MCETOOLV1

MCEToolV1 MCEToolV1 Isolation Box and IR Download Cable Description MCEToolV1 comprises of Isolation Box and IR Download Cable (IRCable). IRCable is used for programming the flash and one time programmable (OTP) memory of 300 Series, 100 Series, 500 Series and 99 Series Digital Control ICs. Isolation box provides UART and JTAG isolation while providing VPP for OTP programming. Following products are supported 300 Series 100 Series 99 Series 500 Series IRMCF/K311 IRMCF/K171/K172 IRMCF/K312 IRMCF188 IRMCF/K371 IRMCF143/K143 IRMCK099 IRMCF588 IRMCF/K343 IRMCF183 IRMCF/K371 IRMCK182 Features MCETOOLV1  Isolated signals from PC to target board  3.3V power supply current 100mA capability  Built-in VPP (6.75V) voltage output  IIC, JTAG, UART interface port  USB port power supply  Offline programming device  57600 baud rate UART support  iMotion DCIC programming support  UART Communication for motor tuning  LED indicators  Software support  USB/DB9 for UART  Compatible with iMotion Software Tools Product Summary     Isolated signal from PC to target board USB single supply IIC, JTAG and UART interface, opto-isolated FR4 based 1oz copper two-layer PCB Isolation Box IRCable 25mm x 65mm x90mm 1 www.irf.com © 2015 International Rectifier September 7, 2015 MCEToolV1 Safety Precautions In addition to the precautions listed throughout this manual, please read and understand the following statements regarding hazards associated with development system. ATTENTION: The input to the isolation box through the JTAG and UART is non- isolated and the ground potential of the drive connected which to target board is biased to a negative DC bus voltage potential. When measuring voltage waveform by oscilloscope, the scope ground needs to be isolated. Failure to do so may result in personal injury or death. Darkened display LEDs is not an indication that capacitors have discharged to safe voltage levels. ATTENTION: The target board contains dc bus capacitors which take time to discharge after removal of the main supply. Before working on drive system, wait three minutes for capacitors to discharge to safe voltage levels. Failure to do so may result in personal injury or death. Darkened display LEDs is not an indication that capacitors have discharged to safe voltage levels. ATTENTION: Only personnel familiar with the drive and associated machinery should plan or implement the installation, start-up, and subsequent maintenance of the system. Failure to comply may result in personal injury and/or equipment damage. ATTENTION: The surface temperatures of the drive may become hot, which may cause injury. ATTENTION: The target board connected through MCEToolV1 contains ESD (Electrostatic Discharge) sensitive parts and assemblies. Static control precautions are required when installing, testing, servicing or repairing this assembly. Component damage may result if ESD control procedures are not followed. If you are not familiar with static control procedures, 2 www.irf.com © 2015 International Rectifier September 7, 2015 MCEToolV1 reference applicable ESD protection handbook and guideline. ATTENTION: An incorrectly applied or installed drive can result in component damage or reduction in product life. Wiring or application errors such as under sizing the motor, supplying an incorrect or inadequate AC supply, or excessive ambient temperatures may result in system malfunction. ATTENTION: Remove and lock out power from the drive before you disconnect or reconnect wires or perform service. Wait three minutes after removing power to discharge the bus voltage. Do not attempt to service the drive until bus voltage has discharged to zero. Failure to do so may result in bodily injury or death. ATTENTION: Do not connect to power when the system is power on, Failure to do so may result in equipment damage or bodily injury. ATTENTION: Debris When Unpacking MCETOOLV1 is shipped with packing materials that need to be removed prior to installation. Failure to remove all debris and packing materials which are unnecessary for system installation may result in overheating or abnormal operating condition. 3 www.irf.com © 2015 International Rectifier September 7, 2015 MCEToolV1 Hardware Description A top view of the MCETOOLV1 incudes Isolation Box and IRCable is shown below. Both of these tools measure 25mm x 65mm x 90mm. VPP Switch UART2 USB to PC USB to PC J2:UART2 J4:UART1 J5: JTAG FS2 or IR Cable 4 www.irf.com UART DB9 to PC Download FPGA Connect to Isolation Box © 2015 International Rectifier September 7, 2015 MCEToolV1 Isolation Boundary MCEToolV1 is shipped along with ribbon and USB cables, to isolate the UART and JTAG interfaces, so that the user can connect their debugger and computer without isolating the computer. However, the user should keep in mind that most parts of the hardware have negative DC bus ground and it may be necessary to isolate the scope when waveforms are measured. System Installation and Operation The software installer can be downloaded from http://www.irf.com/design-tools/mce. Click on Software Updates, then on the 300/100 Series Design Kit Support download link. For information regarding the hardware and software operation, please refer to the IRMCx Download Cable user Manual found in the install directory. 