PB24SM

PB24SM MOUNTING BOARD • Plug-compatible logic connections • Screw terminal barrier block for load connections • Resident pull-up resistors • 5 amp field-replaceable fuses (LITTLEFUSE #251005 or equivalent) • All even-numbered logic connections are logic ground • Input and output modules accepted interchangeably • Operate with 5, 15 or 24 volt logic supplies • Pin retaining system for “SM” series minature modules • LEDs indicate logic status MECHANICAL SPECIFICATIONS 13.0 (330,2) DIMENSIONS: INCHES (MILLIMETERS) TOLERANCE:+0.020 ( + 0,50) 0.5 (12,7) 4.0 (101,6) 4.0 (101,6) POWER TERMINAL STRIP (see notes 2,3,4) 1 2 3 4 5 6 7 8 9 1011 1213 141516 17 1819 202122 232425 2627 282930 3132 4.0 (101,6) REPLACEABLE 5 AMP LINE FUSE (24) (see note 6) 33 343536 3738 394041 4243 444546 4748 0.35 (8,9) 3.05 (77,5) SWAGED STANDOFF THRU HOLE 0.15 (3,8) DIA. (8) REPLACEABLE 1 AMP LOGIC SUPPLY FUSE (see note 5) 3.75 (95,3) CRYDOM DIGITAL I/O MODULES SOLD SEPERATELY 0 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 0.75 (19,1) + SIGNAL INPUT/OUTPUT 50 TRACE (0.1" CENTERS) MALE CARD EDGE (see note 1) 5.1 (129,5) 19 20 21 AC INPUT W DC INPUT B AC OUTPUT R DC OUTPUT Y 22 23 OPTIONAL HOLD DOWN BAR KIT (see note 7) LED STATUS INDICATOR (24) 1.88 (47,6) LOGIC SUPPLY TERMINAL STRIP (see note 2) 3.45 (87,6) PULL UP RESISTOR 3.3K OHM (24) 3.45 (67,6) NOTES: 1) MATING CONNECTOR IS BERG 66317-150 OR EQUIVALENT. SPECIFY SUFFIX 'C' FOR OPTIONAL 65823-093 OR EQUIVALENT MALE PIN CONNECTOR FOR PARALLEL-TO-THE-BOARD CABLE CONNECTION. SPECIFY SUFFIX 'V' FOR OPTIONAL CIRCUIT ASSEMBLY CA-50H-2B-SR OR EQUIVALENT MALE PIN CONNECTOR FOR PERPENDICULAR-TO-THE-BOARD CABLE CONNECTION. 2) 4-40 SCREW TERMINAL STRIPS ACCEPT WIRE SIZES FROM 26 TO 14 AWG. 3) OPTIONAL JUMPERS ARE AVAILABLE TO INTERCONNECT BARRIER STRIP ORDER 3 EACH "JM8". 4) PHOENIX MKD51.5 5.08mm SERIES (OR EQUIVALENT) SCREW TERMINAL BLOCKS STANDARD. SPECIFY SUFFIX "A" FOR BOARD-MOUNTED PHOENIX MSTBVA 1.5/16-G-5.08 (OR EQUIVALENT) MALE CONNECTOR. SPECIFY SUFFIX "B" FOR BOARD-MOUNTED PHOENIX MSTBVA 1.5/16-G-5.08 (OR EQUIVALENT) MALE CONNECTOR AND MATING PHOENIX MSTBVA 1.5/16-ST-5.08 (OR EQUIVALENT) FEMALE. SCREW-TERMINAL PLUG-IN CONNECTOR. 5) LITTLE FUSE 251001 OR EQUIVALENT. 6) LITTLE FUSE 251005 OR EQUIVALENT. 7) TWO HOLD-DOWN BAR KITS ARE AVAILABLE SEPARATELY. MODEL NO. 11.06.413 EMPLOYS A PLAIN ALUMINUM CHANNEL WHILE MODEL NO. 11.06.288 PROVIDES POCKETS IN THE CHANNEL FOR INDIVIDUAL MODULES. POWER BARRIER STRIP LOGIC SUPPLY BARRIER STRIP EDGE CONN BOTTOM LOGIC GRD + ALL EVEN PINS 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 5 AMP LINE FUSE (24) 1 2 3 4 5 1 2 3 4 5 1 2 3 4 5 1 2 3 4 5 1 2 3 4 5 1 2 3 4 5 1 2 3 4 5 1 2 3 4 5 1 2 3 4 5 1 2 3 4 5 1 2 3 4 5 1 2 3 4 5 1 2 3 4 5 1 2 3 4 5 1 2 3 4 5 1 2 3 4 5 1 2 3 4 5 1 2 3 4 5 1 2 3 4 5 1 2 3 4 5 1 2 3 4 5 1 2 3 4 5 1 2 3 4 5 1 2 3 4 5 I/O MODULE PIN SOCKET 1 5 9 13 SIGNAL INPUT/OUTPUT 17 50 TRACE (0.1" CENTERS) 21 MALE CARD EDGE 25 OR OPTIONAL PIN CONNECTOR 29 33 37 41 45 +LOGIC 49 PULL UP RESISTOR 3.3K OHM (24) 1 AMP LOGIC SUPPLY FUSE LED STATUS INDICATOR (24) Rev. 070808 DANGER / PELIGRO / DANGER /GEFAHR / PERICOLO / PERIGO HAZARD OF ELECTRIC SHOCK, EXPLOSION, OR ARC FLASH. x Disconnect all power before installing or working with this equipment. x Verify all connections and replace all covers before turning on power. Failure to follow these instructions will result in death or serious injury. RIESGO DE DESCARGA ELECTRICA O EXPLOSION. x Desconectar todos los suministros de energia a este equipo antes de trabajar con este equipo. x Verificar todas las conexiones y colocar todas las tapas antes de energizer el equipo. El incumplimiento de estas instrucciones puede provocar la muerte o lesiones serias. RISQUE DE DESCHARGE ELECTRIQUE OU EXPLOSION x Eteindre toutes les sources d'énergie de cet appareil avant de travailler dessus de cet appareil x Vérifier tous connections, et remettre tous couverts en olace avant de mettre sous De non-suivi de ces instructions provoquera la mort ou des lésions sérieuses sérieuses. GEFAHR EINES ELEKTRISCHE N SCHLAGES ODER EINER EXPLOSION. x Stellen Sie jeglichen Strom ab, der dieses Gerät versorgt, bevor Sie an dem Gerät Arbeiten durchführen x Vor dem Drehen auf Energie alle Anschlüsse überprüfen und alle Abdeckungen ersetzen. Unterlassung dieser Anweisungen können zum Tode oder zu schweren Verletzungen führen. RISCHIO DI SCOSSA ELETTRICA O DELL’ESPLOSI ONE. x Spenga tutta l'alimentazion e che fornisce questa apparecchiatu ra prima del lavorare a questa apparecchiatu ra x Verificare tutti i collegamenti e sostituire tutte le coperture prima della rotazione sull'alimentazi one L'omissione di seguire queste istruz ioni provocherà la morte o di lesioni serie RISCO DE DESCARGA ELÉTTRICA OU EXPLOSÃO x Desconectar o equipamento de toda á energia antes de instalar ou trabalhar com este equipamen to x Verificar todas as conexões e recolocar todas as tampas antes de religar o equipamento O não cumprimento destas instruções pode levar á morte ou lesões sérias. ANNEX - ENVIROMENTAL INFORMATION