RJC097PB101K

RJC097 Series TOCOS POTENTIOMETERS ® 3/4’’ Rectilinear, 15-Turn, Through-Hole, Sealed Cermet Trimmers Features 3 /4” rectilinear, 15-turn, through-hole, sealed cermet trimmers Miniature design for component density Side adjust with single-slot standard or extended shaft Knob styles available for easier adjustment State-of-the-art brush contact design Excellent stability and low noise PC board solderable pins Sealed to withstand wave soldering and immersion cleaning Meets UL flammability standards Specifications Electrical Standard Resistance Range . . . . . . . . . . . . . . 10 Ω to 1M Ω (standard 1, 2 & 5 sequence ) Resistance Tolerance . . . . . . . . . . . . . . . 10% and 20% End Resistance . . . . . . . . . . 1% or 3 Ω, whichever is greater Resistance Taper . . . . . . . . . . . . . . . . . . . . . . . . . . . . Linear Peak Noise (C.R.V.) . . . . . . . 1% or 1Ω, whichever is greater Power Rating . . . . . . 0.75 watt at 70 C, 0 watt at 125 C Maximum Input Voltage . . . . . . . . 300VDC or power rating, whichever is smaller Temperature Coefficient . . . . 100ppm / C, 200 Ω to 1M Ω 250ppm / C, other values Environmental Temperature Range . . . . . . . . . . . . . . . . . Low Temperature Operation . . . . . . . . . 55 C to 125 C 55 C, 0.75 watt, 45 minutes ∆T/R ) 3%, S.S. ) 1% High Temperature Exposure . . . . . . . . . 125 C, 250 hours ∆T/R ) 3%, S.S. ) 1% Load Life . . . . . . . . . . . . . . . . 70 C, 0.75 watt, 1,000 hours ∆T/R ) 3%, S.S. ) 3% Thermal Shock . . . . . . . . . . . . . . . . . . . . . . 55 C, 125 C, 30 minutes each, 5 cycles ∆T/R ) 2%, S.S. ) 1% Shock . . . . . . . . . . . . . 50G, 6ms, 6 directions, 3 times each ∆T/R ) 1%, S.S. ) 1% Vibration . . . . . . . . . . . . . . . . 10-2,000Hz, 1.5mm amplitude, 20G, 12 hours ∆T/R ) 1%, S.S. ) 1% Humidity . . . . . . . . . . . . . . . . . . . . . . . . 40 C, 90-95%RH, 0.75 watt, 1,000 hours ∆T/R ) 3%, S.S. ) 1% Moisture Resistance . . . . . . 10 C to 65 C, 80-98%RH, 0.75 watt, 10 cycles, 240 hours ∆T/R ) 3% Soldering Heat Resistance . . . . . . . . . . . 350 C, 3 seconds ∆T/R ) 1% Seal Test . . . . . . . . . . . . . . . . . 85 C, hot water for 1 minute Rotational Life . . . . . . . . . . 200 cycles without discontinuity ∆T/R ) 3% ∆T/R = Total Resistance Change; S.S. = Setting Stability ( voltage ratio ) Insulation Resistance . . . . . 1,000M Ω minimum at 500VDC Dielectric Strength . . . . . . . . . . . . . . . . . 900VAC, 1 minute Adjustment Travel . . . . . . . . . . . . . . . . . . . . . . . .15 3 turns Mechanical Mechanical Travel . . . . . . . . . . . . . . . . . . . . . . . .15 3 turns Shaft Torque . . . . . . . . . . . . . . . 300 gf • cm (4.16 oz • in) max. Stop Strength . . . . . . . . . . . . . . . . . . . . . . . . . . Clutch action Flammability of Plastic Materials . . UL 94V-0 for housing; UL 94HB for knob Nominal Weight . . . . . . . . . . . . . . . . . . . . 