564-0300-132

3mm LED CBI® Circuit Board Indicator Tri-Level CATHODE ID 4.32 [.170] MAX A 11.56 [.455] REF POS.1 5.08 [.200] POS.2 15.24 [.600] 5.08 [.200] POS.3 2.54 [.100] 3.68 [.145] ±.010 5.08 [.200] ( TYP ) 4.45[.175] ±.010 RED CATHODE LEAD YEL CATHODE LEAD (BI-COLOR LEDs) 2.54 [.100] ±.010 Ø 1.09 [.043] ±.002 ( 6X ) 2.54 [.100] ±.002 2.54 [.100] ±.010 5.08 [.200] ±.010 TOP LED 564-0x00-xxx PART NO. 564-0100-111 564-0100-132 564-0100-222 564-0100-777 564-0100-999 COLOR* Red-Red-Red Red-Yellow-Green Green-Green-Green Orange-Orange-Orange Blue-Blue-Blue HIGH EFFICIENCY - LED TYPE 01 NEW LOW CURRENT - LED TYPE 02 564-0200-111 564-0200-132 564-0200-222 564-0300-111 564-0300-132 564-0300-222 Red-Red-Red Red-Yellow-Green Green-Green-Green Red-Red-Red Red-Yellow-Green Green-Green-Green INTEGRAL RESISTOR, 5 VOLTS - LED TYPE 03 Dimension A: Red/Green Bi-color 2.76 [.109 ±.015] all other colors 2.67 [.103 +- .015] 2.54 [.100] ±.002 2.54 [.100] ±.002 4 Dimensions in mm [inches] Features • Multiple CBIs form horizontal LED arrays on 4.45mm (0.175”) center-lines. • • • • • High Contrast, UL 94 V-0 rated, black housing Oxygen index: 29% Polymer content: PBT, 0.078 g Housing stand-offs facilitate PCB cleaning Solderability per MIL-STD-202F, method 208F BI-COLOR - LED TYPE 07 564-0700-111 Red/Green-Red/Green-Red/Green 564-0700-444 Yellow/Green-Yellow/GreenYellow/Green * Top-Middle-Bottom LED • LEDs are safe for direct viewing per IEC 825-1, EN-60825-1 Tolerance note: As noted, otherwise: • LED Protrusion: ±0.04 mm [±0.016] • CBI Housing: ±0.02mm[±0.008] Custom Combinations • Contact factory for information on custom color combinations PART NUMBER ORDERING CODE Series LED Type Top LED Position ³ ATTENTION OBSERVE PRECAUTIONS FOR HANDLING ELECTROSTATIC SENSITIVE DEVICES 564-0x00-xxx Middle LED Position Bottom LED Position Color = 0) Blank 1) Red or Red/Green Bi-color 2) Green 3) Yellow 4) Yellow/Green Bi-color 7) Orange 8) Blue³ Dialight Corporation • 1501 Route 34 South • Farmingdale, NJ 07727 • TEL: (732) 919-3119 • FAX: (732) 751-5778 •www.dialight.com 4-43 564-0x00-xxx Typical Operating Characteristics (TA=25°C) HIGH EFFICIENCY Part Number Color Red 564-0100-xxx Green Yellow Orange Blue * IF = 20mA See LED data sheet for additional information See Pages 4-73 and 4-74 for LED Drive Circuit Examples See Page 4-72 for Pin Out Peak Wavelength nm 635 565 585 600 428 IV mcd 10 12.6 10 7 12 VF Volts 2* 2.1* 2.1* 2.2 3.5 T est Current (mA) 10 10 10 10 10 Viewing Angle 2 Θ½ 60° 60° 60° 60° 70° LED Data sheet 521-9216 521-9210 521-9211 521-9498 521-9831 Page # 4-58 4-58 4-58 4-58 4-57 LOW CURRENT Part Number 564-0200-xxx Color Red Green Yellow Peak Wavelength nm 635 565 585 IV mcd 1.6 1.6 1.6 VF Volts 1.7 1.9 1.8 Test Current (mA) 2 2 2 Viewing Angle 2 Θ½ 60° 60° 60° LED Data sheet 521-9324 521-9326 521-9325 Page # 4-60 4-60 4-60 INTEGRAL RESISTOR, 5 VOLTS Part Number 564-0300-xxx Color Red Green Yellow