ELM600(TA)-V

5 PIN SOP HIGH SPEED 10MBit/s LOGIC GATE PHOTOCOUPLER ELM6XX series Schematic Features • High speed 10Mbit/s • Guaranteed performance from -40 to 85 • Logic gate output • High isolation voltage between input and output (Viso=3750 V rms ) • Pb free and RoHS compliant. • UL approved (No. 214129) • VDE approved (No. 40028116) • SEMKO approved • NEMKO approved • DEMKO approved • FIMKO approved ℃ Pin Configuration 1, Anode 3, Cathode 4, Gnd 5, Vout 6, VCC Description The ELM600, ELM601 and ELM611 are consists of an infrared emitting diode optically coupled to a high speed integrated photo detector logic gate with a strobable output. The devices are packaged in a 5-pin small outline package which conforms to the standard footprint. Applications • Ground loop elimination • LSTTL to TTL, LSTTL or 5 volt CMOS • Line receiver, data transmission • Data multiplexing • Switching power supplies • Pulse transformer replacement • Computer peripheral interface 1 Truth Table Input H L Output L H Copyright © 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No: DPC-0000114 Rev.3 www.everlight.com DATASHEET 5 PIN SOP HIGH SPEED 10MBit/s LOGIC GATE PHOTOCOUPLER ELM6XX series Absolute Maximum Ratings (Ta=25℃ ℃) Parameter Symbol Rating Unit Forward current IF 50 mA Reverse voltage VR 5 V Power dissipation PD 100 mW Power dissipation PC 85 mW Output current IO 50 mA Output voltage VO 7.0 V Supply voltage VCC 7.0 V PO 85 mW Isolation Voltage* VISO 3750 V rms Operating Temperature TOPR -40 ~ +85 °C Storage Temperature TSTG -55 ~ +125 °C TSOL 260 °C Input Output Output Power Dissipation 1 2 Soldering Temperature* Notes: *1 AC for 1 minute, R.H.= 40 ~ 60% R.H. In this test, pins 1 & 3 are shorted together, and pins 4, 5 & 6 are shorted together. *2 For 10 seconds 2 Copyright © 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000114 Rev.3 www.everlight.com DATASHEET 5 PIN SOP HIGH SPEED 10MBit/s LOGIC GATE PHOTOCOUPLER ELM6XX series Electrical Characteristics (Ta=-40 to 85°C unless specified otherwise) Input Symbol Min. Typ. Max. Unit Condition Forward voltage VF - 1.45 1.8 V IF = 10mA Reverse voltage VR 5.0 - - V ∆VF/∆TA - -1.9 - mV/°C IF =10mA CIN - 70 - pF VF=0, f=1MHz Min Typ. Max. Unit ICCH - 6.0 9 mA IF=0mA, VCC=5.5V ICCL - 7.5 10 mA IF=10mA, VCC=5.5V Symbol Min Typ. Max. Unit Condition IOH - 2.1 30 uA VOL - 0.4 0.6 V IFT - 2.4 5 mA Parameter Temperature coefficient of forward voltage Input capacitance ℃ IR = 10µA, TA=25 Output Parameter Symbol High level supply current Low level supply current Condition Transfer Characteristics Parameter HIGH Level Output Current LOW Level Output Current Input Threshold Current 3 VCC=5.5V, VO=5.5V, IF=250uA VCC = 5.5V, IF=5mA, IOL(Sinking)=13mA VCC= 5.5V, VO=0.6V, IOL(Sinking)=13mA Copyright © 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000114 Rev.3 www.everlight.com DATASHEET 5 PIN SOP HIGH SPEED 10MBit/s LOGIC GATE PHOTOCOUPLER ELM6XX series Switching Characteristics Parameter Propagation delay time to output High 3 level* (Fig.12) Propagation delay time to output Low 3 level* (Fig.12) Pulse width distortion Propagation Delay 4 Skew* Output rise time (Fig.12) Output fall time (Fig.12) (Ta=-40 to 85°C, VCC=5V, IF=7.5mA unless specified otherwise) Symbol Min Typ. Max. Unit Condition TPHL - 41 100 ns CL = 15pF, RL=350Ω, TA=25°C TPLH - 50 100 ns CL = 15pF, RL=350Ω, TA=25°C |Tphl – Tplh| - 9 35 ns CL = 15pF, RL=350Ω tPSK - - 40 ns CL = 15pF, RL=350Ω tr - 40 - ns CL = 15pF, RL=350Ω tf - 10 - ns CL = 15pF, RL=350Ω - - - Common Mode Transient Immunity at Logic High *6 (Fig.14) M600 M611 20,000 Common Mode Transient Immunity at Logic Low *7 (Fig.14) M600 - M601 M601 CMH CML M611 5,000 5,000 20,000 V/µS - - V/µS IF = 7.5mA , VOH=2.0V, RL=350Ω, TA=25°C VCM=10Vp-p IF = 7.5mA , VOH=2.0V, RL=350Ω, TA=25°C VCM=50Vp-p IF = 7.5mA , VOH=2.0V, RL=350Ω, TA=25°C VCM=1000Vp-p IF = 0mA , VOL=0.8V, RL=350Ω, TA=25°C VCM=10Vp-p IF = 0mA , VOL=0.8V, RL=350Ω, TA=25°C VCM=50Vp-p IF = 0mA , VOL=0.8V, RL=350Ω, TA=25°C VCM=1000Vp-p *All typicals at Ta = 25°C, VCC = 5 V. 4 Copyright © 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000114 Rev.3 www.everlight.com DATASHEET 5 PIN SOP HIGH SPEED 10MBit/s LOGIC GATE PHOTOCOUPLER ELM6XX series Typical Electro-Optical Characteristics Curves 5 Copyright © 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000114 Rev.3 www.everlight.com DATASHEET 5 PIN SOP HIGH SPEED 10MBit/s LOGIC GATE PHOTOCOUPLER ELM6XX series 6 Copyright © 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000114 Rev.3 www.everlight.com