1.1g (P); 1.3g (PK ) 1.7g (PK1 with knob attached & PK2) Marking . . . . . . . . . . . . . . . . . . . Resistance code, date code, model type, wiring diagram TOCOS AMERICA, INC. 1177 East Tower Road, Schaumburg, IL 60173 Tel: 847-884-6664 Fax: 847-884-6665 E-mail: sales@tocos.com www.tocos.com 107 RJC097 Series RJC097P Single-Slot, Short Shaft, Side Adjust Dimensions RJC097PK Short Shaft, Permanent Small Knob, Side Adjust Unit: mm 1.5 0.2 4.7 Ø 2.8 0.2 0.3 2.6 Ø 4.7 0.2 4.7 0.3 0.3 0.1 0.6 6.4 0.4 0.1 0.6 4.7 0.3 0.1 6.4 0.4 4.7 0.6 (3) 0.4 (3) 0.1 0.3 0.3 0.2 0.6 (3) 0.4 (3) 0.1 0.5 0.2 (4) 0.3 0.1 0.1 5.0 1.0 0.5 0.2 (4) 0.3 0.2 0.3 0.1 5.0 1.0 5.1 0.3 0.1 5.1 0.3 12.7 0.3 3.5 0.3 2.5 0.3 12.7 0.3 3.5 0.3 2.5 0.3 19.0 0.5 19.0 0.5 4.7 0.3 #1 #2 #3 4.7 0.3 #1 #2 #3 18 18 RJC097PK1 Single-Slot, Extended Shaft, Side Adjust, Removable Large Knob ( same knob as PK2) RJC097PK2 Extended Shaft, Permanent Large Knob, Side Adjust 5.3 1.0 4.7 0.3 12.0 0.5 Ø 8.8 0.3 3.0 0.5 2.0 0.8 Ø 3.7 Ø4.0 1.0 0.6 6.4 0.4 0.1 Ø 2.6 0.05 4.7 0.2 (4) 6.4 0.3 0.4 4.7 0.6 (3) 0.4 (3) 0.1 0.3 0.3 0.2 0.6 (3) 0.4 (3) 0.1 0.5 0.3 0.1 0.1 5.0 1.0 0.5 0.2 (4) 0.3 0.2 0.3 0.1 0.1 5.0 1.0 5.1 0.3 5.1 0.3 12.7 0.3 3.5 0.3 2.5 0.3 12.7 0.3 3.5 0.3 2.5 0.3 19.0 0.5 19.0 0.5 4.7 0.3 #1 #2 #3 4.7 0.3 #1 #2 #3 Ø 6.2 Ø 6.7 18 18 The knob shipped with the PK1 is the same style and size as the PK2 knob. With the knob attached, the dimensions and weight of PK1 are the same as the PK2 model. Recommended PCB Layout P, PK, PK1 & PK2 Pin-Out Ø1.0 Electrical Schematic Unit: mm clockwise max. (3 holes) 5.0 #1 #3 2.5 #2 12.7 ccw #1 #3 cw #2 wiper 108 1177 East Tower Road, Schaumburg, IL 60173 TOCOS AMERICA, INC. Tel: 847-884-6664 Fax: 847-884-6665 E-mail: sales@tocos.com www.tocos.com RJC097 Series RJC097 P K1 B 102 K Part Numbering System Resistance Tolerance: K = 10%; M = 20% Resistance Code: Expressed in ohms. A three digit code where the first two digits are significant figures, and the third digit indicates the number of zeros that follow these figures (i.e., 100 = 10 Ω ; 101 = 100 Ω ; 102 = 1,000 Ω ; 105 = 1,000,000 Ω ). Resistance Taper: B = Linear. Adjustment Knob: K = Permanent Small Knob, Short Shaft. K1 = Removable Large Knob, Extended Shaft, Single-Slot. K 2 = Permanent Large Knob, Extended Shaft. Blank = No Knob, Short Shaft, Single-Slot. Terminal Style: P = 3 -Lead Configuration. TOCOS Series Name. Part Numbers Nominal Resistance Value ( Ω ) Code Catalog No. Bulk Resistance Tolerance 10% Resistance Tolerance 20% Potentiometer Styles RJC097P Through-Hole, P Terminal Style, Single-Slot, Short Shaft, Side Adjust 10 20 50 100 200 500 1,000 2,000 5,000 10,000 20,000 50,000 100,000 200,000 500,000 1,000,000 100 200 500 101 201 501 102 202 502 103 203 503 104 204 504 105 RJC097P RJC097P RJC097P RJC097P RJC097P RJC097P RJC097P RJC097P RJC097P RJC097P RJC097P RJC097P RJC097P RJC097P RJC097P RJC097P B B B B B B B B B B B B B B B B 100 200 500 101 201 501 102 202 502 103 203 503 104 204 504 105 K K K K K K K K K K K K K K K K RJC097P RJC097P RJC097P RJC097P RJC097P RJC097P RJC097P RJC097P RJC097P RJC097P RJC097P RJC097P RJC097P RJC097P RJC097P RJC097P B B B B B B B B B B B B B B B B 100 200 500 101 201 501 102 202 502 103 203 503 104 204 504 105 M M M M M M M M M M M M M M M M RJC097P RJC097PK Through-Hole, P Terminal Style, Short Shaft, Permanent Small Knob, Side