AE15-UW-S12

Additional Resources: Product Page date 08/17/2021 page 1 of 7 SERIES: AE15-UW Ϳ DESCRIPTION: DC-DC CONVERTER FEATURES MODEL U ED 15 watts high operating temp -40 to +70°C 4,000 Vac isolation designed to meet UL 1741; EN 62109 approved board mounted input voltage range of 200~1,500 Vdc low ripple & noise OVP protection output short circuit protection N • • • • • • • • • output voltage output current output power ripple & noise1 HϒFLHQF\2 range (Vdc) (Vdc) min (A) max (A) max (W) max (mVp-p) W\S (%) AE15-UW-S12 200~1500 12 0 1.25 15 300 71 AE15-UW-S15 200~1500 15 AE15-UW-S24 200~1500 24 0 1.00 15 300 72 0 0.625 15 300 74 TI input voltage 1. Measured at nominal input, 20 MHz bandwidth oscilloscope, with 10 µF electrolytic and 1 µF ceramic capacitors on the output. 2. Measured at 800 Vdc input voltage, full load. $OOVSHFL¿FDWLRQVDUHPHDVXUHGDW7D ƒ&KXPLGLW\QRPLQDOLQSXWYROWDJHDQGUDWHGRXWSXWORDGXQOHVVRWKHUZLVHVSHFL¿HG O PART NUMBER KEY N Notes: Output Voltage Base Number D IS C AE15-UW - SXX cui.com Additional Resources: Product Page CUI Inc Ϳ SERIES: AE15-UW Ϳ DESCRIPTION: DC-DC CONVERTER date 08/17/2021 Ϳ page 2 of 7 INPUT parameter conditions/description min under voltage shutdown shut-down range turn-on range current at 200 Vdc at 800 Vdc at 1500 Vdc inrush current at 200 Vdc at 800 Vdc at 1500 Vdc input fuse 4 A / 1500 Vdc (external) maximum capacitive load from low line to high line, full load load regulation from 0% to full load delay time IURP9LQ 9WRRIUDWHGRXSWXWYROWDJH N parameter conditions/description over voltage protection 12 Vdc, 15 Vdc output models 24 Vdc output model automatic recovery O over current protection 185 195 Vdc Vdc 120 30 16 mA mA mA TI line regulation short circuit protection 170 180 min voltage accuracy PROTECTIONS Vdc U conditions/description 12 Vdc output model 15 Vdc output model 24 Vdc output model at full load units 1500 N parameter WHPSHUDWXUHFRHϒFLHQW W\S 30 80 150 OUTPUT switching frequency max 200 ED operating input voltage min W\S A A A max units 2,000 1,200 470 Nj) Nj) Nj) ±2 % ±1 % ±1 % 2 s 65 kHz ±0.02 %/°C W\S 120 max units 20 30 Vdc Vdc 320 % max units continuous, automatic recovery SAFETY AND COMPLIANCE parameter conditions/description input to output for 1 minute W\S 4,000 C isolation voltage min CSA, EN 62109 conducted emissions CISPR22/EN55022, class A (external circuit required, see Figure 2) radiated emissions CISPR22/EN55022, class A (external circuit required, see Figure 2) ESD IEC/EN61000-4-2, contact ± 6kV/air ± 8kV, class B radiated immunity IEC/EN61000-4-3, 10V/m, class A ()7EXUVW IEC/EN61000-4-4, ± 2kV, class B (external circuit required, see Figure 2) surge IEC/EN61000-4-5, line-line ± 1kV, class B (external circuit required, see Figure 2) conducted immunity IEC/EN61000-4-6, 10 Vr.m.s, class A PDJQHWLF¿HOGLPPXQLW\ IEC/EN61000-4-8, 10 A/m, class A 07%) as per MIL-HDBK-217F, 25°C RoHS yes D IS safety approvals Vac 300,000 cui.com hours Additional Resources: Product Page CUI Inc Ϳ SERIES: AE15-UW Ϳ DESCRIPTION: DC-DC CONVERTER date 08/17/2021 Ϳ page 3 of 7 ENVIRONMENTAL parameter conditions/description min max units operating temperature see derating curves -40 70 °C -40 85 °C 95 % 5000 m storage humidity non-condensing altitude see