PS2K0-48

PS2K0 Series 2000 Watt Single Output PFC and Current Sharing AC/DC Switching Power Supply FEATURES ● Remote Sense ● Power Good Signal ● Remote ON/OFF Control ● 0.98 Typical Power Factor ● Programmable Output Voltage ● Forced Current Sharing at Parallel Operation ● Input Voltage: 90~260VAC (90 ~ 170VAC Reduced Power) ● Short Circuit/ Over Load/ Over Voltage/ Over Temperature Protection SPECIFICATIONS: PS2K0 Series All specifications are based on 25 C, Nominal Input Voltage, and Maximum Output Current unless otherwise noted. We reserve the right to change specifications based on technological advances. INPUT SPECIFICATIONS Input Voltage Range 90 ~ 260VAC **(90 ~ 170 VAC reduced power - see “Output Power vs Input Voltage” derating curve)** Input Frequency 47 to 63Hz Input Current 11.5A at 230VAC (Typical) Inrush Current 180A at 230VAC (Typical) Leakage Current < 10.5mA at 240VAC Remote ON/OFF Control Compatible with a TTL signal to turn ON/OFF OUTPUT SPECIFICATIONS Output Voltage See Table Output Power Range 2000 Watts max. +3.0% ~ -12% typical adjustment by potentiometer. Output Voltage Adjustability 20% ~ 100% adjustment by 1 ~ 5VDC external control. Line Regulation Less than 1% Load Regulation Less than 1% Output Current See Table Ripple & Noise (peak to peak) See Table Setup, Rise, Hold-Up Time 500ms, 250ms, 12ms at full load Temperature Coefficient ±0.04% / °C (0 ~ 50°C) Remote Sense Yes PROTECTION Over Voltage Protection 110% ~ 135% follow to output setup point (shutdown output voltage, re-power on to recover) Over Load Protection 105% ~ 115% rated output power (current limiting, delay shutdown output voltage, re-power on to recover) > 100°C / measure by heatsink near transformer (shutdown output voltage, recovers automatically after Over Temperature Protection temperature goes down. GENERAL SPECIFICATIONS Efficiency See Table Withstand Voltage 3KVAC (input to output); 1.5KVAC (input to field ground); 500VAC (output to field ground) Isolation Resistance 100M ohms / 500VDC (input to output, input to field ground, output to field ground) Power Factor 0.95 at 230VAC (Typical) Power Good Signal Open Collector NPN Transistor Special Function DC voltage Adj., Remote Sensing, Remote Control, Parallel Operation ENVIRONMENTAL SPECIFICATIONS Working Temperature 0°C to +50°C @ 100% Load, +65°C @ 50% Load. Storage Temperature -20°C to +85°C Working Humidity (non-condensing) 20% to 90% RH Storage Humidity 10% to 95% RH Vibration 10 ~ 200Hz, 2g 10 min./1cycle, Period of 60 min. for each axis. Cooling Power rating and temperature controlled fan. MTBF 74,900 hrs min. (MIL-HDBK-217F (25°C) PHYSICAL SPECIFICATIONS Weight 8.9kg Dimensions 320(L) x 212(W) x 124(H) mm SAFETY & EMC Safety Standards UL1950, TUV EN60950-1 Approved EMI Conduction & Radiation Compliance to EN55022 (CISPR22) class A Harmonic Current Compliance to EN61000-3-2,3 EMS Immunity Compliance to EN55024 o Wall Industries, Inc. 5 Watson Brook Road Exeter, NH 03833 603-778-2300 www.wallindustries.com Fax 603-778-9797 PS2K0 Series 2000 Watt Single Output PFC and Current Sharing AC/DC Switching Power Supply OUTPUT VOLTAGE / CURRENT RATING CHART Model Number PS2K0-09 PS2K0-12 PS2K0-15 PS2K0-18 PS2K0-24 PS2K0-36 PS2K0-48 PS2K0-60 Output Voltage 9 VDC 12 VDC 15 VDC 18 VDC 24 VDC 36 VDC 48 VDC 60 VDC Output Current 222A 166A 133A 111.1A 83A 55.5A 41A 33A Maximum Output Power 1998W 1992W 1995W 2000W 1992W 1998W 1968W 1980W Ripple & Noise 150mVp-p 150mVp-p 150mVp-p 180mVp-p 240mVp-p 360mVp-p 480mVp-p 600mVp-p Efficiency 83% 84% 85% 86% 88% 88% 89% 90% NOTES 1. Input voltage is 90 ~ 260VAC however, the unit does not reach full power until >170VAC. See derating curve below. 2. Dimensions of the mechanical drawing are shown in millimeters and inches. 3. Weight of the unit is 8900 grams. DERATING CURVES Wall Industries, Inc. 5 Watson Brook Road Exeter, NH 03833 603-778-2300 www.wallindustries.com Fax 603-778-9797 PS2K0 Series 2000 Watt Single Output PFC and Current Sharing AC/DC Switching Power Supply CONNECTOR PIN-OUT DRAWINGS Wall Industries, Inc. 5 Watson Brook Road Exeter, NH 03833 603-778-2300 www.wallindustries.com Fax 603-778-9797 PS2K0 Series 2000 Watt Single Output PFC and Current Sharing AC/DC Switching Power Supply MECHANICAL DRAWING Wall Industries, Inc. 5 Watson Brook Road Exeter, NH 03833 603-778-2300 www.wallindustries.com Fax 603-778-9797