VR102B150CU

DC/DC Converter DC/DC Converter Programmable, Single Output, 1.1V - 1.85Vout @ 60A Programmable, Single Output, 0.8375 - 1.600Vout @ 150A Features • • • • • • Meets VRM 10.1 and 10.2 Requirements DAC Programmable Output Voltage Power Good Output Differential Remote Sense Remote Enable Supervisory Functions • Output Overcurrent • Short Circuit Protection • Overtemperature Indicator • Output Current Level Signal Tri-state Output when Disabled Dynamic VID Capability 1U Form Factor (1.250” total mating height) LL0 / LL1 Function Table 1: Input Characteristics Input Voltage Operating Range Input Undervoltage Lockout Turn-on Threshold Turn-off Threshold Hysteresis Voltage Maximum Input Current VRM 10.1 Levels Maximum Input Current VRM 10.2 Levels No-Load Input Current Disabled Input Current Enable - Positive Logic Version LL0 and LL1 Typical: 105A 1.325VID Max: 120A 1.6VID Typical: 130A 1.325VID Max: 150A 1.6VID Enable state, no Load Disabled State On State Range Off State Range High State Range Low State Range Table 2: Output Characteristics Output Voltage Set Point Output Line Regulation Output Load Regulation Output Voltage Total Regulation Output Ripple Voltage & Noise (2) Output Current Operating Range Efficiency for 10.1 TDP Efficiency for 10.2 TDP Io = 105 Amps VID = 1.325 Io = 130 Amps VID = 1.325 20 MHz Bandwidth 0 86 84 87 85.5 6.4 150 Adjustable Notes and Conditions (1) 6-Bit DAC Controlled Min 0.8375 -5 0.91 0 Typ Max 1.600 5 1.25 VID-40 Units Vdc mV mΩ mV mVp-p A % % Notes and Conditions (1) Min 11.04 6.5 5.4 0.7 Typ 12.0 6.9 6.0 0.9 13 18 15.3 200 20 0.8 -0.3 0.8 -0.3 320 30 21 400 50 Vin 0.4 3.5 0.4 A mA mA Vdc Vdc Vdc Vdc Max 12.60 7.3 6.6 1.1 Units Vdc Vdc Vdc Vdc A • • • • 1150 Eglinton Avenue East Toronto, Ontario M3C 1H7 1-866-740-1232 www.cdtechno-cps.com 4607 S.E. International Way Milwaukie, Oregon 97222 1-971-206-2800 1 of 4 VR102B150CU_084-20882-04_RevB_Nov12-2004.fm DC/DC Converter DC/DC Converter Programmable, Single Output, 1.1V - 1.85Vout @ 60A Programmable, Single Output, 0.8375 - 1.600Vout @ 150A Table 2: Output Characteristics Turn-on Time Transient Response (3) Remote Sense Compensation Range (4) Recommended Bulk Output Capacitance for 10.1 Applications Recommended Bulk Output Capacitance for 10.2 Applications Notes and Conditions (1) Vin present: Enable to 90% Vout 100A step, 100A/µS, ΔVo, Adjustable 81 Min Typ Max 50 135 300 UCC 4PS560MH11 or equivalent UCC 4PS560MH11 or equivalent 14 16 Units mS mV mV EA EA Table 3: Protection Characteristics Output Overcurrent Shutdown Overvoltage Shutdown Overtemperature Indicator Load Indicator Notes and Conditions (1) Latching Latching, Above VID Non-Latching, at hot spots Worst case junction temperature VID = 1.325, 0 A Load, LL1 = 1 VID = 1.325, 100 A Load, LL1 = 1 VID = 1.325, 0A Load, LL1 = 0 VID = 1.325, 100A Load, LL1 = 0 Table 4: General Characteristics Storage Temperature Range Operating Temperature Range Semiconductor Junction Temperature Material Flammability MTBF Package rated to 150°C UL 94V-0 Calculated (RAC PRISM) 45°C Demonstrated Switching Frequency Dimensions Weight Table 5: Adaptive Voltage Positioning Voltage Droop for 100A Load (linear) Notes and Conditions (1) LL0 = X, LL1 = 0 LL0 = X, LL1 = 1 Min Typ 125 91 Max Units mV Per phase 3.8”L x 1.18”H x 1.0”W 59 g 300 0.93 x106 Hrs x106 Hrs KHz Notes and Conditions (1) Non-condensing Min -40 0 Typ Max 70 60 115 Units °C °C °C Min 155 90 125 1 3 1 3.75 Typ Max 210 200 Units A mV °C V 1150 Eglinton Avenue East Toronto, Ontario M3C 1H7 1-866-740-1232 www.cdtechno-cps.com 4607 S.E. International Way Milwaukie, Oregon 97222 1-971-206-2800 2 of 4 VR102B150CU_084-20882-04_RevB_Nov12-2004.fm DC/DC Converter DC/DC Converter Programmable, Single Output, 1.1V - 1.85Vout @ 60A Programmable, Single Output, 0.8375 - 1.600Vout @ 150A Notes: 1. Vin = 12Vdc, Ta = 25°C, Airflow = 400LFM unless otherwise noted. 2. Output Ripple Voltage is specified when measured with Intel specified capacitance at the output of the converter. 3. Transient response is specified with Intel specified capacitors at the output of the converter. 4. If remote sense is not required or used, the Sense(+) and Sense(-) pins must be connected to Vo(+) and Vo(-) respectively. 5. User will select the appropriate Load Line through the LL0 and LL1 signals. LL0 and LL1 signals are TTL compatible. The default state is a 1.25mOhm Load Line. 6. VRM_PRES and VRM_ID are connected to Vss on the VRM. Mechanical Information Figure 1 Recommended Interface Connector Options Tyco/Elcon 283-0172-01303 (Solder Tail, Long) 283-0172-02303 (Solder Tail, Short) 284-0202-03003 (Surface Mount) 1150 Eglinton Avenue East Toronto, Ontario M3C 1H7 1-866-740-1232 www.cdtechno-cps.com 4607 S.E. International Way Milwaukie, Oregon 97222 1-971-206-2800 3 of 4 VR102B150CU_084-20882-04_RevB_Nov12-2004.fm DC/DC Converter DC/DC Converter Programmable, Single Output, 1.1V - 1.85Vout @ 60A Programmable, Single Output, 0.8375 - 1.600Vout @ 150A Pin Assignment (6) VRM_Pres (6) VRM_ID Figure 2 Ordering Information VR102B150CU Family Name VRM Spec 102 = 10.2 (Also meets 10.1) Input Voltage B = 12Vin Form Factor U = “1U” Mounting Type C = Card-edge Peak Current 150 = 150A Model# VR10150CU is backwards compatible to Model# VR101B120CU (no longer available). C&D Technologies, Inc. reserves the right to alter or improve the specification, internal design or manufacturing process at any time, without notice. Please check with your supplier or visit our website to ensure that you have the current and complete specification for your product before use. © C&D Technologies, Inc. 2004 No part of this publication may be copied, transmitted, or stored in a retrieval system or reproduced in any way including, but not limited to, photography, photocopy, magnetic or other recording means, without prior written permission from C&D Technologies, Inc. Instructions for use are available from: www.cdtechno-cps.com 1150 Eglinton Avenue East Toronto, Ontario M3C 1H7 1-866-740-1232 www.cdtechno-cps.com 4607 S.E. International Way Milwaukie, Oregon 97222 1-971-206-2800 4 of 4 VR102B150CU_084-20882-04_RevB_Nov12-2004.fm