DATASHEET 5 PIN SOP HIGH SPEED 10MBit/s LOGIC GATE PHOTOCOUPLER ELM6XX series Fig. 11 Test circuit and waveforms for tPHL, tPLH, tr, and tf IF=7.5mA Input (IF) IF=3.75mA tPHL tPLH Output (Vo) 1.5V 90% Output (Vo) 10% tf tr Fig. 12 Test circuit Common mode Transient Immunity Peak VCM 0V 5V Vo CMH Switching Pos. (A), IF=0 VO(Min) VO(Max) Switching Pos. (B), IF=7.5mA VCM CML 0.5V Notes: *3 The tPLH propagation delay is measured from 3.75 mA point on the falling edge of the input pulse to the 1.5V point on the rising edge of the output pulse. *4 The tPHL propagation delay is measured from 3.75 mA point on the rising edge of the input pulse to the 1.5 V point on the falling edge of the output pulse *5 tPSK is equal to the magnitude of the worst case difference in tPHL and/or tPLH that will be seen between units at any given temperature within the worst case operating condition range. *6 CMH– The maximum tolerable rate of rise of the common mode voltage to ensure the output will remain in the HIGH state (i.e., VOUT > 2.0V). *7 CML– The maximum tolerable rate of fall of the common mode voltage to ensure the output will remain in the LOW output state (i.e., VOUT < 0.8V). 7 Copyright © 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000114 Rev.3 www.everlight.com DATASHEET 5 PIN SOP HIGH SPEED 10MBit/s LOGIC GATE PHOTOCOUPLER ELM6XX series Order Information Part Number ELM6XX(Z)-V Note XX = Part no.(00, 01 or 11) Z = Tape and reel option (TA, TB or none). V = VDE (optional) Option None (TA) Standard DIP-8 Surface mount lead form + TA tape & reel option Packing quantity 100 units per tube 3000 units per reel (TB) Surface mount lead form + TB tape & reel option 3000 units per reel 8 Description Copyright © 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000114 Rev.3 www.everlight.com DATASHEET 5 PIN SOP HIGH SPEED 10MBit/s LOGIC GATE PHOTOCOUPLER ELM6XX series Package Dimension (Dimensions in mm) Recommended pad layout for surface mount leadform 9 Copyright © 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000114 Rev.3 www.everlight.com DATASHEET 5 PIN SOP HIGH SPEED 10MBit/s LOGIC GATE PHOTOCOUPLER ELM6XX series Device Marking EL M611 YWWV Notes EL M611 Y WW V 10 denotes EVERLIGHT denotes Device Number denotes 1 digit Year code denotes 2 digit Week code denotes VDE (optional) Copyright © 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000114 Rev.3 www.everlight.com DATASHEET 5 PIN SOP HIGH SPEED 10MBit/s LOGIC GATE PHOTOCOUPLER ELM6XX series Tape & Reel Packing Specifications Option TA Option TB Direction of feed from reel Direction of feed from reel Tape dimensions 11 Dimension No. A B Do D1 E F Dimension(mm) 10.4±0.1 10.0±0.1 1.5±0.1 1.5±0.1 1.75±0.1 7.5±0.1 Dimension No. Po P1 P2 t W K Dimension(mm) 4.0±0.1 12.0±0.1 2.0±0.1 0.4±0.1 16.0+0.3/ -0.1 Copyright © 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000114 Rev.3 4.5±0.1 www.everlight.com DATASHEET 5 PIN SOP HIGH SPEED 10MBit/s LOGIC GATE PHOTOCOUPLER ELM6XX series Precautions for Use 1. Soldering Condition 1.1 (A) Maximum Body Case Temperature Profile for evaluation of Reflow Profile Note: Reference: IPC/JEDEC J-STD-020D Preheat Temperature min (Tsmin) 150 °C Temperature max (Tsmax) 200°C Time (Tsmin to Tsmax) (ts) Average ramp-up rate (Tsmax to Tp) 60-120 seconds 3 °C/second max Other Liquidus Temperature (TL) 217 °C Time above Liquidus Temperature (t L) 60-100 sec Peak Temperature (TP) 260°C Time within 5 °C of Actual Peak Temperature: TP - 5°C 30 s Ramp- Down Rate from Peak Temperature 6°C /second max. Time 25°C to peak temperature Reflow times 8 minutes max. 3 times . 12 Copyright © 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000114 Rev.3 www.everlight.com DATASHEET 5 PIN SOP HIGH SPEED 10MBit/s LOGIC GATE PHOTOCOUPLER ELM6XX series DISCLAIMER 1. Above specification may be changed without notice. EVERLIGHT will reserve authority on material change for above specification. 2. When using this product, please observe the absolute maximum ratings and the instructions for using outlined in these specification sheets. EVERLIGHT assumes no responsibility for any damage resulting from use of the product which does not comply with the absolute maximum ratings and the instructions included in these specification sheets. 3. These specification sheets include materials protected under copyright of EVERLIGHT corporation. Please don’t reproduce or cause anyone to reproduce them without EVERLIGHT’s consent. 13 Copyright © 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000114 Rev.3 www.everlight.com