3KP33CA

3KP SERIES GLASS PASSIVATED JUNCTION TRANSIENT VOLTAGE SUPPRESSOR VOLTAGE - 5.0 TO 170 Volts 3000 Watt Peak Pulse Power FEATURES l Plastic package has Underwriters Laboratory Flammability Classification 94V-O l Glass passivated junction l 3000W Peak Pulse Power capability on 10/1000 £g S waveform l Excellent clamping capability l Repetition rate(Duty Cycle): 0.05% l Low incremental surge resistance l Fast response time: typically less than 1.0 ps from 0 volts to BV l Typical ID less than 1 £g A above 10V l High temperature soldering guaranteed: 300 ¢J /10 seconds/.375”,(9.5mm) lead length/5lbs., (2.3kg) tension MECHANICAL DATA Case: Molded plastic over glass passivated junction Terminals: Plated Axial leads, solderable per MIL-STD-750, Method 2026 Polarity: Color band denoteds positive end(cathode) Mounting Position: Any Weight: 0.07 ounce, 2.1 grams DEVICES FOR BIPOLAR APPLICATIONS For Bidirectional use C or CA Suffix for types Electrical characteristics apply in both directions. MAXIMUM RATINGS AND CHARACTERISTICS ¢J ambient temperature unless otherwise specified. Ratings at 25 RATING SYMBOL VALUE Peak Pulse Power Dissipation on 10/1000 £g S waveform PPPM Minimum 3000 (Note 1, FIG.1) Peak Pulse Current of on 10/1000 £g S waveform IPPM SEE TABLE 1 (Note 1, FIG.3) PM(AV) 8.0 Steady State Power Dissipation at TL=75 ¢J Lead Lengths .375”,(9.5mm) (Note 2) Peak Forward Surge Current, 8.3ms Single Half Sine-Wave IF S M 250 Superimposed on Rated Load, Unidirectional only (JECED Method) (Note 3) Operating Junction and Storage Temperature Range TJ,TSTG -55 to +175 NOTES: 1.Non-repetitive current pulse, per Fig. 3 and derated above TA=25 ¢J per Fig. 2. 2.Mounted on Copper Leaf area of 0.79in (20mm ). 3.Measured on 8.3ms single half sine-wave or equivalent square wave, duty cycle= 4 pulses per minutes maximum. 2 2 P-600 UNITS Watts Amps Watts Amps ¢J RATING AND CHARACTERISTIC CURVES 3KP SERIES PPP M, PEAK PULSE POWER,KW 100 EAK PULSE POWER(Ppp) OR CURRENT(lpp) DERATING IN PERCENTAGE% 100 10 75 1.0 NON-REPETITIVE PULSE WAVEFORM SHOWN IN FIGURE 3 TA = 25 ¢J 50 0.1 0.1 £gs 1 .0 £gs 1 0 £gs 1 00 £gs 1.0ms 10ms 25 td, PULSE WIDTH, SEC 0 0 25 50 75 100 125 150 175 200 Fig. 1-PEAK PULSE POWER VS PULSE TIME TA , AMBIENT TEMPERATURE, ¢J 150 Ippm, PEAK PULSE CURRENT, % tf = 10£gse c Peak Value Ippm 100 CJ,CAPACITANCE, pF