AC524

2/99 AC524 AC525 Typical Values 5 TO 500 MHz TO-8 CASCADABLE AMPLIFIERS AC524 AC525 31.5 dB 40.0 dB 3.2 dB +11.5 dBm +24.0 dBm . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31.5 dB . 40.0 dB . 3.0 dB . +8.5 dBm . +20.0 dBm High Gain . . . . . . . . . . . . . . . High Reverse Isolation . . . . Low Noise Figure . . . . . . . . . Medium Output Power . . . . . Medium Third Order I.P. . . . . High Performance Thin Film Standard Size TO-8 . . . . . . . . . . . . . . . . . . . . AC524/AC525 TO-8 Package for Amplifiers 0.450 (11.43) DIA. 0.208 (5.28) MAX. 0.185 ± 0.015 (4.70 ± 0.38) 0.018 ± 0.002 DIA. PIN (0.46 ± 0.05) (4) PLCS 0.504 (12.80) DIA. 50 OHM INPUT GROUND 50 OHM OUTPUT 0.025 (0.64) SPECIFICATIONS Parameter Frequency (Min.) Small Signal Gain (Min.) Gain Flatness (Max.) Noise Figure (Max.) SWR (Max.) AC524 AC525 Typical 3-600 MHz 31.5 dB < ±0.3 dB 3.0 dB 3.2 dB < 1.4:1 +8.5 dBm +12.0 dBm 35.0 mA 48.0 mA Guaranteed* 0 to 50° C -55 to +85° C 5-500 MHz 30.0 dB ±0.7 dB 4.0 dB 4.2 dB 1.7:1 +7.5 dBm +10.5 dBm 38.0 mA 52.0 mA 5-500 MHz 29.0 dB 0.033 (0.84) ±1.0 dB 4.5 dB 4.7 dB 2.0:1 +7.0 dBm +10.0 dBm 41.0 mA 55.0 mA +DC VOLTAGE 0.031 (0.79) 45° ± 3° 0.300 (7.62) DIA. B.C. Input/Output Power Output (Min.) @ 1dB comp. AC524 AC525 DC Current (Max.) AC524 AC525 AS524/AS525 * Measured in a 50-ohm system at +15 Vdc unless otherwise specified. SMTO-8 Package for Amplifiers 0.450 (11.43) 0.225 (5.72) INTERMODULATION PERFORMANCE 0 DETAIL A (NO SCALE) DC BIAS 0.016 ± 0.002 0.010 ± 0.002 Typical @ 25° C AC524 +39 dBm +33 dBm +20 dBm AC525 +43 dBm +37 dBm +24 dBm 0 50 Ω INPUT 0.250 (6.35) 0.450 (11.43) .0.075 (1.91) 0.225 (5.72) 0.375 (9.53) Second Order Harmonic Intercept Point . . . . . Second Order Two Tone Intercept Point . . . . . Third Order Two Tone Intercept Point . . . . . . . 0.016 ± 0.002 (0.41 ± 0.05) (4) PLCS 50 Ω OUTPUT 0.008 0.012 ABSOLUTE MAXIMUM RATINGS SEE DETAIL "A" GND 0 0.040 ± 0.012 (1.02 ± 0.30) (4) PLCS 0.050 (1.27) (4) PLCS 0.100 (2.54) (4) PLCS 0.170 (4.32) Storage Temperature . . . . . . . . . . . . . . . . . . . . . . . . . Maximum Case Temperature . . . . . . . . . . . . . . . . . . . Maximum DC Voltage . . . . . . . . . . . . . . . . . . . . . . . . . Maximum Continuous RF Input Power . . . . . . . . . . . Maximum Short Term Input Power (1 Minute Max.) . . Maximum Peak Power (3 µsec Max.) . . . . . . . . . . . . . Burn-in Temperature (AC524) . . . . . . . . . . . . . . . . . . Burn-in Temperature (AC525) . . . . . . . . . . . . . . . . . . Thermal Resistance1 (θjc; AC524) . . . . . . . . . . . . . . . Thermal Resistance1 (θjc; AC525) . . . . . . . . . . . . . . . Junction Temperature Rise Above Case (Tjc; AC524) Junction Temperature Rise Above Case (Tjc; AC525) 1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . -62 to 125° C +125° C +18 Volts +6 dBm 50 Milliwatts 0.5 Watt +125° C +105° C +43° C/Watt +36° C/Watt +24.5° C +27.8° C 0 0.075 (1.91) 0.200 (5.08) 0.350 (8.89) 0.450 (11.43) 0.010 (TYP.) (0.25) 0.031 (0.79) 0.031 (0.79) 45° 0.008 ± 0.001 (0.20 ± 0.03) DIMENSIONS ARE IN INCHES (MILLIMETERS) Thermal resistance is based on total power dissipation. 