Peak Wavelength nm 635 565 585 IV mcd 29 19 12.6 Test Voltage 5 5 5 Forward Current (mA) 10 10 10 Viewing Angle 2 Θ½ 60° 60° 60° LED Data sheet 521-9215 521-9323 521-9322 Page # 4-59 4-59 4-59 BI-COLOR Part Number Color Peak Wavelength nm 635/565 585/565 IV mcd 4.7/10 4.3/6.3 VF Volts 2/2.1 2.1*/2.1* Test Current (mA) 10 10 Viewing Angle 2 Θ½ 50° 80° LED Data sheet 521-9459 521-9478 Page # 4-63 4-62 564-0700-111 Red/Green 564-0700-444 Yellow/Green * IF = 20mA 4-44 Dialight Corporation • 1501 Route 34 South • Farmingdale, NJ 07727 • TEL: (732) 919-3119 • FAX: (732) 751-5778 •www.dialight.com NEW 3mm Discrete LED Tinted, Diffused 521-9831 PART NO. SURFACE NOT FLAT 4.8 [.189] 4.4 [.173] 4.8 [.189] 4.4 [.173] 0.7 [.028] 0.4 [.016] 0.6 [.024] 0.4 [.016] 2.54 [.100] 3.4 [.134] 3.1 [.122] 521-9831 COLOR Blue³ 2.9 [.114] ø 2.7 [.106] 3.7 [.145] 3.5 [.138] 6.1 [.240] 5.7 [.224] CATHODE 1.8 [.071] 1.2 [.047] 0.6 [.024] 0.4 [.016] 29 [1.142] 27 [1.063] Dimensions in mm [inches] MOUNTING CLIP: 515-0006 located on page 4-65 ³ ATTENTION OBSERVE PRECAUTIONS FOR HANDLING ELECTROSTATIC SENSITIVE DEVICES 4 Blue ABSOLUTE MAXIMUM RATINGS (TA=25°C) Power Dissipation (mW) Forward Current (mA) Derating (mA/°C) From 55°C Operating Temperature (°C) Storage Temperature (°C) Soldering Temperature Solder Adherence per MIL-STD-202E, Method 208C -9831 100 20 .44 -40/+100 -40/+100 260°C, 5 seconds, 1.6 mm from case Blue OPERATING CHARACTERISTICS (TA=25°C) Luminous Intensity (mcd) IF=10mA Peak Wavelength (nm) λ Peak Viewing Angle (2Θ½) Forward Voltage (V) IF=10mA Reverse Voltage (V) IR=10µA -9831 Min. Typical Typical Typical Typical Max. Min. 6.3 12 428 70° 3.5 4.2 3 Θ  is the off axis angle at which the luminous intensity is half the axial luminous intensity Dialight Corporation • 1501 Route 34 South • Farmingdale, NJ 07727 • TEL: (732) 919-3119 • FAX: (732) 751-5778 •www.dialight.com 4-57 3mm Discrete LED High Efficiency Diffused 521-9210, -9211, -9216, -9498, -9636 PART NO. COLOR 521-9210 Green 521-9211 Yellow 521-9216 Red 521-9498 Orange 521-9636 Red 2.54 [.100] 4.45 [.175] 1.02 [.040] 25.4 [1.0] MIN 1.02 [.040] MIN 3.30 [.13] NEW 3.00 [.118] 1.50 [.059] MAX 6.00 [.236] .45 [.016 ] .40 [.016] MOUNTING CLIP: 515-0006 located on page 4-65 short lead cathode all colors except 521-9636 Red. For 521-9636 Red, short lead is anode. Dimensions in mm [inches] Green Yellow Red Orange Red ABSOLUTE MAXIMUM RATINGS (TA=25°C) Power Dissipation (mW) Forward Current (mA) Derating (mA/°C) From 50°C Operating Temperature (°C) Storage Temperature (°C) Soldering Temperature Solder Adherence per MIL-STD-202E, Method 208C 1 -9210 100 -9211 60 20 .25 -55/+100 -55/+100 -9216 100 30 .4 -55/+100 -55/+100 -9498 135 25 .5 -55/+100 -55/+100 -9636 100 40 .51 -55/+100 -55/+100 from 25°C 30 .4 -55/+100 -55/+100 260°C, 5 seconds, 1.6 mm from body Green Yellow Red Orange Red OPERATING CHARACTERISTICS (TA=25°C) Luminous Intensity (mcd) IF=10mA 1 