AP2004SL

AP2004 PWM Buck Controller Features - PWM Buck Control Circuitry - Operating voltage can be up to 27V - Under voltage Lockout (UVLO) Protection - Short Circuit Protection (SCP) - Soft-start circuit - Variable Oscillator Frequency -- 300Khz Max - 1.25V voltage reference Output - 8-pin PDIP and SOP packages General Description The AP2004 integrates Pulse-Width-Modulation (PWM) control circuit into a single chip, mainly designs for power-supply regulator. All the functions include an on-chip 1.25V reference output, an error amplifier, an adjustable oscillator, a soft-start, UVLO, SCP circuitry, and a push-pull output circuit. Switching frequency is adjustable by trimming CT. During low VCC situation, the UVLO makes sure that the outputs are off until the internal circuit operates normally. Applications - Backlight inverter - LCD Monitor - XDROM, XDSL Product - DC/DC converters in computers, etc. Pin Assignment ( Top View ) OUT VCC COMP FB 1 2 3 4 8 7 6 5 Pin Descriptions Name GND CT SS SCP Description Timing Capacitor Voltage Feedback Soft-Start. Feedback Loop Compensation PWM Output Ground Supply Voltage Short Circuit Protection CT FB SS COMP OUT GND VCC SCP PDIP/SOP Ordering Information AP2004 X Package N: PDIP-8L S: SOP-8L X X Lead Free Packing Blank : Tube Blank : Normal L : Lead Free Package A : Taping This datasheet contains new product information. Anachip Corp. reserves the rights to modify the product specification without notice. No liability is assumed as a result of the use of this product. No rights under any patent accompany the sale of the product. Rev. 0.4 Arpr 6, 2004 1/8 AP2004 PWM Buck Controller Block Diagram VCC SS CT 1.25V Bandgap Reference 2.5V Internal use UVLO Oscillator VCC MAX.500KHz Iss PWM Amplifier FB + + Error Amplifier COMP 1.5V + 0.7V + OUT SCP GND Absolute Maximum Ratings Symbol VCC VI VO ISOURCE ISINK TOP TST TLEAD Supply voltage Amplifier input voltage Collector output voltage Source current Sink current Operating temperature range Storage temperature range Lead temperature 1.6 mm(1/16 inch) from case for 10 seconds Parameter Rating 28 20 VCC-1.0V 200 200 -20 to +85 -65 to +150 260 Unit V V V mA mA o o o C C C Anachip Corp. www.anachip.com.tw 2/8 Rev. 0.4 Apr 6, 2004 AP2004 PWM Buck Controller Recommended Operating Conditions Symbol VCC VI VO IFB RF CT FOSC TOP Supply voltage Amplifier input voltage Collector output voltage Current into feedback terminal Feedback resistor Timing capacitor Oscillator frequency Operating free-air temperature =6V, f=200 Khz) Parameter Min. 3.6 1.05 Max. 27 1.45 Vcc-1.5 45 Unit V V V µA kΩ pF KHz ºC 100 100 10 -20 6800 300 85 Electrical Characteristics (T =25ºC, V A CC Reference (REF) Symbol Parameter Comp connect to FB VREF Output voltage change with temperature Under voltage lockout (UVLO) Symbol Parameter VUT Upper threshold voltage (VCC) VLWT Lower threshold voltage (VCC) VHT Hysteresis (VCC) Short-circuit protection (SCP) control Symbol Parameter VIT Input threshold voltage VSTB Standby voltage VLT Latched input voltage ISCP Input (source) current Comparator threshold voltage VCT (COMP) Oscillator (OSC) Symbol Parameter FOSC Frequency Standard deviation of frequency ∆FOSC Frequency change with voltage Conditions TA = -20ºC ~ 25ºC TA = 25ºC ~ 85ºC Conditions IO(REF) = 0.1mA TA = 25ºC Conditions TA = 25ºC No pull up No pull up VI = 0.7V, TA = 25ºC Min. 1.225 Typ. 1.25 -0.1 -0.2 Typ. 2.9 2.4 500 Typ. 0.67 130 50 -15 1.5 Max. 1.275 ±1 ±1 Max. Unit V % % Unit V V mV Unit V mV mV µA V Min. Min. 0.60 100 -10 Max. 0.75 160 100 -20 Conditions CT =270 pF CT =270 pF VCC=3.6V ~ 20V Min. Typ. 200 10 1 Max. Unit KHz % Anachip Corp. www.anachip.com.tw 3/8 Rev. 0.4 Apr 6, 2004 AP2004 PWM Buck Controller Electrical Characteristics (Continued) (T =25ºC, V A CC =6V, f=200 Khz) Error-amplifier Symbol Parameter VIO Input offset voltage IIO Input offset current IIB Input bias current Common-mode input voltage VCM range Open-loop voltage AV amplification GBW Unity-gain bandwidth CMRR Common-mode rejection ratio VOH Max. output voltage VOL Min. output voltage IOI Output (sink) current (COMP) Output (source) current IOO (COMP) Output section Symbol Parameter ILEAK IDRV VSAT Leakage current Sink current Source current Output saturation voltage Conditions VO (FB)=1.25V VO (FB)=1.25V VO (FB)=1.25V VCC=3.6V ~ 20V RF=200 kΩ Min. Typ. 160 1.05 70 60 Vref-0.1 80 1.5 80 Max. ±6 ±100 500 1.45 Unit mV nA nA V dB MHz dB V V mA µA 1 VID = -0.1V, VO = 1.25V VID = 0.1V, VO = 1.25V Conditions VO = 25V VIN= 20V VIN= 20V IO = 10 mA VO = 6V Conditions CT Maximum duty cycle Conditions CT = 270pF Conditions Min. 1.2 Min. Min. 200 200 1.0 120 Typ. 0.6 1.3 Typ. 6 Typ. 2.3 20 Max. 10 Max. Max. 0.7 1.5 0.5 -45 Min. 1.6 -70 Typ. Max. 10 Unit µA mA mA V mA Unit V V Unit mA Unit V µA ISC Short-circuit output current PWM comparator Symbol Parameter VT0 VT100 Total device Symbol ICCA Soft Start Symbol VSS ISS Input threshold voltage at f = 10 KHz (COMP) Parameter Average supply current Parameter Soft-start Voltage Constant Charge Current Anachip Corp. www.anachip.com.tw 4/8 Rev. 0.4 Apr 6, 2004 AP2004 PWM Buck Controller Typical Application Circuit R3 10K~100K Vcc = 12V C2 10nF Optional 1 OUT GND 8 2 VCC CT 7 COMP SS 6 FB SCP 5 C4 270pF C5 50nF C6 220nF 4 3 Q1 P mos C1 470uF L1 33uH R1 9K Output C4 50nF Optional 5A C3 470uF R2 3K Step-Down DC/DC converter Typical Characteristics REFERENCE OUTPUT VOLTAGE v.s. POWER-SUPPLY VOLTAGE 1.26 1.255 1.25 1.245 1.24 1.235 1.23 1.225 1.22 4 8 12 16 20 24 28 AVERAGE SUPPLY CURRENT v.s. POWER-SUPPLY VOLTAGE 5 VrefReference Output Voltage (V) Icc-Average Supply Current (mA) 4 3 2 1 0 0 4 8 12 16 20 24 28 Vcc-Power Supply Voltage (V) Vcc - Power-Supply Voltgae (V) VCT(min) VCT(max) AVERAGE SUPPLY CURRENT v.s. AMBIENT TEMPERATRUE 7 6 5 4 3 2 -50 -25 0 25 50 75 100 VCT v.s. Frequency 1.6 1.4 1.2 1 0.8 0.6 0.4 0.2 0 0 100 200 ICC - Average Supply Current (mA) VCT (V) 300 TA - Ambient Temperatrure(℃) Frequency (KHz) Anachip Corp. www.anachip.com.tw 5/8 Rev. 0.4 Apr 6, 2004 AP2004 PWM Buck Controller Typical Characteristics (Continued) OSCILLATOR FREQUENCY v.s. TIMING CAPACITANCE tscp-SCP Time-out Period (ms) 350 35 30 25 20 15 10 5 0 45 SCP TIME-OUT PERIOD v.s. SCP CAPACITANCE fosc - Frequency (KHz) 300 250 200 150 100 50 0 100 600 1100 1600 2100 2600 3100 3600 4100 4600 5100 5600 6100 6600 90 135 180 225 270 315 360 405 450 495 CT-Timing Capacitor (pF) Cscp - SCP Capacitance (nF) SOFT-START TIME (Ts) v.s. SOFT-START CAPACITOR (Css) 30 25 Ts (mS) 20 15 10 5 0 25 50 75 100 125 150 175 200 Css (nF) Marking Information (Top View) 8 5 Logo Part No. AC AP2004 YY WW X X 1 4 ID code Blank: normal L: Lead Free Package Xth week: 01~52 Year: "01" =2001 "02" =2002 ~ PDIP/SOP Anachip Corp. www.anachip.com.tw 6/8 Rev. 0.4 Apr 6, 2004 AP2004 PWM Buck Controller Package Information (1) PDIP-8L (Plastic Dual-in-line Package ) D E-PIN O0.118 inch E1 E 15 (4X) PIN #1 INDENT O0.025 DEEP 0.006-0.008 inch 7 (4X) eB A2 A C L B S e B1 B2 Symbol A A1 A2 B B1 B2 C D E E1 e L eB S Dimensions in millimeters Min. Nom. Max. 5.33 0.38 3.1 3.30 3.5 0.36 0.46 0.56 1.4 1.52 1.65 0.81 0.99 1.14 0.20 0.25 0.36 9.02 9.27 9.53 7.62 7.94 8.26 6.15 6.35 6.55 2.54 2.92 3.3 3.81 8.38 8.89 9.40 0.71 0.84 0.97 A1 Dimensions in inches Min. Nom. Max. 0.210 0.015 0.122 0.130 0.138 0.014 0.018 0.022 0.055 0.060 0.065 0.032 0.039 0.045 0.008 0.010 0.014 0.355 0.365 0.375 0.300 0.313 0.325 0.242 0.250 0.258 0.100 0.115 0.130 0.150 0.330 0.350 0.370 0.028 0.033 0.038 Anachip Corp. www.anachip.com.tw 7/8 Rev. 0.4 Apr 6, 2004 AP2004 PWM Buck Controller Package Information (Continued) (2) SOP- 8L(JEDEC Small Outline Package) E H L VIEW "A" D 7 (4X) A2 A 0.015x45 7 (4X) A1 e B y C VIEW "A" Symbol A A1 A2 B C D E e H L y θ Dimensions In Millimeters Min. Nom. Max. 1.40 1.60 1.75 0.10 0.25 1.30 1.45 1.50 0.33 0.41 0.51 0.19 0.20 0.25 4.80 5.05 5.30 3.70 3.90 4.10 1.27 5.79 5.99 6.20 0.38 0.71 1.27 0.10 0O 8O Dimensions In Inches Min. Nom. Max. 0.055 0.063 0.069 0.040 0.100 0.051 0.057 0.059 0.013 0.016 0.020 0.0075 0.008 0.010 0.189 0.199 0.209 0.146 0.154 0.161 0.050 0.228 0.236 0.244 0.015 0.028 0.050 0.004 0O 8O Anachip Corp. www.anachip.com.tw 8/8 Rev. 0.4 Apr 6, 2004