derating curves ED storage temperature W\S SOLDERABILITY parameter conditions/description min W\S max units hand soldering for 3~5 seconds 350 360 370 °C wave soldering for 5~10 seconds 255 260 265 °C max units U MECHANICAL conditions/description dimensions 125.00 x 75.00 x 40.00 [4.921 x 2.953 x 1.575 inch] case material EODFNÀDPHUHWDUGDQWKHDWSURRISODVWLF8/9 weight units: mm [inch] tolerance: ±0.50[±0.020] pin diameter tolerance: ±0.10[±0.004] pin height tolerance: ±1.50[±0.059] 1 -Vin 2 +Vin NC 4 -Vout 5 +Vout C 3 O 3,1&211(&7,216 Function 300 N In high vibration environments, this series should be mounted with screws. tightening torque: max 0.4 N*m W\S TI MECHANICAL DRAWING PIN min N parameter D IS 1& QRFRQQHFWLRQ Recommended PCB Layout 7RS9LHZ cui.com mm g Additional Resources: Product Page CUI Inc Ϳ SERIES: AE15-UW Ϳ DESCRIPTION: DC-DC CONVERTER date 08/17/2021 Ϳ page 4 of 7 D IS C O N TI N U ED DERATING CURVES cui.com Additional Resources: Product Page CUI Inc Ϳ SERIES: AE15-UW Ϳ DESCRIPTION: DC-DC CONVERTER date 08/17/2021 Ϳ page 5 of 7 D IS C O N TI N U ED EFFICIENCY CURVES cui.com Additional Resources: Product Page CUI Inc Ϳ SERIES: AE15-UW Ϳ DESCRIPTION: DC-DC CONVERTER date 08/17/2021 Ϳ page 6 of 7 APPLICATION CIRCUIT Fuse 4 A / 1500 Vdc 4 A / 1500 Vdc 24 4 A / 1500 Vdc 1 C2 Nj) 120 796 SMBJ20A 1 120 SMBJ20A 1 68 SMBJ30A N TI 12 15 C1 Nj) N Vout (Vdc) U Table 1 ED Figure 1 O EMC RECOMMENDED CIRCUIT Figure 2 Table 2 Recommended External Circuit Components IS C FUSE 4 A/1500 Vdc C7, C8, C9, C10 104K/275 Vac C3, C4, C5, C6 47 µF/450 Vdc R1, R2, R3, R4 0Ÿ: LDM 330 µH/1 A LCM 7 mH/1 A D 1RWH6HHDOVR7DEOH 1RWHV &LVDFHUDPLFFDSDFLWRUXVHGWR¿OWHUKLJKIUHTXHQF\QRLVH 2. C2 is electrolytic and is recommended to be high frequency and low resistance. For capacitance and current of the capacitor, refer to the datasheet provided by the manufacturer. Capacitance withstand voltage derating should be 80% or above. cui.com Additional Resources: Product Page CUI Inc Ϳ SERIES: AE15-UW Ϳ DESCRIPTION: DC-DC CONVERTER date 08/17/2021 Ϳ page 7 of 7 REVISION HISTORY description date 09/13/2017 1.0 initial release 1.01 updated datasheet 1.02 changed external input fuse recommendation 1.03 company logo updated 1.04 ED rev. 03/05/2018 07/24/2019 04/12/2021 GHUDWLQJFXUYHVHϒFLHQF\FXUYHVDQGFLUFXLW¿JXUHVXSGDWHG 08/17/2021 D IS C O N TI N U 7KHUHYLVLRQKLVWRU\SURYLGHGLVIRULQIRUPDWLRQDOSXUSRVHVRQO\DQGLVEHOLHYHGWREHDFFXUDWH Headquarters 20050 SW 112th Ave. 7XDODWLQ25 800.275.4899 Fax 503.612.2383 cui.com techsupport@cui.com &8,RϑHUVDWZR\HDUOLPLWHGZDUUDQW\&RPSOHWHZDUUDQW\LQIRUPDWLRQLVOLVWHGRQRXUZHEVLWH CUI reserves the right to make changes to the product at any time without notice. Information provided by CUI is believed to be accurate and reliable. However, no responsibility is assumed by CUI for its use, nor for any infringements of patents or other rights of third parties which may result from its use. CUI products are not authorized or warranted for use as critical components in equipment that requires an extremely high level of reliability. A critical component is any component of a OLIHVXSSRUWGHYLFHRUV\VWHPZKRVHIDLOXUHWRSHUIRUPFDQEHUHDVRQDEO\H[SHFWHGWRFDXVHWKHIDLOXUHRIWKHOLIHVXSSRUWGHYLFHRUV\VWHPRUWRDϑHFWLWVVDIHW\RUHϑHFWLYHQHVV