TA = 25¢J Pulse Width(td) is Defined as the Point Where the Peak Current Decays to 50% of lpp Fig. 2-DERATING CURVE 2 0,000 1 0,000 TJ = 25 ¢J f = 1.0MHz Vsig = 50mVp-p Half Value-Ipp 2 10/1000 £gsec Waveform as Defined by R.E.A. 50 1,000 MEASURED AT ZERO BIAS MEASURED AT ST AND-OFF VOLTAGE(V W) M e-kt 0 0 td 1 00 1 .0 2.0 3.0 4.0 t, TIME , ms 10 1.0 2 .0 10 20 100 200 400 Fig. 3-PULSE WAVEFORM 10.0 L = 375" (9.5mm) V(WM), REVERSE STAND-OFF VOLTAGE, VOLTS Pm(AV) STEADY STATE POW ER DISSIPATION, WATTS 6.0 20mm × 20mm × 1mm CU (0.8" × 0.8" × 0.40") 4.0 IF SM, PEAK FORW ARD SURGE CURRENT, Fig. 4-TYPICAL CAPACITANCE VS STAND-OFF VOLTAGE 300 250 200 AM PERES 150 100 50 TJ = TJ max 8.3ms SINGLE HALF SINCE-WAVE JEDEC METHOD 2.0 0 0 25 50 75 100 125 150 175 200 TL, LEAD TEMPERATURE, ¢J Fig. 5-STEADY STATE POWER DERATING 1 2 5 10 20 50 100 NUMBER OF CYCLES AT 60Hz Fig. 6-MAXIMUM NON-REPETITIVE PEAK FORWARD SURGE CURRENT UNI-DIRECTIONAL 3000 Watt Axial Lead TVS UNIDIRECTIONAL PART NUMBER 3KP5.0 3KP5.0A 3KP6.0 3KP6.0A 3KP6.5 3KP6.5A 3KP7.0 3KP7.0A 3KP7.5 3KP7.5A 3KP8.0 3KP8.0A 3KP8.5 3KP8.5A 3KP9.0 3KP9.0A 3KP10 3KP10A 3KP11 3KP11A 3KP12 3KP12A 3KP13 3KP13A 3KP14 3KP14A 3KP15 3KP15A 3KP16 3KP16A 3KP17 3KP17A 3KP18 3KP18A 3KP20 3KP20A 3KP22 3KP22A 3KP24 3KP24A 3KP26 3KP26A 3KP28 3KP28A 3KP30 3KP30A 3KP33 3KP33A 3KP36 3KP36A 3KP40 3KP40A 3KP43 3KP43A 3KP45 3KP45A 3KP48 3KP48A 3KP51 3KP51A 3KP54 3KP54A 3KP58 3KP58A REV ERS E STAND-OF F VOLTAGE VRWM (V) 5.00 5.00 6.00 6.00 6.50 6.50 7.00 7.00 7.50 7.50 8.00 8.00 8.50 8.50 9.00 9.00 10.00 10.00 11.00 11.00 12.00 12.00 13.00 13.00 14.00 14.00 15.00 15.00 16.00 16.00 17.00 17.00 18.00 18.00 20.00 20.00 22.00 22.00 24.00 24.00 26.00 26.00 28.00 28.00 30.00 30.00 33.00 33.00 36.00 36.00 40.00 40.00 43.00 43.00 45.00 45.00 48.00 48.00 51.00 51.00 54.00 54.00 58.00 58.00 B REA KDOW N VOLTAGE VBR (V) MIN. @IT 6.40 6.40 6.67 6.67 7.22 7.22 7.78 7.78 8.33 8.33 8.89 8.89 9.44 9.44 10.00 10.00 11.10 11.10 12.20 12.20 13.30 13.30 14.40 14.40 15.60 15.60 16.70 16.70 17.80 17.80 18.90 18.90 20.00 20.00 22.20 22.20 24.40 24.40 26.70 26.70 28.90 28.90 31.10 31.10 33.30 33.30 36.70 36.70 40.00 40.00 44.40 44.40 47.80 47.80 50.00 50.00 53.30 53.30 56.70 56.70 60.00 60.00 64.40 64.40 BRE AKDOW N VOLTAGE VBR (V) MAX. @IT 7.55 7.25 8.45 7.67 9.14 8.30 9.86 8.95 10.67 9.58 11.30 10.23 