106 408-522-3838 • Fax: 408-522-3839 • Check for updates: www.cougarcorp.com 2003 AC524/AC525 TYPICAL PERFORMANCE Gain vs Temperature AC524 33.0 G AIN - dB 32.0 31.0 30.0 5 10 30 50 100 200 300 FREQUENCY - MHz 400 500 600 KEY: +25 ° C +85 ° C -55 ° C Model: AC524 FREQ MHZ 2 5 10 50 100 200 300 400 500 600 Model: AC524 FREQ. MHz 2 5 10 50 100 200 300 400 500 600 700 700 Model: AC524 FREQ MHZ 2 5 10 50 100 200 300 400 500 600 Model: AC525 FREQ MHZ 2 5 10 50 100 200 300 400 500 600 Model: AC525 FREQ MHZ 2 5 10 50 100 200 300 400 500 600 SWR IN 1.71 1.26 1.13 1.06 1.08 1.13 1.16 1.16 1.18 1.31 TYPICAL AUTOMATIC TEST DATA SWR OUT 1.75 1.24 1.13 1.08 1.09 1.14 1.18 1.18 1.14 1.06 Vcc=+15V GAIN DB 29.8 31.2 31.4 31.5 31.5 31.7 31.8 31.8 31.5 31.0 GROUP DELAY NSEC Icc=36.27 REV/ISO DB -42.8 -41.3 -40.6 -40.8 -40.3 -40.3 -40.8 -40.6 -40.3 -40.6 8.670 1.758 1.082 1.037 1.073 1.111 1.135 1.141 Gain vs Temperature AC525 32.0 GAIN - dB 31.0 30.0 29.0 5 10 30 50 100 200 300 FREQUENCY - MHz 400 500 600 S11 MAG 0.26 0.12 0.06 0.03 0.04 0.06 0.08 0.07 0.08 0.13 0.22 0.34 Noise Figure NOISE FIGURE - dB 4.0 3.5 3.0 A C524 2.5 2.0 5 10 30 50 100 200 300 FREQUENCY - MHz 400 500 600 AC525 LINEAR S-PARAMETERS Vcc=+15V S21 S12 ANG MAG ANG MAG ANG -82.8 30.81 68.5 0.007 80.0 -83.7 36.14 25.8 0.009 32.0 -89.0 36.98 10.3 0.009 16.0 -94.8 37.39 -15.1 0.009 2.0 -99.8 37.76 -34.5 0.010 -5.0 -109.1 38.31 -71.9 0.010 -11.0 -117.2 38.99 -110.4 0.009 -26.0 -112.5 38.81 -150.4 0.009 -31.0 -88.9 37.45 168.7 0.010 -43.0 -74.6 35.35 127.6 0.009 -57.0 -74.7 33.13 86.0 0.010 -73.0 -80.1 31.73 41.9 0.010 -95.0 Vcc=+12V GAIN DB 29.0 30.3 30.5 30.6 30.7 30.8 30.9 30.9 30.7 30.3 Vcc=+15V GAIN DB 29.7 31.1 31.3 31.4 31.5 31.5 31.6 31.6 31.3 30.8 Vcc=+12V GAIN DB 29.1 30.4 30.6 30.7 30.7 30.8 31.0 31.0 30.7 30.3 Icc=36.27 S22 MAG ANG 0.27 -96.3 0.11 -104.8 0.06 -120.9 0.04 -162.4 0.05 -173.6 0.06 163.0 0.08 132.9 0.08 97.4 0.07 54.6 0.03 -47.3 0.13 -152.2 0.32 164.3 Icc=28.95 REV/ISO DB -42.1 -40.5 -40.2 -40.4 -40.2 -40.0 -40.1 -40.0 -39.9 -39.9 Icc=49.19 REV/ISO DB -42.6 -41.2 -40.8 -40.9 -40.7 -40.8 -41.1 -40.9 -40.7 -40.6 Icc=39.34 REV/ISO DB -42.2 -40.7 -40.4 -40.7 -40.4 -40.1 -40.3 -40.5 -39.7 -40.1 OUTPUT POWER - dBm Power Output at 1 dB Compression 1 4.0 AC525 12.0 10.0 8.0 6.0 5 10 30 50 100 AC524 200 300 FREQUENCY - MHz 400 500 600 SWR IN 1.68 1.27 1.15 1.09 1.11 1.18 1.23 1.24 1.22 1.26 SWR OUT 1.77 1.27 1.15 1.09 1.10 1.14 1.17 1.17 1.12 1.08 GROUP DELAY NSEC 8.356 1.740 1.081 1.039 1.068 1.108 1.133 1.148 INTERCEPT POINT - dBm Intercept Point AC524 50 2nd HAR 40 30 20 10 10 20 30 50 100 IP 2 IP 3 200 300 FREQUENCY - MHz 400 500 600 SWR IN 1.62 1.22 1.12 1.06 1.09 1.15 1.15 1.08 1.12 1.36 SWR OUT 1.91 1.33 1.23 1.20 1.22 1.27 1.30 1.30 1.22 1.08 GROUP DELAY NSEC 8.510 1.750 1.077 1.021 1.053 1.091 1.116 1.123 Intercept Point AC525 INTERCEPT POINT - dBm 60 50 40 30 20 10 10 20 30 50 100 IP 2 IP 3 200 300 FREQUENCY - MHz 400 500 600 2nd HAR SWR IN 1.57 1.23 1.13 1.10 1.13 1.19 1.21 1.13 1.05 1.27 SWR OUT 1.92 1.35 1.25 1.21 1.22 1.27 1.30 1.28 1.20 1.08 GROUP DELAY NSEC 8.311 1.729 1.070 1.022 1.049 1.091 1.124 1.138 2003 408-522-3838 • Fax: 408-522-3839 • Check for updates: www.cougarcorp.com 107