5 www.irf.com © 2015 International Rectifier September 7, 2015 MCEToolV1 Connector definition Isolation Box J5 – JTAG Pin Name Description 1 GND Ground 2 TMS TMS (test mode) 3 TDO TDO (data output) 4 TDI TDI (data input) 5 TCK TCK (clock) 6 RESET Reset to IC 7 +3.3V On board 3,3V power (see Specification for max current) 8 VPP OTP programming voltage supplement J4 – UART1 Pin Name Description 1 +3.3V On board 3.3V supply 2 TXD1 Input, Receive data to IRMCx Device 3 RXD1 Output, Transmit data from IRMCx Device 4 GND Ground 6 www.irf.com © 2015 International Rectifier September 7, 2015 MCEToolV1 J2 – UART2 Pin Name Description 1 +3.3V On board 3.3V supply 2 TXD1 Input, Receive data to IRMCx Device 3 RXD1 Output, Transmit data from IRMCx Device 4 GND Ground Pin Name Description 1 5V On board 5V supply 2 SDA Input, Receive/Transmit data to F300 boot EEPROM 3 SCL Output, Transmit clock to F300 boot EEPROM 4 GND Ground J7 – IIC IRCable JP1 – IIC Pin Name Description 1 3.3V On board 3.3V supply 2 IICSDA Input, Receive/Transmit data to F300 boot EEPROM 3 IICSCL Output, Transmit clock to F300 boot EEPROM 4 GND Ground 7 www.irf.com © 2015 International Rectifier September 7, 2015 MCEToolV1 Specifications Parameters Values Conditions 256 kbps MCEProgrammer support 57.6 kbps MCEDesigner support 57.6 kbps MCEDesigner support 3.3V Typical 57.6 kbps, single ended 3.3V Interface with FS2 or IRCable 3.3V Typical 100kbps 3.3V Current supply 100mA Can supply target board 3.3V within this range VPP current supply 50mA Host interface (Isolated) USB to UART Programming USB to UART Debugging DB9 Debugging Host interface (Non isolated) UART(TXD, RXD) JTAG interface TMS, TDI, TCK, TDO IIC SDA,SCL Current Protection Isolator IC 3.3V reverse connection Power Device USB 5V On board power supply 3.3V 3.3V+/-5%, Max 50mA Box Material Plastic Dimension 25mm x 65mm x 90mm System environment Ambient temperature 8 www.irf.com 0 to 70C 95% RH max. (Non-condensing) © 2015 International Rectifier September 7, 2015 MCEToolV1 Revision History Data and Specifications are subject to change without notice IR WORLD HEADQUARTERS: 233 Kansas St., El Segundo, California 90245, USA Tel: (310) 252-7105 TAC Fax: (310) 252-7903 Visit us at www.irf.com for sales contact information 9 www.irf.com © 2015 International Rectifier September 7, 2015 3 4 5 6 COU3 U3 COC4 C4 COU2 U2 100uF,16V 1 2 PISW101 PIU202 5VIN+ 9VOUT+ PIC401 COU1 U1 5V_USB 7 PIU107 REGIN COC3 C3 COC1 C1 PIC102 PIC101 PIC302 PIC301 6 PIU106 104 PIC201 VBUS 2 D- PIJ102 3 D+ PIJ103 4 GND PIJ104 5 M. Hole PIJ105 6 M. Hole PIJ106PIR4101 PIR4302 COR43 R43 PIR4301 PIR4202 PIR4201 COR42 R42 22R 22R PIR4102 PIC4401 PIC4402 COR41 R41 1M VBUS 5 PIU105 D- 4 PIU104 D+ PID202 PID203 PID204 COC5 C5 DNI 5Vin- 9VOUT- 3 PIU203 PIC701 COC7 C7 PIC702 100uF,25V PIC4302 PIC4301 104 6 PIU306 2 RI PIU102 1 DCD PIU101 28 DTR PIU1028 27 DSR PIU1027 24 RTS PIU1024 23 CTS PIU1023 COLED2 LED2 +3.3V RXD2 PILED20K PILED20A PIC1302 COC13 C13 104 PIC1301 PIR802 COR8 R8 PIR801 2K COISO1 ISO1 1 VDD1 2 PIISO102 VOA 3 PIISO103 VIB 4 PIISO104 GND1 PIISO101 26 TXD PIU1026 25 PIU1025 8 VDD2 7 VIA PIISO107 6 VOB PIISO106 5 GND2 PIISO105 PIISO108 104 COLED3 TXD2 LED3 PIR902 PILED30K PILED30A PIR1101 COR9 R9 47R PIR1102 PIR1001 COR10 R10 47R COC15 C15 100p PIC1602 PIC1601 COR11 R11 1K PIJ201 NLTXD2 TXD2 NLRXD2 RXD2 PIR901 PIR1002 PIC1502 PIC1501 ADUM1201BR COU5 U5 220uF,16V PIC2301 PIC2302 COD4 D4 1N4148 7 PIU507 PIC2502 PIC2501 5V_232 V+ VCC V- GND COC25 C25 PIR2002 PIC2402 PIC2401 COR20 R20 PID10 A PID10 K COC24 C24 10R 104 PIR2101 334 5.1V D10 COD10 BZT52C5V1-7-F COR21 R21 10R PIR2102 1 PIU501 PID501 PID502 COD5 D5 1N4148 PID601 C1+ 15 PIU5015 14 PIU5014 2 PIU502 EN 12 PIU5012 FORCEON C1- 4 PIU504 16 PIU5016 FORCEOFF C2+ PIU505 10 PIU5010 INVALID C2- 6 PIU506 DIN PIU5011 ROUT PIU509 13 PIU5013 PIJ202 PIJ203 PIJ204 COC16 C16 100p 1 2 3 4 PPIR301IR201 COR3 R3 PIR4401 PIC801 PIR4601 COR46 PIC802 R46 COD3 D3 8 PIU508 DOUT RIN 5 PIR1401 10R PIR1402 NLRST10I RST1_I DNI VCC GND GND GND GND GND COC28 C28 3K PIC2802 104 PILED60A COLED6 LED6 PILED60K UART_Vcc Blue PIC2601 COC26 C26 PIC2602 PILED50A COLED5 LED5 PILED50K RXD1 COC27 C27 334 PIR2202 COR22 R22 PIR2201 PIC2901 105 RED(Hight light) LED7 COLED7 TXD1 +3.3V COISO3 ISO3 1 VDD1 2 PIISO302 VOA 3 PIISO303 VIB 4 PIISO304 GND1 8 VDD2 7 VIA PIISO307 6 VOB PIISO306 5 GND2 PIISO305 PIISO301 9 PITP701 COTP7 TP7 PIC2902 RED (Hight light) 2K 11 COC29 C29 5V_232 473 PIC2701 PIC2702 MAX3221CDBR PID602 PIC2801 PIR2301 PIISO308 PIC30 2 PIC30 1 PILED70K PILED70A COC30 C30 COR26 R26 1K PIR2602 COR24 R24 47R 104 PIR2402 COC39 C39 100p PIR2601 PIR2501 1 TXD1 NLTXD1PIJ402 NLRXD1PIJ403 2 RXD1 3 PIJ404 4 COC40 C40 100p COR25 PIC40 2 R25 47R PIC40 1 GND_I 1N4148 R35 COR36 R36 C37 5V_I2C COR35 COC37 4.7k 4.7k 104 PIJ60MH2 J6 COJ6 PIR3501 PIR3601 PIR3502 PIR3602 PIC3702 PIC3701 COJ7 J7 DB9RF RS-232 1 2 3 4 D PIJ701 PIJ702 PIJ703 PIJ704 I2C_PICKit2 SDA_IN NLSDA0IN SCL_IN NLSCL0IN COISO6 ISO6 DNI 1 