mA 10Hz ≤ f ≤ 100kHz (Note2) f=120Hz, 12V ≤ VIN ≤ 18V 38 70 44 150 -0.90 12V ≤ VIN ≤ 18V 1.0mA ≤ IO ≤ 100mA Min 8.6 * 8.55 18 20 3 Typ 9 Max 9.4 * 9.45 75 90 5 * 1.5 * 0.1 V Units mV mV mA mA µV dB mA mV / oC Average Temperature Coefficient ∆ VO / ∆ T of Output Voltage Minimum Value of Input Voltage Required to Maintain Line Regulation VIN (MIN) 10.7 V Note1: Power Dissipation ≤ 0.6W Note2: Recommended minimum load capacitance of 0.01uF to limit high frequency noise. 9 AME, Inc. AME78LXX 100mA Positive Linear Regulator n Electrical Specifications-12V Limits in standard typeface are for TJ=25oC, Io=40mA, CI=0.33uF, CO=0.1uF, VI=18V, unless otherwise specified. Parameter Output voltage Symbol Vo Test Condition 15V ≤ VIN ≤ 18V 1.0mA ≤ IO ≤ 40mA (Note1) Line Regulation Load Regulation Quiescent Current Quiescent Current Change Output Voltage Noise Ripple Rejection Peak Output Current RegLINE RegLOAD IQ IQ eN ∆ VIN / ∆ VO IPK IO=5.0mA 15V ≤ VIN ≤ 18V 1.0mA ≤ IO ≤ 40mA 10Hz ≤ f ≤ 100kHz (Note2) f=120Hz, 15V ≤ VIN ≤ 18V 40 80 54 150 -1.00 15V ≤ VIN ≤ 18V 1.0mA ≤ IO ≤ 100mA Min 11.5 * 11.4 18 20 3 Typ 12 Max 12.5 * 12.6 75 90 5 * 1.5 * 0.1 V Units mV mV mA mA µV dB mA mV / oC Average Temperature Coefficient ∆ VO / ∆ T of Output Voltage Minimum Value of Input Voltage Required to Maintain Line Regulation VIN (MIN) 13.7 V Note1: Power Dissipation ≤ 0.6W Note2: Recommended minimum load capacitance of 0.01uF to limit high frequency noise. 10 AME, Inc. AME78LXX Dropout Voltage vs. Temperature 2000 1900 100mA Positive Linear Regulator Dropout Voltage vs. Load Current 2000 1900 -45 oC -5oC 25 C 55 oC 85 oC 115oC 1300 1200 1100 125oC o Dr op out Vo ltage ( mV) Dro po ut Vo ltag e (m V) 1800 1700 1600 1500 1400 1300 1200 1100 1000 -50 -25 0 25 50 75 100 125 1800 1700 1600 1500 1400 100mA 40mA 1mA 1000 1 20 40 60 80 100 Temperature (o C) Load Current (mA) Load Regulation vs. Temperature 30 Output Voltage vs. Temperature 5.005 L oad Reg ulat ion (m V) 25 5.000 20 Ou tp ut Volt age ( V) 4.995 15 4.990 10 5 4.985 0 -50 -25 0 25 50 75 100 125 4.980 -100 -50 0 50 100 150 Temperature (o C) Temperature (oC) Short Circuit Current vs. Temperature 240 220 200 180 160 140 120 100 -50 Maximun Power dissipation vs. Ambient Temperature (SO-8 Package) 1 Sho rt C ircu it C urren t ( mA ) Pow er D issip atio n ( W) No Heatsink 0.1 R JA= 250 O C/W P D(MAX) to 25oC=0.6W 0 25 50 75 100 125 150 -25 0 25 50 75 100 125 Temperature (o C) Ambient Temperature (o C) 11 AME, Inc. AME78LXX Line Transient Response VO = 5.0V V OUT 2 100mA Positive Linear Regulator Load Transient Response VIN= 10V VOUT=5.0V Iload=40mA VIN from 10V to 11V 1 ILoad 1 V OUT 2 Ch1 1.00V Ch2 5.00mV T M 200uS A Ch1 394.400uS 360mV Ch1 25mA Ch2 10.0mV M 200uS A Ch1 T 400mV 0.00000uS Input Bias Current vs. Input Voltage 3.0 6 Output Voltage vs. Input Voltag In pu t B ias Cu rren t ( mA ) 2.5 5 2.0 Ou t pu t Vo ltag e ( V) 4 40mA 3 1mA 2 1.5 1.0 0.5 1 100mA 