11.92 10.82 12.60 11.50 14.10 12.80 15.40 14.00 16.90 15.30 18.20 16.50 19.80 17.90 21.10 19.20 22.60 20.50 23.90 21.70 25.30 23.30 28.10 25.50 30.90 28.00 33.80 30.70 36.60 33.20 39.40 35.80 42.20 38.30 46.50 42.20 50.70 46.00 56.30 51.10 60.50 54.90 63.30 57.50 67.50 61.30 71.80 65.20 76.00 69.00 81.60 74.10 T EST CURRENT IT (mA) 10 10 10 10 10 10 10 10 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 MAXIMUM CLAMPING VOLTAGE @IPP V C (V) 9.6 9.2 11.4 10.3 12.3 11.2 13.3 12.0 14.3 12.9 15.0 13.6 15.9 14.4 16.9 15.4 18.8 17.0 20.1 18.2 22.0 19.9 23.8 21.5 25.8 23.2 26.9 24.4 28.8 26.0 30.5 27.6 32.2 29.2 35.8 32.4 39.4 35.5 43.0 38.9 46.6 42.1 50.0 45.4 53.5 48.4 59.0 53.3 64.3 58.1 71.4 64.5 76.7 69.4 80.3 72.7 85.5 77.4 91.1 82.4 96.3 87.1 103.0 93.6 PEA K PULSE CURRE NT IPP (A) 312.5 326.0 263.2 291.3 243.9 267.9 225.6 250.0 209.8 232.6 220.0 220.6 188.8 208.4 177.4 194.8 159.6 176.4 149.2 184.8 136.4 150.6 126.0 139.4 116.2 129.4 111.6 123.0 104.2 115.4 98.4 106.6 93.2 102.8 83.8 92.6 76.2 84.4 69.8 77.2 64.4 71.2 60.0 66.0 56.0 62.0 50.4 56.2 46.6 51.6 42.0 46.4 39.2 43.2 37.4 41.2 35.0 38.8 37.0 36.4 31.2 34.4 29.2 32.0 REVERSE LE AKAGE @VRW M IR (uA) 1000 1000 1000 1000 500 500 200 200 100 100 50 50 25 25 10 10 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 UNI-DIRECTIONAL 3000 Watt Axial Lead TVS UNIDIRECTIONAL PART NUMBER 3KP60 3KP60A 3KP64 3KP64A 3KP70 3KP70A 3KP75 3KP75A 3KP78 3KP78A 3KP85 3KP85A 3KP90 3KP90A 3KP100 3KP100A 3KP110 3KP110A 3KP120 3KP120A 3KP130 3KP130A 3KP150 3KP150A 3KP160 3KP160A 3KP170 3KP170A REV ERS E STAND-OF F VOLTAGE VRWM (V) 60.00 60.00 64.00 64.00 70.00 70.00 75.00 75.00 78.00 78.00 85.00 85.00 90.00 90.00 100.00 100.00 110.00 110.00 120.00 120.00 130.00 130.00 150.00 150.00 160.00 160.00 170.00 170.00 B REA KDOW N VOLTAGE VBR (V) MIN. @IT 66.70 66.70 71.10 71.10 77.80 77.80 83.30 83.30 86.70 86.70 94.40 94.40 100.00 100.00 111.00 111.00 122.00 122.00 133.00 133.00 144.00 144.00 167.00 167.00 178.00 178.00 189.00 189.00 BRE AKDOW N VOLTAGE VBR (V) MAX. @IT 84.50 76.70 90.10 81.80 98.60 89.50 105.70 95.80 109.80 99.70 119.20 108.20 126.50 115.50 141.00 128.00 154.50 140.50 169.00 153.00 182.50 165.50 211.50 192.50 226.00 205.00 239.50 217.50 T EST CURRENT IT (mA) 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 MAXIMUM CLAMPING VOLTAGE @IPP V C (V) 107.0 