PIISO601 VDD1 VDD2 2 PIISO602 SDA1 SDA2 3 PIISO603 SCL1 SCL2 4 PIISO604 GND1 GND2 8 PIISO608 7 PIISO607 6 PIISO606 5 PIISO605 (ADUM1251ARZ) I2C isolation 2 3 5 PIU405 6 PIU406 270R, 1% PIR302 PIR4602DNC FLAG ADJ GND GND PIR502 COR5 R5 4 PIU404 GND 7 PIU407 GND 8 PIU408 PIR501 +3.3V COTP2 TP2 PID101 PID102 PITP201 PIR702 COR7BAV19W R7 510R, 1% 1K PIC10 1 PIC10 2 PIR4501 PILED10A 1 A 3.3V PIC1 01 PIC1 02 PIR701 PIR601 COR6 R6 PIR4502 PIR602240R, 1% COR45 R45 COC8 COC9 C8 C9 100uF,16V 100uF,16V 6.7V-6.8V COC11 C11 100uF,16V PILED10K COLED1 LED1 VPP LED1_1(3mm, Flash RED) 5.1K, 1% COC38 C38 COJ8 J8 104 SDA NLSDA SCL NLSCL PIJ801 PIJ802 PIJ803 PIJ804 PIJ805 PID802 PID801 COD8 D8 1 2 3 4 5 I2C_Targert 4 6 4 PIJ306 COR12 R12 PIR1201 PIJ304 8 PIJ308 COISO2DNI ISO2 1 PIISO201 2 PIISO202 DBRST RESET TMS TDI TCK TDO 3 4 PIISO204 PIISO203 PIR1202 1k PIC1702 PIC1701 10 15 17 PIJ3017 PIJ3010 PIJ3015 COC18 C18 4.7k PITP301 7 PIISO207 6 5 PIR1502 PPIQ10B IR1601 1 VDD1 PIISO401 2 VOA PIISO402 3 VIB PIISO403 4 GND1 PIISO404 LED4 VCC Blue 1K PIR1902 COR16 R16 10k 1k PIQ10E +3.3V COC22 C22 PIR1602 COC32 C32 104 NLDBRST DBRST NLRST2DB RST2DB COR18 R18 PIR1801 PIR1802 4.7k PIC2202 PIC2201 PIU605 10uF,10V 4PIU604 COU6 U6 SN74LVC1G14DCK PIU603 PIS104 PIS103 COTP5 TP5 COS1 S1 KT11P4JM34LFS 2 PIU602 COC34PIC3401 C34 103 PIC3402 PIS102 PIS10 PITP501 COTP6 TP6 PITP601 +3.3V PIR2901 PIR30 1 4.7k 4.7k 4.7k PIR2902 PIR30 2 COISO5 ISO5 1 PIISO501 VDD1 2 PIISO502 GND1 3 PIISO503 VIA 4 PIISO504 VIB 5 PIISO505 VIC 6 PIISO506 VOD 7 PIISO507 VE1 8 PIISO508 GND1 104PIC3101 NLTMS0I TMS_I NLTDI0I TDI_I NLTCK0I TCK_I TDO_I NLTDO0I PIR3801 COR38 R38 COJ9 J9 0 PIR3901 DNI PIR3902 (0) PIR3802 COTP4 TP4 COR39 R39 RESET VDD2 GND2 VOA VOB VOC VID VE2 GND2 16 PIISO5016 15 PIISO5015 14 PIISO5014 13 PIISO5013 12 PIISO5012 11 PIISO5011 10 PIISO5010 9 PIISO509 PIC3 02 PIC3 01 PIR3101 PIR3201 C PIR3 01 COR31 COR32 COR33 R31 R32 R33 COC33 C33 4.7k 4.7k 104 PIR3102 PIR3202 4.7k R37 COR37 PIR3701 PIR3702 1k PIJ9010 PID1201 PID1202 5 PIC4102 PIC4101 COD12 D12 DNI COJ5 J5 +6.75V JTAG PIR3 02 NLTMS TMS NLTDI TDI NLTCK TCK TDO NLTDO ADUM1401CRW +3.3V PIC3502 PIC3501 COR34 PIJ508 R34 PIR3401 PIR3402 PIJ507 RST 1R PIJ506 COC35 C35 TCK PIJ505 104 PIC3602 TDI PIJ504 C36 COC36 TDO PIJ503 PIC3601 104 TMS PIJ502 PIJ501 8 7 6 5 4 3 2 1 PITP401 To IRMCK/F300/100 Please set in FS2 console as following to have right RESET (ISO4 used as default) : ResetAsserted=High ResetNegated=Low 5V_I 1 GND COR28 R28 COR29 R29 COR30 R30 COC31 C31PIC3102 PIR2802 1 GND 5V_I PIR2801 B PIR1901 COR19 R19 COQ1 Q1 MMBT3904LT1 COR15 R15 PIR1501 PILED40K NLRST RST PIQ10C PIISO205 PIC3202 PIC3201 PILED40A COLED4 1 RST 104 ADUM1201BR 1N4007 2510-6002UB PID1 01 COD11 D11 11DQ10PID1 02 5V_USB PIR1702 PIISO206 COISO4 ISO4 8 PIISO408 VDD2 7 PIISO407 VIA 6 PIISO406 VOB 5 PIISO405 GND2 PIR1701 COC21 C21 +3.3V NLDBRST0I DBRST_I NLRST2DB0I RST2DB_I PIR2701 COR27 R27 2 PIJ302 3 PIJ303 14 PIJ3014 12 PIJ3012 16 PIJ3016 13 PIJ3013 5 PIJ905 9 PIJ909 1 PIJ901 3 PIJ903 8 PIJ908 6 PIJ906 4 PIJ904 7 PIJ907 2 PIJ902 10 8 PIISO208 5V_I COC20 C20 PIC20 2 PIC20 1 PIR2702 VDD2 SDA2 SCL2 GND2 COTP3 TP3 COR17 R17 DNI (220R) 10uF,10V 104 5 7 PIJ307 18 PIJ3018 19 PIJ3019 20 PIJ3020 VDD1 SDA1 SCL1 GND1 PIC2102 PIC2101 (ADUM1251ARZ) PIC1801 COC17 C17 104 PIC1802 PIJ305 +3.3V NLRST1 RST1 +3.3V PIC1902 COC19 C19 104 PIC1901 5V_I 1 N/C PIJ301 9 N/C PIJ309 11 N/C PIJ3011 TMS TDI TCK TDO RESET VIO VCC TrigOut GND GND +3.3V PIC3802 PIC3801 COJ4 J4 UART PORT1 PIJ401 PIR2401 PIR2502 PIC3901 PIC3902 ADUM1201BR PIC901 PIC902 COD1 D1 100uF,10V JTAG isolation BAV19W UART PORT2 COR23 R23 PIR2302 1 PIU401 COR14 5V_I R14 COR13 R13 4.7k PIR1302 PID301 PID302 PIR1301 5V_USB COJ2 J2 COD6 D6 1 GND 8 PIU308 270K PIR402 COC10 C10 1.24 x ( 1 + 510/229) = 4.0V 2 3 PIU402 VIN VOUT PIU403 COD9 D9 (AMP104549-2 ) 3 PIC1201 PIC1202 PIU503 COC23 C23 MH2 7 PIU307 COR2 R2 1 SP0503BAHTG 5V_232 1 PIJ601 2 PIJ602 3 PIJ603 4 PIJ604 5 PIJ605 6 PIJ606 7 PIJ607 8 PIJ608 9 PIJ609 GND GND PIR4402 COR44 R44 BAV19W PID901 PID902 5V_232 RS-232 DRIVERS / RECEIVERS 1 5V_USB MH1 GND 10R 1% PIR202 COJ3 J3 COD2 D2 334 PIJ60MH1 ADJ COR4 R4 PITP101 PIR401 Green (Hight light) PIC1402 PIC1401 COC14 C14 COC12 C12 C 5 PIU305 FLAG 4 1.2K, PIU304 6.75V CP2102 1 PID201 PIR2001 1 PIU301 S05B09-2W 104 PID401 PID402 PIC4201 COC42 C42 PIC4202 100uF,16V Green (Hight light) RXD COC44 C44 1 PIU201 TS-4AS-CQ-H PIR101 4 67068-8000 8 PIU108 3 B 100uF,16V COR40 1 R40PIR4001 1R PIJ101 PIR4002 2 (12MHz) COC2 C2 5V_USB COR1 R1 PIR102 PIC602 PIC601 11 SUSPEND PIU1011 3 PIU103 GND 29 PIU1029 GND 30 PIU1030 GND PIC202 USB to 232 9 PIU109 12 SUSPEND PIU1012 VDD 104 COJ1 J1 RST COSW1 SW1 PIC502 PIC402 PIC501 +6.75V 4 3 3 PISW103 C43 MURS160 COC43 104 PID701 PID702 +9V COU4 U4 IRU1208CS 2 1 2 PISW102 A COC6 C6 104 4 PIU204 8 5 5V_USB COTP1 TP1 +6.75V IRU1208CS 1.24 x ( 1 + 1.2K/270) = 6.75V 2 3 PIU302 VIN VOUT PIU303 COD7 D7 7 3 2 1 1 If use ISO2 for RESET isolation (ISO4 MUST be removed, and install R39 & R17), Please set: Title ResetAsserted=Low ResetNegated=High IRMCS-ISO-V3.1 C41 COC41 0.1uF,16V Please m ake sure LED4 & LED6 are light, which m eans both sides of isolation board are powered. ISO2 &ISO4 DNI Size Number 6 R3_1 1/1 A2 Date: File: (BAV19W) D Revision 2015/8/21 Sheet of F:\Work\..