AE15-EW-S24

Additional Resources: Product Page date 02/02/2023 page 1 of 7 SERIES: AE15-EW Ϳ DESCRIPTION: DC-DC CONVERTER FEATURES U ED 15 watts high operating temp -40 to +70°C 4,000 Vac isolation extra wide input voltage 10:1 input voltage up to 1 kVdc OVP protection output short circuit protection board mounted EN 62109 approved MODEL N • • • • • • • • • output voltage output current output power ripple & noise1 HϒFLHQF\2 range (Vdc) (Vdc) min (A) max (A) max (W) max (mVp-p) W\S (%) AE15-EW-S12 100~1000 12 0 1.25 15 200 77 AE15-EW-S15 100~1000 15 AE15-EW-S24* 100~1000 24 0 1.00 15 200 78 0 0.625 15 200 80 TI input voltage 1. Measured at nominal input, 20 MHz bandwidth oscilloscope, with 10 µF electrolytic and 1 µF ceramic capacitors on the output. 2. Measured at 200 Vdc input voltage, full load. $OOVSHFL¿FDWLRQVDUHPHDVXUHGDW7D ƒ&KXPLGLW\QRPLQDOLQSXWYROWDJHDQGUDWHGRXWSXWORDGXQOHVVRWKHUZLVHVSHFL¿HG 4. * Discontinued model. O PART NUMBER KEY N Notes: Output Voltage Base Number D IS C AE15-EW - SXX cui.com Additional Resources: Product Page CUI Inc Ϳ SERIES: AE15-EW Ϳ DESCRIPTION: DC-DC CONVERTER date 02/02/2023 Ϳ page 2 of 7 INPUT parameter conditions/description min W\S 100 current at 200 Vdc at 600 Vdc at 1000 Vdc inrush current at 200 Vdc at 600 Vdc at 1000 Vdc input fuse 2 A / 1000 Vdc (external) max units 1000 Vdc 120 40 22 mA mA mA ED operating input voltage 7 20 30 OUTPUT conditions/description maximum capacitive load 12 Vdc output model 15 Vdc output model 24 Vdc output model min W\S max units 2,000 1,200 470 Nj) Nj) Nj) ±1 ±2 % U parameter N voltage accuracy A A A from low line to high line, full load ±0.5 ±1 % load regulation from 0% to full load ±0.5 ±1 % delay time IURP9LQ 9WRRIUDWHGRXSWXWYROWDJH 1 s switching frequency WHPSHUDWXUHFRHϒFLHQW at full load PROTECTIONS TI line regulation conditions/description min over voltage protection 12 Vdc output model 15 Vdc output model 24 Vdc output model over current protection automatic recovery short circuit protection continuous, automatic recovery O N parameter 75 ±0.02 W\S kHz %/°C max units 15 19 28 Vdc Vdc Vdc 110 % SAFETY AND COMPLIANCE parameter conditions/description min input to output for 1 minute W\S 4,000 max units Vac C isolation voltage EN 62109 conducted emissions CISPR22/EN55022, class A (external circuit required, see Figure 2) radiated emissions CISPR22/EN55022, class A (external circuit required, see Figure 2) ESD IEC/EN61000-4-2, contact ± 6kV/air ± 8kV, class B IS safety approvals IEC/EN61000-4-3, 10V/m, class A ()7EXUVW IEC/EN61000-4-4, ± 4kV, class B (external circuit required, see Figure 2) surge IEC/EN61000-4-5, ± 2kV, class B (external circuit required, see Figure 2) conducted immunity IEC/EN61000-4-6, 10 Vr.m.s, class A 07%) as per MIL-HDBK-217F, 25°C RoHS 2011/65/EU D radiated immunity 300,000 cui.com hours Additional Resources: Product Page CUI Inc Ϳ SERIES: AE15-EW Ϳ DESCRIPTION: DC-DC CONVERTER date 02/02/2023 Ϳ page 3 of 7 ENVIRONMENTAL parameter conditions/description min max units operating temperature see derating curves -40 70 °C -40 105 °C 95 % 2000 m storage temperature non-condensing ED