96.8 114.0 103.0 125.0 113.0 134.0 121.0 139.0 126.0 151.0 137.0 160.0 146.0 179.0 162.0 196.0 177.0 214.0 193.0 231.0 209.0 268.0 243.0 287.0 259.0 304.0 275.0 PEA K PULSE CURRE NT IPP (A) 28.0 31.0 26.4 29.2 24.0 26.6 22.4 24.8 21.6 22.8 19.8 20.8 18.8 20.6 16.6 18.6 15.4 16.8 14.0 15.6 13.0 14.4 11.2 12.4 10.4 11.6 9.8 11.0 REVERSE LE AKAGE @VRW M IR (uA) 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 BI-DIRECTIONAL 3000 Watt Axial Lead TVS BI-DIRECTIONAL PART NUMB ER 3KP5.0C 3KP5.0CA 3KP6.0C 3KP6.0CA 3KP6.5C 3KP6.5CA 3KP7.0C 3KP7.0CA 3KP7.5C 3KP7.5CA 3KP8.0C 3KP8.0CA 3KP8.5C 3KP8.5CA 3KP9.0C 3KP9.0CA 3KP10C 3KP10CA 3KP11C 3KP11CA 3KP12C 3KP12CA 3KP13C 3KP13CA 3KP14C 3KP14CA 3KP15C 3KP15CA 3KP16C 3KP16CA 3KP17C 3KP17CA 3KP18C 3KP18CA 3KP20C 3KP20CA 3KP22C 3KP22CA 3KP24C 3KP24CA 3KP26C 3KP26CA 3KP28C 3KP28CA 3KP30C 3KP30CA 3KP33C 3KP33CA 3KP36C 3KP36CA 3KP40C 3KP40CA 3KP43C 3KP43CA 3KP45C 3KP45CA 3KP48C 3KP48CA 3KP51C 3KP51CA 3KP54C 3KP54CA 3KP58C 3KP58CA REV ERS E STAND-OF F VOLTAGE VRWM (V) 5.00 5.00 6.00 6.00 6.50 6.50 7.00 7.00 7.50 7.50 8.00 8.00 8.50 8.50 9.00 9.00 10.00 10.00 11.00 11.00 12.00 12.00 13.00 13.00 14.00 14.00 15.00 15.00 16.00 16.00 17.00 17.00 18.00 18.00 20.00 20.00 22.00 22.00 24.00 24.00 26.00 26.00 28.00 28.00 30.00 30.00 33.00 33.00 36.00 36.00 40.00 40.00 43.00 43.00 45.00 45.00 48.00 48.00 51.00 51.00 54.00 54.00 58.00 58.00 B REA KDOW N VOLTAGE VBR (V) MIN. @IT 6.40 6.40 6.67 6.67 7.22 7.22 7.78 7.78 8.33 8.33 8.89 8.89 9.44 9.44 10.00 10.00 11.10 11.10 12.20 12.20 13.30 13.30 14.40 14.40 15.60 15.60 16.70 16.70 17.80 17.80 18.90 18.90 20.00 20.00 22.20 22.20 24.40 24.40 26.70 26.70 28.90 28.90 31.10 31.10 33.30 33.30 36.70 36.70 40.00 40.00 44.40 44.40 47.80 47.80 50.00 50.00 53.30 53.30 56.70 56.70 60.00 60.00 64.40 64.40 BRE AKDOW N VOLTAGE VBR (V) MAX. @IT 7.55 7.25 8.45 7.67 9.14 8.30 9.86 8.95 10.67 9.58 11.30 10.23 11.92 10.82 12.60 11.50 14.10 12.80 15.40 14.00 16.90 15.30 18.20 16.50 19.80 17.90 21.10 19.20 22.60 20.50 23.90 21.70 25.30 23.30 28.10 25.50 30.90 28.00 33.80 30.70 36.60 33.20 39.40 35.80 42.20 38.30 46.50 42.20 50.70 46.00 56.30 51.10 60.50 54.90 63.30 57.50 67.50 61.30 71.80 65.20 76.00 69.00 81.60 74.10 T EST CURRENT IT (mA) 10 10 10 10 10 10 10 10 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 MAXIMUM CLAMPING VOLTAGE @IPP V C (V) 