IF=20mA Peak Wavelength (nm) λ Peak Viewing Angle (2Θ ½) Forward Voltage (V) IF=10mA 1 IF=20mA Reverse Voltage (V), IR=100µA Min. Typical Typical Typical Typical Max. Max. -9210 4.7 12.6 565 60° 2.11 2.81 5 -9211 7.4 10 585 60° 2.11 2.81 5 -9216 7.4 10 635 60° 21 2.81 5 -9498 3.4 7 600 60° 2.2 3 5 -9636 8.71 481 660 60° 1.81 2.41 4 Θ  is the off axis angle at which the luminous intensity is half the axial luminous intensity 4-58 Dialight Corporation • 1501 Route 34 South • Farmingdale, NJ 07727 • TEL: (732) 919-3119 • FAX: (732) 751-5778 •www.dialight.com 3mm Discrete LED Integral Resistor, 5V Diffused 4.40 [.175] 1.01 [.040] 1.0 [.040] .457 [.018] SQ. 521-9215, -9322, -9323 PART NO. 521-9215 521-9322 521-9323 COLOR Red Yellow Green 3.20 2.90 [.125] [.115] 2.54 [.100] 5.97 [.235] 2.41 [.950] MAX 1.27 [.050] CATHODE Dimensions in mm [inches] MOUNTING CLIP: 515-0006 located on page 4-65 Red Yellow Green ABSOLUTE MAXIMUM RATINGS (TA=25°C) Forward Voltage (V) Derating (V/°C) From 50°C Operating Temperature (°C) Storage Temperature (°C) Soldering Temperature Solder Adherence per MIL-STD-202E, Method 208C -9215 7.5 .086 -40/+85 -55/+100 -9322 7.5 .086 -40/+85 -55/+100 -9323 7.5 .071 -20/+85 -55/+100 4 260°C, 5 seconds, 1.6 mm from case Red Yellow Green OPERATING CHARACTERISTICS (TA=25°C) Luminous Intensity (mcd) VF=5V Peak Wavelength (nm) λ Peak Viewing Angle (2Θ½) Forward Current (mA) VF=5V Reverse Voltage (V), IR=100µA Min. Typical Typical Typical Typical Max. Min. -9215 8.7 29 635 60° 10 20 5 -9322 3.7 12.6 585 60° 10 20 5 -9323 5.6 19 565 60° 10 20 5 Θ  is the off axis angle at which the luminous intensity is half the axial luminous intensity Dialight Corporation • 1501 Route 34 South • Farmingdale, NJ 07727 • TEL: (732) 919-3119 • FAX: (732) 751-5778 •www.dialight.com 4-59 3mm Discrete LED Low Current Diffused 4.4 [.175] 1.01 [.040] .40 [.016] 521-9324, -9325, -9326 PART NO. COLOR Red Yellow Green 521-9324 521-9325 521-9326 1.0 [.040] 3.3 [.130] 1.00 26.67 [.040] [1.05] MIN. .40 [.016] 2.54 [.100] 5.97 [.235] CATHODE Dimensions in mm [inches] MOUNTING CLIP: 515-0006 located on page 4-65 Red Yellow Green ABSOLUTE MAXIMUM RATINGS (TA=25°C) Power Dissipation (mW) Forward Current (mA) Derating (mA/°C) From 90°C Peak Current (mA) Pulse width = 10 µs -9324 20 7 .7 500 -55/+100 -55/+100 -9325 20 7 .7 500 -55/+100 -55/+100 -9326 20 7 .7 500 -55/+100 -55/+100 Operating Temperature (°C) Storage Temperature (°C) Soldering Temperature Solder Adherence per MIL-STD-202E, Method 208C 260°C, 5 seconds, 1.6 mm from case Red Yellow Green OPERATING CHARACTERISTICS (TA=25°C) Luminous Intensity (mcd) IF=2mA Peak Wavelength (nm) λ Peak Viewing Angle (2Θ ½) Forward Voltage (V) IF=2mA Reverse Voltage (V), IR=50µA  -9324 Min. Typical Typical Typical Typical Max. Min. 1 1.6 635 60° 1.7 2.2 5 -9325 1 1.6 585 60° 1.8 2.7 5 -9326 1 1.6 565 60° 1.9 2.2 5 Θ is the off axis angle at which the luminous intensity is half