\IRMCS-ISO-V3.1_20110627.Sch Drawn By: 7 8 COTP1 COC43 COC42 PAD702 PATP101 PAC4301 PAC4202 PAR302 PAR4 01 PAC4201 PAR4402 PAR301 PAU301 PAU302 PAU303 PAU304 PAR202 PAR201 COR3 COR44PAC4302 COLED3 COC8 PAR4601 PALED30K PAR4602 COR46PAC801 PALED30A PAC802 PAU308 PAD701 COR2 PAR401PAU307 PAU306 PAU305 PAR402 PAU408 PAR2602 PAU401 PAU407 PAU402 PAU406 PAU405 PAC1602 PAC1601 PAR1002 COR26 PAR1001 COLED7 COC4 COR1 PAU404 PAD102 PAR4001 PAR4002 PAJ101 PAJ104 PASW101 PASW102 PASW103 PAJ102 PAJ103 PAJ105 PAR102 PAD201 PAD202 PAC302 COC1 PAC301 PAR4301 PAR4302COR43 PAR4201 PAR4202COR42 PAC102 PAC201 PAD401 COD4 PAC101 COC2 PAU102 PAU1023PAU1024PAU1025PAU1026PAU1P0A2U71028 PAC202 PAD402 PAD10 A COR20 PALED20K COU1 PAU1015 PAU1030 PAU1016 PAU1017 COR8 PAU1018 PAU1019 PAU104 PAU103 PAU1020 PALED20A PAR802 PAU1021 PAU102 PAU101 PAU1029 PAR801 PAISO108 PAISO305 PAISO306 PAISO304 PAISO303 PAISO307 PAISO302 PAU509 PAU5010 PAU5011 PAU5012 PAS102 PAS101 PAC3501 COJ5 PAR3401 PAC3502 PAR3402 COC35 PAISO201 PAISO207 PAISO206 PAISO202 PAISO203 PAISO205 PAISO204 COISO2 PAISO509 COR34 PAJ508 COR33 PAISO507 COR28 PAISO5011 PAISO506 PAISO5012 PAISO505 PAR3102 PAR3101 COR31 PAISO5013 COR32 PAR3202 PAR3201 PAR3302 PAC3301PAISO5015 PAR3301 PAC3302PAISO5016 COC34 PAJ506 PATP501 PAC3401 PAC3402 PAR1902 PAC1702 PAC1801 COR29 PAC1701COJ3 COR30 PAC3101 PAC3102 PAC1802 PAISO405 PAJ3020 PAJ3019 PAJ60MH2 COJ9 PAJ3018 PAJ30MH3PAJ3015 PAJ3016 PAJ3014 PAJ3017 PAJ3013 PAR1602 COR16 PAD602 COD6 COC18 PAU605 PAJ805 PAJ804 PAJ803 PAJ802 PAJ801 COJ8 COR19 PAD601 COC17 PAC2001 PAJ3012 PAJ3011 PAC3201PAISO403 COC20 PAISO406 COR12 PAJ309 PCOR15 AC2 02 PAISO402 COC32 PAISO407 PAC2002 PAR2701 PAR1202 PAJ3010 PAJ308 PAJ307 PAR1802 PAR1801 PAR1501 PAC3202PAISO401 COISO6PAISO408 PAR2702 COR27 PAJ305 COQ1 PAQ10C COR38 PAPAR1502 C2 01 PAISO605COISO4PAISO604 PAR1201 PAJ306 PAJ30MH1 PAU602 PAJ304 PAJ303 PAU603 PAU604 PAQ10B COC22 PAISO606 PAR3801 PAR3802 PAISO603 PAJ301 PALED40K PAQ10ECOR18 PAC3701 PAJ302 PAC3801 PAISO607 PAISO602 PAR1901 PAR1601 COC38 COC37 COU6 PAISO601 PAC3702 PAC3802PAISO608 PALED40A COJ7 PAU601 COLED4 COC31 PAISO404 PAJ609 PAR3002 PAR3001 PAISO503 PAISO502 PAISO501 COD11 PAJ608 PAJ605 COLED6 PAR2802 PAR2801 PAR2902 PAR2901 PAISO504 COC33 PAU502 PAU50 PAU501 PAISO508 PAISO5010 COTP5 PAISO5014 PAJ507 PAJ505 PAJ504 PAJ503 PAJ502 PAJ501 PAISO208 PAJ606 PAJ607 PAJ603 PAJ604 PAU506 PAU505 PAU503 PAU5015 PAU5016 PAD1202 PAJ601 PAU504 PAU5014 PAD1201 PAD1102 PAD1101 PAJ602 PAU508 PAU507 PAU5013 PAD802 PAD801 COD10 COC44 COD12 PAJ60MH1 PAU107 PAU105 PAU106 PALED70A PAR901 PAR902 PAC1402 PAC2302 PAR2001 PAD10 K PAC2401 PAC1501 PAC1502 COD3 PAD302 PAD301 COC23 COC24 COR9 COISO1 PAJ404 PALED70K PAC2402PAC2301 PAR2002 PAR2101 PAC4002 PAC4001COC40 COC15 COD9COR13 PAD902 PAD901 COU5 COR22 COISO3 PAJ403 COTP2 COR21 COC27PAR2102 COR25 COC29 COTP3 PAR2501 PAR2502 PAR2201 PAC2502 PAC2501 COC25 PAC2702 COR24PAC3001 PAJ402 PAC2901 PAR1301 PAD502 PAC2801 PAR2202 COC39 PAR2401 PAR2402COC30 PAC1201 PAC1202 COC12 PAC2701 PAR1302 PAC2802 PAC3002 PAC2902COC28 PAJ401 PATP201 PAISO301 PAC2602 PAC3901 PAC3902 PATP301 PAISO308 COTP4 PAD501 COR14 COR23 COTP6 COC21 COC19 COTP7 PAC2601 COD8 PAR1401 PAR3901 PAR2302 PAR2301 PAC1902 COC26COD5 PAS104 PAS103COR17 PAR1702 PAR1701 PAC2102 PAR1402 PAR3902 PATP401 PALED60K PALED50K COJ6 COS1 PAC2101 PAC1901 COR39 PAC3601 PAC3602 COC36 PATP601 PALED60A PALED50A COLED5 PATP701 COISO5 COJ4 PAR4101 PAC4401 PAR4102 PAC4402 COR41 COC3 COLED2 COD1PAISO105 PAJ106 COR40 PAU10 4PAU1013PAU10 2PAU101 PAU10 PAU109PAU108 PAD101 COC16 COR10 PAISO104 PAISO103 PAC1301 COC13 PAISO102 PAC1302 PAISO101 PAC1401PAISO106 COC14 PAISO107 COJ1 PASW106 COLED1PAU201 PAR4502 PAR4501 COR45 COC10 PAC1002 PAC1001 PAC1102 COSW1 PAC501 PAC502 COC5 COU2 PAC402 PAC401 COD2 PAR101 PAD204 PAD203 PAR601 PAR602 PAR702COR6 PAR701 COR7 PAR501 PAU403 PAR502 COR5 COC11 PAC1101 PALED10A PAC901 PAC902 COU4 COR4 COR11 PAR2601 COC9 COU3 PAR1102 PAR1101 COJ2 PAJ204 PAJ203 PAJ202 PAJ201 PAC601 PAC602COC7COC6 PAU204 PAC702 PAC701 PAU203 COD7 PALED10K PAU202 PAJ704 PAJ703 PAJ702 PAJ701 PAR3602 PAR3502 PAR3601 PAR3501 COR36 COR35 PAJ901 PAJ902 PAC4101 PAC4102 COC41 PAJ903 PAJ904 PAJ905 PAJ906 PAR3701 PAR3702 COR37 PAJ907 PAJ908 PAJ909 PAJ9010 Comment 104 Description Designator Footprint LibRef Quantity 22 100uF,25V C1, C3, C5, C6, C0805 C13, C14, C17, C19, C20, C21, C24, C28, C30, C31, C32, C33, C35, C36, C37, C38, C43, C44 C2, C4, C8, C9, C1/2 C11, C42 C7 C1/2A 100uF,10V C10 C1/2 1 334 C12, C25, C27 100p 10uF,10V C15, C16, C40 C18, C22 220uF,16V 473 100uF,16V 6 1 C0805 3 C39, C0805 4 C3216 2 C23 C1/2A 1 C26 C0805 1 105 C29 C0805 1 103 C34 C0805 1 0.1uF,16V C41 C0805 1 BAV19W D1, D3, D9 D1206 3 SP0503BAHTG D2 SOT-143 1 1N4148 D4, D5, D6 D1206 3 MURS160 D7 SMA/KA 1 1N4007 D8 SMA/KA 1 BZT52C5V1-7-F D10 SOD-123 1 11DQ10 D11 SMA/KA 1 DNI D12 D1206 1 ADUM1201BR ISO1, ISO3, ISO4 SO-8 3 DNI ISO2, ISO6 SO-8 2 ADUM1401CRW ISO5 SO-16W 1 67068-8000 J1 USB_CONN 1 UART PORT2 J2 A2501W