9.6 9.2 11.4 10.3 12.3 11.2 13.3 12.0 14.3 12.9 15.0 13.6 15.9 14.4 16.9 15.4 18.8 17.0 20.1 18.2 22.0 19.9 23.8 21.5 25.8 23.2 26.9 24.4 28.8 26.0 30.5 27.6 32.2 29.2 35.8 32.4 39.4 35.5 43.0 38.9 46.6 42.1 50.0 45.4 53.5 48.4 59.0 53.3 64.3 58.1 71.4 64.5 76.7 69.4 80.3 72.7 85.5 77.4 91.1 82.4 96.3 87.1 103.0 93.6 PEA K PULSE CURRE NT IPP (A) 312.5 326.0 263.2 291.3 243.9 267.9 225.6 250.0 209.8 232.6 220.0 220.6 188.8 208.4 177.4 194.8 159.6 176.4 149.2 184.8 136.4 150.6 126.0 139.4 116.2 129.4 111.6 123.0 104.2 115.4 98.4 106.6 93.2 102.8 83.8 92.6 76.2 84.4 69.8 77.2 64.4 71.2 60.0 66.0 56.0 62.0 50.4 56.2 46.6 51.6 42.0 46.4 39.2 43.2 37.4 41.2 35.0 38.8 37.0 36.4 31.2 34.4 29.2 32.0 REVERSE LE AKAGE @VRW M IR (uA) 2000 2000 2000 2000 1000 1000 400 400 200 200 100 100 50 50 20 20 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 BI-DIRECTIONAL 3000 Watt Axial Lead TVS BI-DIRECTIONAL PART NUMB ER 3KP60C 3KP60CA 3KP64C 3KP64CA 3KP70C 3KP70CA 3KP75C 3KP75CA 3KP78C 3KP78CA 3KP85C 3KP85CA 3KP90C 3KP90CA 3KP100C 3KP100CA 3KP110C 3KP110CA 3KP120C 3KP120CA 3KP130C 3KP130CA 3KP150C 3KP150CA 3KP160C 3KP160CA 3KP170C 3KP170CA REV ERS E STAND-OF F VOLTAGE VRWM (V) 60.00 60.00 64.00 64.00 70.00 70.00 75.00 75.00 78.00 78.00 85.00 85.00 90.00 90.00 100.00 100.00 110.00 110.00 120.00 120.00 130.00 130.00 150.00 150.00 160.00 160.00 170.00 170.00 B REA KDOW N VOLTAGE VBR (V) MIN. @IT 66.70 66.70 71.10 71.10 77.80 77.80 83.30 83.30 86.70 86.70 94.40 94.40 100.00 100.00 111.00 111.00 122.00 122.00 133.00 133.00 144.00 144.00 167.00 167.00 178.00 178.00 189.00 189.00 BRE AKDOW N VOLTAGE VBR (V) MAX. @IT 84.50 76.70 90.10 81.80 98.60 89.50 105.70 95.80 109.80 99.70 119.20 108.20 126.50 115.50 141.00 128.00 154.50 140.50 169.00 153.00 182.50 165.50 211.50 192.50 226.00 205.00 239.50 217.50 T EST CURRENT IT (mA) 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 MAXIMUM CLAMPING VOLTAGE @IPP V C (V) 107.0 96.8 114.0 103.0 125.0 113.0 134.0 121.0 139.0 126.0 151.0 137.0 160.0 146.0 179.0 162.0 196.0 177.0 214.0 193.0 231.0 209.0 268.0 243.0 287.0 259.0 304.0 275.0 PEA K PULSE CURRE NT IPP (A) 28.0 31.0 26.4 29.2 24.0 26.6 22.4 24.8 21.6 22.8 19.8 20.8 18.8 20.6 16.6 18.6 15.4 16.8 14.0 15.6 13.0 14.4 11.2 12.4 10.4 11.6 9.8 11.0 REVERSE LE AKAGE @VRW M IR (uA) 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5