0.0 0 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 0 0.0 0.5 1.0 1.5 2.0 2.5 3.0 3.5 4.0 4.5 5.0 5.5 6.0 6.5 7.0 7.5 8.0 Input Voltage (V) Input Voltage (V) Input Bias Current vs. Input Voltage 2.80 2.70 Inp ut Bias C urr en t (m A) 2.60 2.50 2.40 2.30 2.20 2.10 2.00 -50 -25 0 25 50 75 100 125 Temperature (oC) 12 AME, Inc. AME78LXX 100mA Positive Linear Regulator n Package Dimension SO-8 SYMBOLS Top View Side View C MILLIMETERS MIN MAX 1.75 0.25 INCHES MIN 0.05315 MAX 0.0689 A A1 A2 B C D 1.35 0.10 0.00394 0.00984 0.058 REF 0.01299 0.02008 0.00748 0.00984 0.18898 0.19685 0.14961 0.15748 0.050 BSC 0.01575 0 o E 1.473 REF 0.33 0.19 4.80 3.80 0.51 0.25 5.00 4.00 D θ Front View 7o(4X) L E e L y θ 1.27 BSC 0.40 0 o 1.27 0.10 8 o 0.05 0.004 8 o A2 B SOT-89 Top View D D1 H POLISH A1 e A Side View SYMBOLS A A1 E MILLIMETERS MIN 1.39 INCHES MIN MAX MAX 1.60 0.05472 0.06299 0.0315REF 0.01378 0.01732 0.17283 0.1811 0.8REF 0.35 4.39 1.35 2.28 0.44 4.60 1.83 3.60 C D D1 C A1 0.05315 0.07205 0.08976 0.14173 0.1181REF 0.0276REF 0.0590REF S1 e Front View MATTE FINISH E e H S1 3.00REF 0.70REF 1.50REF A POLISH 13 AME, Inc. AME78LXX 100mA Positive Linear Regulator n Package Dimension TO-92-3 (bulk pack) Top View L e e1 SYMBOLS A b E D MILLIMETERS MIN 2.80 INCHES MIN 0.1102 MAX 4.95 MAX 0.1949 0.40REF 3.94REF 2.54REF 1.27REF 12.70 2.29 0.35 3.80 0.76 4.95 15.49 0.0157REF 0.1551REF 0.1000REF 0.0500REF 0.5000 0.6098 w e e1 L R W D E-PIN C 1/16 Side View A R b E 0.0902 0.0138 0.1496 0.0299 0.1949 Notes: 1. Package outline exclusive of any mold flashes dimension. 2. Package outline exclusive of burr dimension. 3. Lead pitch=2.54mm is bulk pack. 4. Lead pitch=5.08mm is tape pack. TO-92-3 (tape pack) Top View SYMBOLS L MILLIMETERS MIN MAX 4.95 INCHES MIN 0.1102 MAX 0.1949 A e e1 w D 2.80 b E e E-PIN C 1/16 0.40REF 2.40 3.94 0.0157REF 0.0945 0.1551 5.08REF 2.54REF 12.70 2.00 0.35 3.80 0.76 4.95 15.49 0.2REF 0.1REF 0.5000 0.6098 e1 L R W Side View A R b E 0.0787 0.0138 0.1496 0.0299 0.1949 D Notes: 1. Package outline exclusive of any mold flashes. 2. Package outline exclusive of burr dimension. 3. Lead pitch=2.54mm is bulk pack. 4. Lead pitch=5.08mm is tape pack. 14 www.ame.com.tw E-Mail: sales@ame.com.tw Life Support Policy: These products of AME, Inc. are not authorized for use as critical components in life-support devices or systems, without the express written approval of the president of AME, Inc. AME, Inc. reserves the right to make changes in the circuitry and specifications of its devices and advises its customers to obtain the latest version of relevant information. © AME, Inc. , June 2005 Document: BCD-DS78LXX-D Corporate Headquarter AME, Inc. 2F, 302 Rui-Guang Road, Nei-Hu District Taipei 114, Taiwan. Tel: 886 2 2627-8687 Fax: 886 2 2659-2989 U.S.A.(Subsidiary) Analog Microelectronics, Inc. 3100 De La Cruz Blvd., Suite 201 Santa Clara, CA. 95054-2046 Tel : (408) 988-2388 Fax: (408) 988-2489