VR-4P 1 DNI J3 1 UART PORT1 J4 CONN_AMP1045 49-2 A2501W VR-4P JTAG J5 A2501W VR-8P 1 DB9RF RS-232 J6 DB-9RA/F 1 I2C_PICKit2 J7 A2501W VR-4P 1 I2C_Targert J8 A2501W VR-5P 1 2510-6002UB J9 1 VPP LED1 25106002UB_W O LED_3MM_1 RXD2 LED2 LED_3MM_1 1 TXD2 LED3 LED_3MM_1 1 VCC LED4 LED 1 RXD1 LED5 LED_3MM_1 1 UART_Vcc LED6 LED_3MM_1 1 TXD1 LED7 LED_3MM_1 1 MMBT3904LT1 Q1 SOT23-BCE 1 DNI R1, R17, R39 R0805 3 1.2K, 1% R2 R0805 1 270R, 1% R3 R0805 1 10R R4 R2512 1 510R, 1% R5 R0805 1 240R, 1% R6 R0805 1 1K R7, R11, R15, R19, R37 R12, R0805 R26, 7 1 1 2K R8, R22 R0805 2 47R R9, R10, R24, R0805 R25 R13, R20, R21 0805 4 11 10k R14, R18, R28, R29, R31, R32, R35, R36 R16 R0805 1 3K R23 R0805 1 1R R34, R40 R0805 2 0 R38 R0805 1 1M R41 R0805 1 22R R42, R43 R0805 2 270K R44 R0805 1 5.1K, 1% R45 R0805 1 DNC R46 R0805 1 KT11P4JM34LFS S1 KT11P3JM 1 TS-4AS-CQ-H SW 1 SW _W O 1 +6.75V TP1 TP_5002 1 3.3V TP2 TP_5002 1 RST TP3 TP_5002 1 RESET TP4 TP_5002 1 GND TP5, TP6 TP_5002 2 GND_I TP7 TP_5002 1 CP2102 U1 QFN-28 1 S05B09-2W U2 DC-DC5S9 1 IRU1208CS U3, U4 SO-8 2 MAX3221CDBR U5 SSOP-16 1 SN74LVC1G14DC K U6 DCK 1 10R 4.7k R27, R0805 R30, R33, 3 2 3 4 5 6 7 +3.3V +1.2VD VCCO I2C EEPROM for PARAMETER (SOP-8) PIC401 PIC501 PIC801 PIC10 1 PIC1 01 PIC1201 PIC1301 PIC1401 PIC1501 PIC1601 PIC1701 PIC1801 PIC1901 PIC20 1 PIC2 01 PIC2301 PIC2401 PIC2501 PIC2601 COC4 COC5 COC8 COC10 COC11 COC12 COC13 COC14 COC15 COC16 COC17 COC18 COC19 COC20 COC22 COC23 COC24 COC25 COC26 C4 C5 C8 C10 C11 C12 C13 C14 C15 C16 C17 C18 C19 C20 C22 C23 C24 C25 C26 PIC402 47nF PIC502 0.47nF PIC802 47nF PIC10 2 47nF PIC1 02 0.47nF PIC1202 47nF PIC1302 47nF PIC1402 47nF PIC1502 47nF PIC1602 47nF PIC1702 0.47uF PIC1802 0.47uF PIC1902 0.47uF PIC20 2 0.47uF PIC2 04.7uF 2 PIC2304.7uF 2 PIC24022uF, 2 16VPIC2502 0.47uF PIC2602 47nF AT24C02 1 PIU301 2 PIU302 3 PIU303 +2.5VD 7 PIU607 REGIN COC51 C51 COC49 C49 PIC4902 PIC4901 6 PIC5102 PIC5101 104 PIU606 68 PIR1902 68 PIR2002 (12MHz) COR391R 1 R39 PIR3902 PIJ201 PIR3901 SUSPEND PIU6011 RI DCD DTR DSR RTS CTS PIU602 1 PIU601 28 27 PIU6027 24 PIU6024 23 PIU6023 NLUART0DTR UART_DTR NLUART0DSR UART_DSR NLUART0RTS UART_RTS NLUART0CTS UART_CTS PIR4001 22R 5 COR40 R40 PIU605 TXD 26 PIU6026 NLTX TX 22R RXD PIU6025 25 NLRX RX PID802 PID803 PIR3802 R38 PIC5702 COC57 COR38 C57 1M 1 PIC5701 103 PID801 PIR3801 D- PID804 R23 COR23 COD2 D2 Ready led PID20K PID20A PIR2301 D4 COD4 PID40K PIR2302 PIJP?02 PIJP?03 PIJP?04 COR24 R24 PID40A PIR2401 PIR2402 TX RX UART_RI UART_DCD UART_DTR UART_DSR UART_RTS UART_CTS UART_REST 4 HEADER COC61 C61 0.1uF 1 IC_TCKPIU802 2 NLIC0TCK IC_TDO 3 NLIC0TDO PIU803 4 IC_TMSPIU804 NLIC0TMS NLJ0RESET J_RESET 5 PIU805 NLIC0TDI IC_TDIPIU806 6 ICVPP_ONPIU807 7 NLICVPP0ON 8 PIU808 9 F3SCL PIU809 NLF3SCL NLF3SDA F3SDA PIU8010 10 11 PIU8011 12 PIU8012 NLLED1 LED1 1 2 3 4 PIJP?01 IICSCL IICSDA +3.3V PIU801 390 BLUE LED Error led NLUART0RI UART_RI NLUART0DCD UART_DCD COU8 U8 State LED 1PIU401 2PIU402 4PIU404 5PIU405 6PIU406 7PIU407 8PIU408 10PIU4010 11PIU4011 12PIU4012 13PIU4013 14PIU4014 15PIU4015 17PIU4017 18PIU4018 20PIU4020 21PIU4021 COJP? JP? USB to UART SP0503BAHTG C PIU6028 D+ D8 COD8 36PIU4036 63PIU4063 105PIU40105 108PIU40108 112PIU40112 113PIU40113 116PIU40116 11 2 NLLED2 LED2 PIC6101 PIC6102 NC A0 A1 A2 A3 A4 A5 A6 A7 A8 A9 GND VCC #BE B0 B1 B2 B3 B4 B5 B6 B7 B8 B9 24 23 PIU8023 22 PIU8022 21 PIU8021 20 PIU8020 19 PIU8019 18 PIU8018 17 PIU8017 16 PIU8016 15 PIU8015 14 PIU8014 13 PIU8013 PIU8024 NLLEDK LEDK PIR501 R5 COR5 TCK NLTCK TDO NLTDO NLTMS TMS NLRST RST 23PIU4023 24PIU4024 25 PIU4025 26PIU4026 27PIU4027 28PIU4028 30PIU4030 31 LEDF NLLEDF PIR502 4.7K NLLED1x LED1x TDI NLTDI LED3x NLLED3x VPP_ON NLVPP0ON PIU4031 NLIICSCL IICSCL NLIICSDA IICSDA F3SCL F3SDA IDTQS3861-TSSOP24 D6 COD6 PID60K COR25 R25 PID60A PIR2501 PIR2502 NLLED3 LED3 DNP SW2 COSW2 PISW202 R46 100 COR46 PIR4601 PIR4602 10K PIR4302 PIC5901 PIR4701 PIR4402 R44 PIC60 2 COR44 C60 COC60 10K PIC60 1 103 PIR4401 PIR5201 PIR4702 R48 COR48 PISW302 PIR4801 R49 COR49 PISW301 PISW303 100 PIR5102 100 PIR5202 PIR4901 TMS TDI TCK TDO RESET VIO VCC TrigOut GND GND LED1 SW1 NLGCLK7 GCLK7 SRAM_D5 NLSRAM0D5 SRAM_A13 NLSRAM0A13 SRAM_A10 NLSRAM0A10 IO_L31N_5/D4 IO_L01P_7/VRN_7 IO_L01N_7/VRP_7 IO_VREF_7 IO_L20P_7 IO_L20N_7 IO_L21P_7 IO_L21N_7 IO_L22P_7 IO_L22N_7 IO_L23P_7 IO_L23N_7 IO_L24P_7 IO_L24N_7 IO_L40P_7 IO_L40N_7/VREF_7 IO_L40P_6/VREF_6 IO_L40N_6 SW1 COSW1 R45 COR45 PIR4502 100 PIR4501 PISW102 PISW101 141 PIU40141 140 PIU40140 137PIU40137 135PIU40135 132 PIU40132 131 PIU40131 130 PIU40130 129 PIU40129 128PIU40128 127 PIU40127 125 PIU40125 124 PIU40124 123 PIU40123 122 PIU40122 119 PIU40119 118 PIU40118 104 PIU40104 Button & switch R50 COR50 PISW103 A9 PIR5001 PIR5002 68 PIU4068 69 PIU4069 70 PIU4070 73 PIU4073 74 PIU4074 76 PIU4076 77 PIU4077 78 PIU4078 IO_L31P_5/GCLK2 +3.3V IO_L31N_5/GCLK3 2 3 RUN1 VIN PGND COR35 R35 LTC3407-11PIN 620K PIC5 01 SW2 NLSRAM0D1 SRAM_D1 10uF 6 PIU1406 COL3 L3 10uH NL0303V +3.3V PIR2202R22 COR22 PIL301 7 PIL302 PIU1407 MODE/SYIC SW2 PIR3002 PIC5301 PIC5302 10 PIR3001 PIU14010 COR30 R30 910K PIR3202 COC53 C53 10uF VFB2 COR32 R32 PIR3401 COR34 R34 100K B 8 #POR PIU1408 