TPDC500P-48B

36-72VDC INPUT RANGE DC-DC CONVERTER HOT-SWAP CompactPCI QUAD OUTPUT 500 WATTS ACTIVE CURRENT SHARING SWITCHING POWER SUPPLIES TPDC500P-48B SERIES FEATURES: 500W 6U X 8HP EUROCARD PACKAGE 36-72VDC NOMINAL 48VDC INPUT INTERNAL OR-ING DIODES FOR N+1 REDUNDANCY HOT-SWAPPABLE THIRD-WIRE CURRENT SHARING EMI MEET EN 55022 CLASS A CE MARKING COMPLIANCE FULLY COMPLIANT WITH PICMG TOTAL POWER INT'L SPECIFICATION INPUT SPECIFICATION Input Voltage: Typ. 36-72Vdc,nominal input 48Vdc. OVP shutdown at 75Vdc & UVP shutdown at 36Vdc. Input Connector: Positronic 47-pin PCIH47M400A1. Soft Start: Installed. Inrush Current: Typ. 11A @ 48Vdc. Input Current: 13.2A @ nominal input 48Vdc. Dielectric Withstand: Meet IEC950 regulation. Transient Protection: MOV withstands transient as specified by EN61000-4-4 level 3. EMI: Meet CISPR EN55022 Class A. Remote ON/OFF: Available at [INH#] & [EN#] pins. Power Fail Signal: Available at [FAL#] pin. Status LED: means valid input voltage. means a critical fault. Thermal Protection (OTP): Installed NTC for thermal sensor at [DEG#] pin. Thermostat will shutdown the PSU if >100°C. Overload Protection (OLP): Fully protected against output overload or short circuit. Typ. set at 120-150% max. load. Consult the factory for special OLP setting. OUTPUT SPECIFICATION Output Voltage: See Ratings Chart. Output Current: See Ratings Chart. Output Power: Typ. 500W continuous. Output Connector: Positronic 47-Pin PCIH47M400A1. Line Regulation: Typ. 0.1%. Load Regulation: VO1 & VO2 typ. ±0.5%. VO3 & VO4 typ. ±1.0-4.0%. Noise & Ripple: Typ. 1% peak-peak or 50mV,which is greater. OVP: Built-in at all outputs.(Latch). Adjustability: Available at VO1,VO2, VO3 & VO4. Output Trim: Electrical trim available at VO1/ VO2.[ADJ #]. Remote Sensing: Available at VO1,VO2 & VO3. Hot-Swap: Available. N+1 Redundancy: Available with OR-ing diodes at all outputs for N+1 redundancy. Current Sharing: Third-wire current sharing at VO1,2&3. Power OK Signal: Available for all outputs. Over Current Protection (OCP): Installed at each rail. GENERAL SPECIFICATION Efficiency: Typ. 80 %. Switching Frequency: 120K Hz. Circuit Topology: Forward circuit. Transient Response: Peak transient less than 220mV and recovers within 0.5mS after 50% load-change. Safety Standard: IEC60950. Construction: Eurocard 6U X 8HP X 160mm CompactPCI format. Front Panel with Extractor handle. Operating Temperature: -30 to +50 °C at full load with specified air flow. Derates linearly to 50% at +70 °C Storage Temperature: -40 to +85 °C. Temperature Coefficient: Typ. ±0.02% / °C. Cooling: At least 8lfm moving air is required to achieve full rating power 500W in a confined area. Power Density: 4.50 Watts/ Cubic Inch. Remark: All measurements are at nominal input, full load and +25°C unless otherwise specified. OUTPUT VOLTAGE/CURRENT RATINGS CHART QUAD OUTPUT MODEL NO. HDC500P-48B-490 MAIN +VO1 @★#≡⊙ Min. Typ. 0A 50A Volt. +5V Max. 60A AUX. +VO2 ▲@★#≡⊙ Min. 0A Typ. AUX. +VO3 ▲≡#⊙★@ AUX. –VO4 ▲⊙★@ Volt. Max. Min. Typ. Volt. Max. Pk. Min. Typ. Volt. Max. Pk. 0A 10A +12V 14A 15A 0A 3A -12V 4A 5A 30A +3.3V 60A Symbol: "★" OVP built-in. "@" Adjustable. "#" Remote sensing. "≡" 3rd-wire Load Sharing. "⊙" Installed with Or-ing diode. "▲" Magnetic Amplifier. "●" Installed with Post-regulator. "■" Common Choke. Remark: Peak load less than 60sec. with duty cycle