Adjust 10 20 50 100 200 500 1,000 2,000 5,000 10,000 20,000 50,000 100,000 200,000 500,000 1,000,000 100 200 500 101 201 501 102 202 502 103 203 503 104 204 504 105 RJC097PK RJC097PK RJC097PK RJC097PK RJC097PK RJC097PK RJC097PK RJC097PK RJC097PK RJC097PK RJC097PK RJC097PK RJC097PK RJC097PK RJC097PK RJC097PK B B B B B B B B B B B B B B B B 100 200 500 101 201 501 102 202 502 103 203 503 104 204 504 105 K K K K K K K K K K K K K K K K RJC097PK RJC097PK RJC097PK RJC097PK RJC097PK RJC097PK RJC097PK RJC097PK RJC097PK RJC097PK RJC097PK RJC097PK RJC097PK RJC097PK RJC097PK RJC097PK B B B B B B B B B B B B B B B B 100 200 500 101 201 501 102 202 502 103 203 503 104 204 504 105 M M M M M M M M M M M M M M M M RJC097PK TOCOS AMERICA, INC. 1177 East Tower Road, Schaumburg, IL 60173 Tel: 847-884-6664 Fax: 847-884-6665 E-mail: sales@tocos.com www.tocos.com 109 RJC097 Series Nominal Resistance Value ( Ω ) Code Part Numbers Catalog No. Bulk Resistance Tolerance 10% Resistance Tolerance 20% Potentiometer Styles RJC097PK1 Through-Hole, P Terminal Style, Single-Slot, Extended Shaft, Removable Large Knob, Side Adjust 10 20 50 100 200 500 1,000 2,000 5,000 10,000 20,000 50,000 100,000 200,000 500,000 1,000,000 100 200 500 101 201 501 102 202 502 103 203 503 104 204 504 105 RJC097PK1 RJC097PK1 RJC097PK1 RJC097PK1 RJC097PK1 RJC097PK1 RJC097PK1 RJC097PK1 RJC097PK1 RJC097PK1 RJC097PK1 RJC097PK1 RJC097PK1 RJC097PK1 RJC097PK1 RJC097PK1 B B B B B B B B B B B B B B B B 100 200 500 101 201 501 102 202 502 103 203 503 104 204 504 105 K K K K K K K K K K K K K K K K RJC097PK1 RJC097PK1 RJC097PK1 RJC097PK1 RJC097PK1 RJC097PK1 RJC097PK1 RJC097PK1 RJC097PK1 RJC097PK1 RJC097PK1 RJC097PK1 RJC097PK1 RJC097PK1 RJC097PK1 RJC097PK1 B B B B B B B B B B B B B B B B 100 200 500 101 201 501 102 202 502 103 203 503 104 204 504 105 M M M M M M M M M M M M M M M M RJC097PK1 RJC097PK2 Through-Hole, P Terminal Style, Extended Shaft, Permanent Large Knob, Side Adjust 10 20 50 100 200 500 1,000 2,000 5,000 10,000 20,000 50,000 100,000 200,000 500,000 1,000,000 100 200 500 101 201 501 102 202 502 103 203 503 104 204 504 105 RJC097PK2 RJC097PK2 RJC097PK2 RJC097PK2 RJC097PK2 RJC097PK2 RJC097PK2 RJC097PK2 RJC097PK2 RJC097PK2 RJC097PK2 RJC097PK2 RJC097PK2 RJC097PK2 RJC097PK2 RJC097PK2 B B B B B B B B B B B B B B B B 100 200 500 101 201 501 102 202 502 103 203 503 104 204 504 105 K K K K K K K K K K K K K K K K RJC097PK2 RJC097PK2 RJC097PK2 RJC097PK2 RJC097PK2 RJC097PK2 RJC097PK2 RJC097PK2 RJC097PK2 RJC097PK2 RJC097PK2 RJC097PK2 RJC097PK2 RJC097PK2 RJC097PK2 RJC097PK2 B B B B B B B B B B B B B B B B 100 200 500 101 201 501 102 202 502 103 203 503 104 204 504 105 M M M M M M M M M M M M M M M M RJC097PK2 Packaging Standard: Bulk Packaging Quantity P & PK: 20 pieces per vinyl bag. 200 pieces per box. PK1 & PK 2: 10 pieces per vinyl bag. 100 pieces per box. Soldering and Cleaning Guidelines For soldering, cleaning and other information, refer to Guidelines and Precautions for Using Potentiometers. 110 1177 East Tower Road, Schaumburg, IL 60173 TOCOS AMERICA, INC. Tel: 847-884-6664 Fax: 847-884-6665 E-mail: sales@tocos.com www.tocos.com