SW1 PIU1404 VFB1 PIU1401 4 PIR3201 1 PIR3602C OR36 R36 LTC3407-11PIN4.7k PIU1405 PIU140 200K PID10K ICVPP_ON PIR3402 COU14 U14 COC54 C54 22pF PIC5401 PIC5402 390 PID10A PIR3301 PIU1409 PIU1403 PIU1402 COC55 C55 PIC5 02 PIR3601 Power led Component / FPGA IO power BUTTON Program State LED +3.3V IO_L24P_6 IO_L24N_6/VREF_6 IO_L23P_6 IO_L23N_6 IO_L22P_6 IO_L22N_6 IO_L21P_6 IO_L21N_6 PIU4056 IO_L31P_4/DOUT/BUSY PIU4057 IO_L23P_3/VREF_3 PIU4084 IO_L23N_3 PIU4085 IO_L01N_0/VRP_0 IO_L01P_0/VRN_0 IO_L27N_0 IO_L27P_0 IO_L30N_0 IO_L30P_0 IO_L31N_0 IO_L31P_0/VREF_0 IO_L32N_0/GCLK7 IO_L32P_0/GCLK6 IO_L32N_1/GCLK5 IO_L32P_1/GCLK4 IO_L31N_1/VREF_1 IO_L31P_1 IO_L28N_1 IO_L28P_1 IO_L20P_2 56 FPGA_PSCL 57 FPGA_PSDA 85 86 PIU4086 IO_L24N_3 PIU4087 J_RESET 92 PIU4092 IC_TMS IO_L40N_2 PIU4093 93 IC_TDO IO_L24P_2 95 PIU4095 IC_TCK 96 NLSRAM0A5 SRAM_A5 97 SRAM_D3 NLSRAM0D3 98 SRAM_D2 NLSRAM0D2 99 SRAM_A4 NLSRAM0A4 IO_L24N_2 PIU4096 IO_L23P_2 PIU4097 IO_L23N_2/VREF_2 PIU4098 IO_L22P_2 PIU4099 IO_L22N_2 PIU40100 HSWAP_EN PIU4042 PIU4045 PIU4064 PIU4067 PIU4081 PIU408 PIU4094 PIU401 PIU401 4 PIU401 7 PIU40136 PIU40139 7 WP PIU907 SCL SDA PIU906 6 5 PIU905 PIR10 2 PIR1 02 BLUE LED COR10 COR11 R10 R11 COC28 C28 4.7K 0.1uF PIR10 1 D5 COD5 FPGA_SCL FPGA_SDA PID50K 100 SRAM_WE NLSRAM0W\E\ 102 SRAM_A8 NLSRAM0A8 103 SRAM_A9 NLSRAM0A9 PIU40102 PIU40103 SRAM_D7 SRAM_D6 SRAM_D5 SRAM_D4 SRAM_D3 SRAM_D2 SRAM_D1 SRAM_D0 59 PIU4059 107 PIU40107 R27 COR27 PID50A D7 COD7 PID70K PID100K SRAM_A15 NLSRAM0A15 142 PIU40142 32 31 30 PIU10030 29 PIU10029 21 PIU10021 20 PIU10020 19 PIU10019 18 PIU10018 17 PIU10017 16 PIU10016 15 PIU10015 14 PIU10014 13 PIU10013 4 PIU1004 3 PIU1003 2 PIU1002 1 PIU10031 PIU1001 27 26 23 PIU10023 22 PIU10022 11 PIU10011 10 PIU10010 7 PIU1007 6 PIU10027 PIU10026 PIU1006 A16 A15 A14 A13 A12 A11 A10 A9 A8 A7 A6 A5 A4 A3 A2 A1 A0 PIR2701 PIR2702 LEDF 390 YELLOW +3.3V PIU10032 LEDK 4.7K R28 COR28 PID70A PIR2801 PIR2802 LED1x R29 COR29 PID100A RED LED PIR2901 PIR2902 LED3x 390 24 VCC PIU10024 VCC PIU1008 GND C62 PIC6302 COC63 C63 25 PIC6202 COC62 PIU10025 GND PIU1009 8 PIC6201 PIC6301 0.1uF 9 0.1uF U10 COU10 71V124SA10TY8 ASYN SRAM IO7 IO6 IO5 IO4 IO3 IO2 IO1 IO0 WE OE CS 12 28 5 PIU10012 PIU10028 PIU1005 SRAM_WE SRAM_OE SRAM_CS D 38 M0 PIU4038 37 M1 PIU4037 39 M2 PIU4039 Title Memorizer 6 C 390 GREEN LED SRAM_A16 SRAM_A15 SRAM_A14 SRAM_A13 SRAM_A12 SRAM_A11 SRAM_A10 SRAM_A9 SRAM_A8 SRAM_A7 SRAM_A6 SRAM_A5 SRAM_A4 SRAM_A3 SRAM_A2 SRAM_A1 SRAM_A0 PIR2602 390 PIR1 01 I2C EEPROM ( DIP8) FPGA & Peripheral 5 PIC2801 PIC2802 PID30A PIR2601 COD10 D10 90 PIU4090 IO_L30P_4/D3 IO_L01P_2/VRN_2 PID30K SRAM_A6 NLSRAM0A6 IC_TDI IO_L40N_3/VREF_3 PIU409 PIU4016 PIU402 PIU4029 NLSRAM0A7 SRAM_A7 89 PIU4089 IO_L21N_2 GND VCC COR26 R26 D3 COD3 8 PIU908 87 IO_L40P_3 IO_L21P_2 4 PIU904 84 IO_L24P_3 IO_L40P_2/VREF_2 1 A0 2 PIU902 A1 3 PIU903 A2 PIU901 60 IO_L30N_4/D2 COC56 C56 10uF COR330 R33 AT24C512B-PU25 IO_L32N_4/GCLK1 PIC5601 PIC5602 620K PIR3501 PIR3302 COU9 U9 PIU4060 PIR3701 COR37 R37 5V_USB IRMCx DownLaod Cable Number A2 4 PIR3702 PIR3502 NLFPGA0SCL FPGA_SCL NLFPGA0SDA FPGA_SDA 51 53 1 PIU1501 NLSRAM0C\S\ SRAM_CS NLSRAM0A3 SRAM_A3 NLSRAM0A2 SRAM_A2 PIU4051 PIU4053 VFB1 PIU150 PIU150 240K Size 3 GND COR31 R31 PIR3101 100 2 VFB2 11 PIR1201 COR12 R12 750K PIR3102 COC52 C52 10uF NL0102VD +1.2VD PIL202 NLSRAM0D0 SRAM_D0 46 44 PIU4044 47 PIU4047 50 PIU4050 52 COL210uH L2 PIL201 PIC4701 PIC4702 10 PIU15010 PIU4046 PIU4052 4 PIU1504 2 80 82 PIU4082 83 PIU4083 SW1 FPGA core Pow er COC47 C47 22pF 5 PIR1202 PIU4080 #POR 100K COC31 C31 22pF PIC5201 PIC5202 79 PIU4079 SW2 8 PIU1508 COR13 R13 PIC3101 PIC3102 COD1 D1 RED LED +3.3V Interface 1 LED2 SRAM_A0 NLSRAM0A0 PIR4802 100 LED3 SRAM_D6 NLSRAM0D6 SRAM_D7 NLSRAM0D7 SRAM_A1 NLSRAM0A1 SRAM_OE NLSRAM0O\E\ +3.3V 100 PIR4902 COU4 U4 XC3S200-4TQG144C_2 MODE/SYIC 7 PIU1507 PIR2201 360-1012-ND(B12AP) 103 OFF-PC program BUTTON NLBUTTON R52 COR52 SW3 COSW3 R47 100 COR47 C59 COC59 IO_L28P_5/D7 IO/VREF_5 IO_L28N_5/D6 IO_L31P_5/D5 COD9 D9 360-1012-ND(B12AP) PIR4301 R43 PIC5902 COR43 PIR5101 PISW203 SW1 NLSW1 IO_L01P_4/VRN_4 IO_L01N_4/VRP_5 IO/VREF_4 IO_L01P_3/VRN_3 IO_L01N_3/VRP_3 IO IO_L20P_3 IO_L20N_3 IO_L01N_6/VRP_6 IO_L27P_4/D1 IO_L20N_2 IO_L01N_2/VRP_2 IO_L01P_1/VRN_1 IO_L01N_1/VRP_1 IO 9 16 22 29 D R51 COR51 5 9 PID909 5V_USB 1 PID901 3 PID903 8 PID908 R53 COR53 6 PIR5302 PIR5301 PID906 VPP_ON 4 0R PID904 7 PID907 2 PID902 10 PID905 PID9010 PISW201 PIC5801 Size select CCLK IO_L31N_4/INIT_B DONE PROG_B IO_L27N_4/DIN/D0 2510-6002UB TMS TDI TCK TDO RST Data buffer select SW2 NLSW2 PIR4201 R42 PIC5802 COR42 C58 COC58 10K 103 PIR4202 IO_L21P_3 IO_L21N_3 IO_L22P_3 IO_L22N_3 (Pin6 used to power Isolation Box V3.1) (Isolation box: JTAG Pin6 VIO is input for FS2 ) 390 GREEN LED IO_L32P_4/GCLK0 40PIU4040 IO_L01P_5/CS_B 41PIU4041 IO_L01N_5/RDWR_B Target JTAG Download led PIU4049 PIU4061 PIU4012 PIU4013 32PIU4032 IO_L20P_6 33 PIU4033 IO_L20N_6 35PIU4035 IO_L01P_6/VRN_6 390 YELLOW PIU4048 PIU4062 PIU40120 PIU40134 +3.3V 4 3 NLshe l1 4 PIU604 VBUS 2K 12 PIU401 5 PIU40126 PIU40138 GND GND GND GND PIR4002 2 67068-8000 8 PIU608 COR41 R41 PIR4101 PIR4102 sheel1 VBUS 2 