storage humidity W\S altitude SOLDERABILITY parameter conditions/description min W\S max units hand soldering for 3~5 seconds 350 360 370 °C wave soldering for 5~10 seconds 255 260 265 °C max units U MECHANICAL conditions/description dimensions 70.00 x 48.00 x 23.50 [2.756 x 1.890 x 0.925 inch] case material EODFNÀDPHUHWDUGDQWKHDWSURRISODVWLF8/9 weight units: mm [inch] tolerance: ±0.50[±0.020] pin diameter tolerance: ±0.10[±0.004] 3,1&211(&7,216 NC 2 -Vin 3 +Vin 4 +Vout 5 -Vout D IS C 1& QRFRQQHFWLRQ O 1 95 N Function W\S TI MECHANICAL DRAWING PIN min N parameter Recommended PCB Layout 7RS9LHZ cui.com mm g Additional Resources: Product Page CUI Inc Ϳ SERIES: AE15-EW Ϳ DESCRIPTION: DC-DC CONVERTER date 02/02/2023 Ϳ page 4 of 7 C O N TI N U ED DERATING CURVES D IS EFFICIENCY CURVES cui.com Additional Resources: Product Page CUI Inc Ϳ SERIES: AE15-EW Ϳ DESCRIPTION: DC-DC CONVERTER date 02/02/2023 Ϳ page 5 of 7 D IS C O N TI N U ED EFFICIENCY CURVES (CONTINUED) cui.com Additional Resources: Product Page CUI Inc Ϳ SERIES: AE15-EW Ϳ DESCRIPTION: DC-DC CONVERTER date 02/02/2023 Ϳ page 6 of 7 APPLICATION CIRCUIT Table 1 Fuse MOV 17& 12 2 A / 1000 Vdc S14K880 10D-11 15 2 A / 1000 Vdc S14K880 24 2 A / 1000 Vdc S14K880 C1 (µF) C2 (µF) 796 1 120 SMBJ15A N Vout (Vdc) U ED Figure 1 1 120 SMBJ20A 10D-11 1 68 SMBJ33A TI 10D-11 N EMC RECOMMENDED CIRCUIT D IS C O Figure 2 1RWHV Table 2 Recommended External Circuit Components FUSE 2 A/1000 Vdc MOV S14K880 C3, C4, C5, C6 47 µF/400 Vdc R1, R2, R3, R4 0ƻ: 17& 10D-11 LDM 4.7 mH/0.38 A LCM 10 mH 1RWH6HHDOVR7DEOH &LVDFHUDPLFFDSDFLWRUXVHGWR¿OWHUKLJKIUHTXHQF\QRLVH 2. C2 is electrolytic and is recommended to be high frequency and low resistance. For capacitance and current of the capacitor, refer to the datasheet provided by the manufacturer. Capacitance withstand voltage derating should be 80% or above. cui.com Additional Resources: Product Page CUI Inc Ϳ SERIES: AE15-EW Ϳ DESCRIPTION: DC-DC CONVERTER date 02/02/2023 Ϳ page 7 of 7 REVISION HISTORY rev. description date 09/13/2017 initial release company logo updated 1.02 GHUDWLQJFXUYHVHϒFLHQF\FXUYHVDQGFLUFXLW¿JXUHVXSGDWHG 07/29/2021 discontinued AE15-EW-S24 02/02/2023 1.03 ED 1.0 1.01 04/12/2021 D IS C O N TI N U 7KHUHYLVLRQKLVWRU\SURYLGHGLVIRULQIRUPDWLRQDOSXUSRVHVRQO\DQGLVEHOLHYHGWREHDFFXUDWH Headquarters 20050 SW 112th Ave. 7XDODWLQ25 800.275.4899 Fax 503.612.2383 cui.com techsupport@cui.com &8,RϑHUVDWZR\HDUOLPLWHGZDUUDQW\&RPSOHWHZDUUDQW\LQIRUPDWLRQLVOLVWHGRQRXUZHEVLWH CUI reserves the right to make changes to the product at any time without notice. Information provided by CUI is believed to be accurate and reliable. However, no responsibility is assumed by CUI for its use, nor for any infringements of patents or other rights of third parties which may result from its use. CUI products are not authorized or warranted for use as critical components in equipment that requires an extremely high level of reliability. A critical component is any component of a OLIHVXSSRUWGHYLFHRUV\VWHPZKRVHIDLOXUHWRSHUIRUPFDQEHUHDVRQDEO\H[SHFWHGWRFDXVHWKHIDLOXUHRIWKHOLIHVXSSRUWGHYLFHRUV\VWHPRUWRDϑHFWLWVVDIHW\RUHϑHFWLYHQHVV