the axial luminous intensity 4-60 Dialight Corporation • 1501 Route 34 South • Farmingdale, NJ 07727 • TEL: (732) 919-3119 • FAX: (732) 751-5778 •www.dialight.com 3mm Discrete LED Bi-Color Non-Tinted, Diffused 1.02 [.040] 25.40 [1.00] MIN RED CATHODE 521-9768 YELLOW CATHODE 521-9478 GREEN CATHODE 521-9628 3.20 [.126] MAX 521-9478, -9628, -9768 PART NO. 521-9478 521-9628 2.54 [.100] COLOR Yellow/Green Red/Green Red/Yellow 3.00 [.118] 4.45 [.175] .50 [.020] TYP 2.54 [.100] NOM 521-9768 5.20 ±.5 [.205 ±.02] NOTE: MENISCUS MAY EXTEND 1.0MM [.040] DOWN FROM HOUSING Dimensions in mm [inches] MOUNTING CLIP: 515-0006 located on page 4-65 Yellow/Green Red/Green Red/Yellow ABSOLUTE MAXIMUM RATINGS (TA=25°C) Power Dissipation (mW) Forward Current (mA) Derating (mA/°C) From 25°C 1 From 50°C Peak Current (mA) Pulse width = 10µs -9478 60/100 20/30 .251/.401 80/120 -55/+100 -55/+100 -9628 140/100 40/30 .5/.4 200/120 -55/+100 -55/+100 -9768 100/60 30/20 .41/.251 120/80 -55/+100 -55/+100 Operating Temperature (°C) Storage Temperature (°C) Soldering Temperature Solder Adherence per MIL-STD-202E, Method 208C 260°C, 5 seconds, 1.66 mm from case Yellow/Green Red/Green Red/Yellow OPERATING CHARACTERISTICS (TA=25°C) Luminous Intensity (mcd) Min. IF=10mA * IF=20mA Typical Peak Wavelength (nm) λ Peak Viewing Angle (2Θ ½) Forward Voltage (V) IF=20mA Reverse Voltage (V) IR=100ua Typical Typical Typical Max. Min. -9478 2.5/2.5 4.3/6.3 585/565 80° 2.1/2.1 2.8/2.8 5 -9628 3.7*/1.1* 12.6*/3.7* 660/565 200° 1.8/2.1 2.4/2.8 5 -9768 1.7*/1.7* 5.6*/5.6* 630/585 80° 2/2.1 2.8/2.8 5 Θ  is the off axis angle at which the luminous intensity is half the axial luminous intensity 4-62 Dialight Corporation • 1501 Route 34 South • Farmingdale, NJ 07727 • TEL: (732) 919-3119 • FAX: (732) 751-5778 •www.dialight.com 3mm Discrete LED Bi-Color Non-Tinted, Diffused 4.59 [.181] 4.0 [.158] 3.00 [.118] 1.80 [.071] MAX 26.92 [1.06] MIN 1.0 [.040] CATHODE GREEN .50 [.020] SQ. NOM. 3.40 [.134] MAX 521-9459 PART NO. 521-9459 2.54 [.100] COLOR Red/Green 6.10 [.240] Dimensions in mm [inches] MOUNTING CLIP: 515-0006 located on page 4-65 4 Red/Green ABSOLUTE MAXIMUM RATINGS (TA=25°C) Power Dissipation (mW) Forward Current (mA) Derating (mA/°C) From 25°C Peak Current (mA) Pulse width = 10µs -9459 140 45 .6 1000 -55/+100 -55/+100 260°C, 5 seconds, 1.6 mm from case Operating Temperature (°C) Storage Temperature (°C) Soldering Temperature Solder Adherence per MIL-STD-202E, Method 208C Red/Green OPERATING CHARACTERISTICS (TA=25°C) Luminous Intensity (mcd) IF=10mA Peak Wavelength (nm) λ Peak Viewing Angle (2Θ½) Forward Voltage (V) IF=10mA -9459 Min. Typical Typical Typical Typical Max. 2.5/3.7 4.7/10 635/565 50° 2/2.1 2.8/2.8 Θ  is the off axis angle at which the luminous intensity is half the axial luminous intensity Dialight Corporation • 1501 Route 34 South • Farmingdale, NJ 07727 • TEL: (732) 919-3119 • FAX: (732) 751-5778 •www.dialight.com 4-63