D- PIJ202 3 D+ PIJ203 4 GND PIJ204 5 M. Hole PIJ205 6 M. Hole PIJ206 SUSPEND PIU6012 3 PIU603 GND 29 PIU6029 GND 30 PIU6030 GND USB to 232 NLSRAM0A12 SRAM_A12 NLSRAM0A11 SRAM_A11 R17 NLUART0REST UART_REST PIR1701COR17 PIR1702 PIU609 VDD 104 COJ2 J2 9 RST PIU4075 PIU4091 PIU401 6 PIL102 PIR1301 RUN1 68 PIR1802 NLSRAM0D4 SRAM_D4 +3.3V PIU4043 PIU4054 PIU406 110PIU40110 TCK 111PIU40111 TMS 109PIU40109 TDO 144PIU40144 TDI NLSRAM0A16 SRAM_A16 NLSRAM0A14 SRAM_A14 CP2102 COL1 L1 10uH PIL101 6 PIU1506 PGND COR20 R20 PIR2001 COU6 U6 +1.2VD PIR1302 COU15 U15 11 COR18 R18 PIR1801 COR19 R19 PIR1901 NLF0TDO F_TDO NLF0TDI F_TDI NLF0TMS F_TMS 5V_USB +2.5VD 10uF 3 NLF0TCK F_TCK PIU1509 PIU1503 PIU1502 COC34 C34 PIC3402 48 62 120 134 3 19 34 FPGA JTAG PIR1602 PIC3401 4.7K VCCO VCCO VCCO 72PIU4072 58PIU4058 71PIU4071 143PIU40143 65PIU4065 0 PIR2102 4.7K PIR1502 NLFPGA0PSCL FPGA_PSCL NLFPGA0PSDA FPGA_PSDA VCCAUX VIN PIR1402 PIR901 PIC40 1 PIC4201 PIC4 01 PIC4601 COC38 COC40 COC42 COC44 COC46 C38 C40 C42 C44 C46 47nF PIC40 2 0.47uF PIC4202 0.47uF PIC4 4.7uF PIC4622uF, 02 16V 02 NL5V0USB 5V_USB GND GND GND GND B 4.7K PIC3 01 COC30 C30 0.47nF PIC3 02 PIR401 PIU403 PIU4019 PIU4034 PIR1601 4.7K PIC30 1 PIC30 2 NL0205VD +2.5VD COR14 COR16 R14 COR15 R15 R16 PIJ106 PIC4501 +2.5VD COR9 R9 4.7K GCLK7 81 88 94 101 6 5 PIJ105 4 PIJ104 3 PIJ103 2 PIJ102 1 PIJ101 PIR1501 PIR702 GND GND GND GND HDR1X6 PIR1401 PIR701 +3.3V PIR2101 PIC4301 PIR902 22 55PIU4055 PIC4801 COC48 PIC50 2 COC50 C48 C50 PIC4802 22uF,16V PIC50 1 0.1uF COR7 R7 3 PIU203 PIR402 +3.3V PIC3801 COC36 C36 47nF PIC3802 PIC4101 A COR4 R4 COR21 R21 PIC3601 COC33 C33 47nF PIC3602 PIC3901 GND OUT FPGA PROGRAM EEPROM COJ1 J1 5 PIU305 PIR801 4.7K PIC3701 5 GND XCF02SVO20C +3.3V 6 PIU306 0.1uF COR8 R8 4 PIU204 VCCAUX VCCAUX VCCAUX VCCAUX 0.1uF 2 PIU202 VCC 115 126 138 COC7 C7 0.1uF OE VCCO VCCO VCCO PIC901 PIC902 COC21 C21 1 PIU201 75 91 106 PIC702 PIC701 3 VCCJ CLK PIU103 8 VCC0 OE/RST PIU108 10 VCC CE PIU1010 7 DNC CF PIU107 13 DNC CEO PIU1013 1 DNC D0 PIU101 6 DNC TCK PIU106 5 DNC TMS PIU105 4 DNC TDI PIU104 17 GND TDO PIU1017 SCL SDA PIR802 COC27 C27 PIC3501 CSX750PCC33.3330MT PIR302 42 45 64 67 0.1uF PIC602 PIC601 PIC302 PIC301 PIC2101 PIC2102 GND GND GND GND GND COC3 C3 20 PIU1020 19 PIU1019 18 PIU1018 2 PIU102 16 PIU1016 15 PIU1015 14 PIU1014 12 PIU1012 9 PIU109 11 PIU1011 COC9 C9 22uF, 16V 0.1uF 4.7K PIR202 4.7K VCCO VCCO VCCO COC6 C6 COR1 R1 PIR602 330 PIR102 4.7K COU1 U1 4 PIU304 COU2 U2 43 54 66 +3.3V COR2 R2 VCCO VCCO VCCO A COR6 R6 PIR301 COR3 R3 7 PIU307 PIC2701 PIC2702 PIC3201 9 PIR101 PIR201 WP 8 PIU308 COC29 COC32 COC35 COC37 COC39 COC41 COC43 COC45 C29 C32 C35 C37 C39 C41 C43 C45 47nF PIC3202 47nF PIC3502 47nF PIC3702 47nF PIC3902 0.47uF PIC4102 0.47uF PIC434.7uF 02 PIC4502 22uF, 16V RUN2 PIR601 VCC FPGA CLOCK +3.3V VCCAUX A0 A1 A2 VCCINT PIC2901 PIC2902 9 +3.3V +3.3V 49 61 121 133 47nF COU3 U3 VCCINT VCCINT VCCINT VCCINT COC2 C2 114 117 136 139 PIC101 PIC201 COC1 C1 PIC102 0.47uF PIC202 8 RUN2 1 Date: File: 1/1 Revision 2015/8/21 Sheet of F:\Work\..\IRMCx Download cable_R1.0_20110811G.sch Drawn By: 7 R1.0 Yang WeiPeng 8 COR36 PAR3601 PAR3602 PAR3301 PAR3302 PAU1401 PAU1401 PAU1402 PAU1403 PAU1404 PAU1405 COR33 COU14 PAR3402 PAR3401 COR34 COR2 PAR2202 PAR3501 PAR3502 PAR3502COR35 COR37PAR3701 PAR3702 PAU1501 COC47PAC4702 PAU1504 COL2 PAC4701 PAU1502 PAU1503 PAU1505 PAU1501 PAU15010 PAU1509 PAU1508 PAU1507 PAU1506 COU15 PAR1302 PAR1301 COR13 PAC5601 PAC5602 PAC3401 COJ2 PAR1201 PAR1202 PAR1202COR12 PAC3102 PAC3101COC31 COU4 PAC2401 COC24PAC2402 PAC5202 PAC5201 PAJ203PAJ202 PAJ202 PAJ204PAJ201 PAD60K PAR2402 PAR2401 PAR2502 PAR2501 COR9 PAR901 PAR902 COU3 PAU305 COC64 COC66 COC42 COC15 PAU4014 PAU4013PAC6402 PAU40142PAU401 PAU40140PAC6401 PAU40139PAU40138PAU40137PAU40136PAU40135PAU40134PAU40P1A3U40132PAU4013PAU40130PAC6602 PAU40129PAU40128PAU40127PAU40126PAC6601 PAU40125PAU40124PAU40123PAC4201 PAU4012PAU40121PAU4012PAU4019PPAC4202 AU401 8PAU4017PAU40PAC1501 1 6PAU4015PAU4014PAU401 3PAC1502 PAU4012PAU401 PAU401 PAU401 9 PAU401 COC65 PAU40PAC6502 PAU402 PAU403 COC30 COC46PAC4602 PAC6501 PAC1801 PAU406 PAC3002 PAC3001 PAU404 PAU405 PAU407 PAC1802 PAU408 PAU4010 COC18 PAC4601 PAU409 PAU4011 PAU4012 COC4 PAC4501 PAC402 PAC401PAC3301 PAC3302 PAC501 PAC2901 PAC3501 PAC4101COC33 PAC2301 PAC2302 PAC4502 PAC2902 PAC3502 PAC4102 PAC1002 PAC1902 PAC1001 PAC1901 PAU4016 PAU4017 PAU4018 PAU4019 PAU4020 PAU4021 COC10COC19 PAU4022 COC41 PAU40105 PAU40104 COC26 PAU40102 PAU40101 PAC2602 PAU4099 PAU40100 PAU306 PAU307 PAU303 PAU302 PAU308 PAU301 PAU801 PAU4098 PAU4097 PAU4096 PAU4095 COC2 PAC2202 PAC2201 PAU304 COU8 COC61PAC6102 PAU40103 PAC2601 COC23 COJP2 COR8 PAR801 PAR802 PAJP201 PAJP202 PAJP203 PAJP204 PAJP205 PAJP206 PAJP207 PAJP208 PAC2701 PAC2702 COC27 PAU40108 PAU40107 PAC502COC5PAU40106 PAC502 COC45 COC29 COC35 PAU4013 PAU4014 PAU4015 COC51 PAR40 2 PAR40 1 PAC5101 PAC5102 COR41PAR4102 PAR4101 PAU607PAU606PAU605PAU604PAU603PAU602PAU601PAU6029 PAC4902 PAD802 COR17PAD803 PAU608 PAU6028 PAR1701 PAU6010 PAU6026 PAD804 PAR3901COC49 PAR3902 PAC4901 PAD801 PAU8023 PAU803 PAU804 PAU805 PAU8022 PAU8021 PAU8020 PAU806 PAU4093 PAU4092 PAU807 PAU4091 PAC801 PAR5301 COR53 PAJP209 PAJP2010 PAU8019 PAU8018 PAU808 PAU8017 PAU4089 PAU4088 PAU4087 PAU809 PAU8010 PAU8011 PAU8016 PAU8015 PAU8014 PAU4086 PAU4085 PAU8012 PAU8013 PAU4090 PAR5302 PAU8024 PAU802 PAC802 PAU4094 COC8 PAC6101 PAR502 PAR501 COR5 COR21 PAU4084 COC9 COC1 PAU4082 COR19PAR2102 PAR2101 PAR1902 PAR1901 PAU4080 PAU10 PAC902 PAC901 PAC102 PAC1602 PAU4077 PAU1017 PAC1102 PAC1402 PAC4002 PAC3602 COR39 PAR1802 PAR1801COR18PAU104 PAC1701 PAC3801 PAC4401 PAC101 PAC1601 PAU105 PAU1016 PAC701 PAC702 COC7 PAU6015PAU6016PAU6017PAU6018PAU6019PAU602 PAU6021 PAU4075 PAU106 PAU1015 COR2 PAR201 PAR202 COU6 PAC3802 PAC4402 PAC1101 PAC1401 PAC4001 PAC3601 PAU107 PAU1014 PAC601 PAC602 COC6 PAJP101 COR55 PAR101 PAR102 PAR102COR1 COR49 COR47 COR48COC59 COC58 COC13 PAU4037PAU4038PAC1302 PAU4039PAU40 PAU40 1PAC1301 PAU402PAU403PAU40 4PAU405PAU40 6PAC3201 PAU407PAU4P0AU840 9PAU405PAC3202 PAU4051PAU4052PAU4COC32 053PAU405PAU405PAU4056PAU4057PAU4058PAU4059COC37 PAU406 PAU4061PAU4062PAU4063PAU406PAU4PAC2501 065PAU406PAU4067PAU4068PAC2502 PAU4069PAU407 PAU4071PCOC25 AU4072 PAR4902 PAR4701 PAR4802 PAC5902 PAR4301 PAC302 PAR601 PAR602 PAR602COR6 PAC301 PAC302COC3 PAJP102 PAR5502 PAR5 01 PAR4201 COU1 PAR4601 PAC5802 PAC4301 PAC3701 PAR4901 PAR4702 PAR4801 PAC5901 PAR4302 COC48 PAC2002 PAC2001 PAR20 2 PAR20 1 COR20 PAR4602 PAC5801 PAR4202 PAC3901 PAC3902 PAC4302 PAC3702 PAC201 PAC202 PAR5402 PAR5401 COC60 PAC4802 PAC4801 PAJP103 COR54 COC20 COC39 PASW303 PASW302 PASW301 COSW3 COC2 PAR4502 PAC6002 PAR4402 PASW201 PASW202 PASW203 PAJP104 PAR702 COJ1 PAR401 PAR402 PAR4501 PAC6001 PAR4401 PAJ101 PAJ102 PAJ103 PAJ104 PAJ105 PAJ106 COC28 COR7 COR4 PAR701 PAR5602 PAR5101 PAR5201 COR52 PAC2801 PAU908 PAU907 PAU906 PAU905 PAR1101 PAR1402 PAR1502 PAR1602 PAC5001 COU2 COJP1 PAR5601 PAR5102 PAR5202 PAR1102 PAC2802 PAR1702 COD8 PAJ206 COR46 PASW206 COSW2 PAR2302 PAR2301 PAU10 1 PAU10 2 PAU10 3 PAU10 4 PAU10 5 PAU10 6 PAU10 7 PAU10 8 PAU10 9 PAU10 10 PAU10 1 PAU10 12 PAU10 13 PAU10 14 PAU10 15 PAU10 16 COC63PAC6301 PAC6302 COL1 PAD40K COR23 COR24 COR25 COR40 PAR3801 PAR3802 PAD20K COD2PAD20A COD4PAD40A COD6 PAD60A COL3 PAC5302 PAC5301COC53 COC52 PAJ205 PAC5701 PAC5702 PAC6202 PAC6201 PAU10 32 PAU10 31 PAU10 30 PAU10 29 PAU10 28 PAU10 27 PAU10 26 PAU10 25 PAU10 24 PAU10 23 PAU10 2 PAU10 21 PAU10 20 PAU10 19 PAU10 18 PAU10 17 PAR3102 PAR3101 PAL102 PAL101 PAC3402 COC34 COR38 COC57 COC62 COU10 COR31 PAL202 PAL201 COC56 PAL302 PAL301 PAC5 01 PAC5 02COC55 PAR2201 PAD10K PAD10ACOD1 COR32 PAR3202 PAR3201 PAR3001 PAR30 2 COR30 PAC5402 PAC5401 COC54 PAU14010 PAU1409 PAU1408 PAU1407 PPAU1406 AU1406 PAU6030 PAU609 PAU6027 PAU6011 PAU6012 PAU6025 PAU6024 PAU6013 PAU6023 PAU6014 PAU6022 PAU4023 PAU4024 COC12 COC17 COC40 COC36 PAC1202 PAC1702 COC38 COC44 COC1 COC14 PAU4083 PAU4081 PAU4030 PAU4031 PAU4079 PAU4078 PAU4032 PAU4033 PAC1201 PAU4034 PAU4076 PAU4035 PAU4036 PAU4074 PAU4073 COR43 COR42 COC16 PAU4025 PAU4027 PAU4028 PAU4029 PAU4026 COR45 PAU203 COR56COR51 PAR1001 COD7 PAD70K COR10 PAR1002 COU9 PAU901 PAU902 PAU903 PAU904 PAU1020 PAU102 PAU1019 PAU103 PAU1018 PAU108 PAU1013 PAU109 PAU1012 PAU1010 PAU1011 COC43 COR1 PAD70A PAU101 PAU202 PAC2102 PAC2101 COC21 PAU204 PAU201 PAR301 PAR302 COR3 COR44 PASW102PASW103 PASW101 COSW1 PAR5001 PAR5002 COR50 PAR1401 COR14 COR15 COR16 PAR1501 COR26 PAR2602 PAR2601 PAD303 COD3PAD301 PAR2702 PAR2701 COR27 PAD304 PAD302 PAR1601 PAC5002 COC50 COR28 PAR2802 PAR2801 PAD503 COD5PAD501 PAR2902 PAR2901 COR29 PAD504 PAD502 Comment Designator Footprint C1, C5, C11, C17, C18, C19, C20, C25, C30, C39, C40, C41, C42, C64, C66 C2, C4, C8, C10, C12, C13, C14, C15, C16, C26, C29, C32, C33, C35, C36, C37, C38, C65 C3, C6, C7, C21, C27, C28, C50, C61, C62, C63 C9, C24, C45, C46, C48 C22, C23, C43, C44 C31, C47, C54 C0603 15 C0603 18 C0603 10 C1206 5 C0805 4 C0603 3 C34, C52, C55, C56 C49, C51 C53, C1206 5 C0603 2 C59, C0603 4 RED LED C57, C60 D1 L1206-1 1 BLUE LED D2 L1206-1 1 LED_3 D3, D5 2 YELLOW D4 LED_PAN_LNJ_A RA L1206-1 GREEN LED D6 L1206-1 1 GREEN LED D7 LED-0603 1 SP0503BAHTG D8 SOT-143 1 HDR1X6 J1 HDR1X6 1 67068-8000 J2 USB_CONN 1 4 HEADER JP1 A2501W VR-4P 1 2510-6002UB JP2 1 10uH L1, L2, L3 25106002UB_W O INDP4540X32L 4.7K 15 330 R1, R2, R3, R4, J1-0603 R5, R8, R9, R10, R11, R14, R15, R16, R36, R54, R55 R6 J1-0603 22 R7 J1-0603 1 750K R12 J1-0603 1 100K R13, R34 J1-0603 2 2K R17 J1-0603 1 68 R18, R19, R20 J1-0603 3 0 R21, R33 J1-0603 2 390 9 910K R22, R23, R24, J1-0603 R25, R26, R27, R28, R29, R56 R30 J1-0603 240K R31 J1-0603 1 200K R32 J1-0603 1 620K R35, R37 J1-0603 2 1M R38 J1-0603 1 1R R39 R0805 1 22R R40, R41 J1-0603 2 10K R42, R43, R44 J1-0603 3 100 R45, R46, R47 J1-0603 3 0.47uF 47nF 0.1uF 22uF, 16V 4.7uF 22pF 10uF 104 103 Description C58, LibRef Quantity 1 3 1 1 47 0R R48, R49, R51, R52 R53 A9 360-1012ND(B12AP) DIP3 R50, J1-0603 5 R0805 1 SW 1 3296 1 SW 2 SW _W O 1 SW 3 HDR1X3 1 XCF02SVO20C U1 TSSOP-20 1 CSX750PCC33.33 30MT AT24C02 U2 CSX-750P 1 U3 8S1_L 1 XC3S2004TQG144C_2 CP2102 U4 TQFP-144_20X20 1 U6 QFN-28 1 IDTQS3861TSSOP24 AT24C512B-PU25 U8 TSSOP-24 1 U9 DIP-8 1 71V124SA10TY8 U10 PJ32 1 LTC3407-11PIN U14, U15 LTC3407 2