PJ31002CS

PJ31002 Tone Ringer For Telephone Set T • • • • • h e PJ31002 is a bipolar integrated circuit designed for telephone bell replacement. D IP -8 SOP -8 FEATURES Oscillation frequency is variable Few external components Sustaining power is low P ackage is compact ( DIP-8) Current consumption is small P in: 1. Vcc 2. Rsl 3. Lfi 4. Lfo 5. Gnd 6. Hfo 7. Hfi 8. Out ORDERING INFORMATION Device P J31002CD P J31002CS Operating Temperature -20℃～+85℃ Package DIP-8 S OP-8 ELECTRICAL CHARACTERISTICS ( Unless otherwise specified, T a=25 ℃, Vcc=24V) Parameter Operating Voltage S upply Initiation Voltage S ustaining Voltage S upply Initiation Current S ustaining Current Oscillator Frequence (NOTE3) Oscillator Frequence (NOTE3) Oscillator Frequence (NOTE3) Output Voltage *Hi* Output Voltage *Lo* R inging Start Voltage Symbol Vopr Vsi Vsus Isi lsus fL fH1 fH2 Voh Vol Vtr Min. -15 10.5 1.4 0.35 9 461 576 19.7 0.5 -Typ. -17 12.0 3.3 0.9 10 512 640 22.0 0.9 -Max. 38 19.5 13.0 4.2 1.5 11 563 703 23.5 1.4 36.0 Unit V V V mA mA Hz Hz Hz V V V loh=10mA 7 Pin=GND Iol=10mA 7 Pin=5.5V (NOTE 4) (NOTE 1) (NOTE 2) Vcc=Vsi, No LOAD Vcc=Vsus, No LOAD Conditions Test Circuit FIG.4 FIG.4 FIG.4 FIG.4 FIG.4 FIG.5 FIG.5 FIG.5 FIG.4 FIG.4 FIG.3 ABSOLUTE MAXIMUM RATING ( T a=25 ℃ ) Parame te r Supply Voltage P ower Dissipation Operating T emperature Range Storage T emperature Range Symbol Vcc Pd T opr T stg 1-5 Rating 38 500 -20 ~ +85 -55 ~ +125 Unit V mW ℃ ℃ 2002/01.rev.A PJ31002 Tone Ringer For Telephone Set ( NOT E 1 ) Supply initiation voltage is the value of DC supply voltage required to start the tone ringer oscillation. Sustaining voltage is the value of DC supply voltage required to maintain oscillation. Oscillator frequency is determined by the following equations : fL = 1 / ( 1.234 * R1 * C1 ) fH1 = 1 / ( 1.515 * R2 * C2 ) fH2 = 1.24 * fH1 ( NOT E 4 ) Hz Hz Hz ( NOT E 2 ) ( NOT E 3 ) Ringing start voltage is the value of AC supply voltage required to start the tone ringer ringing in FIG.3 T his product is not designed for protection against radioactive rays. All data and specifications are subject to change without notice. ( NOT E 5 ) ( NOT E 6 ) Figure 2. Block Diagram 2-5 2002/01.rev.A PJ31002 Tone Ringer For Telephone Set H O W TO USE THE RSL PIN In the IC, the supply initiation current (lsi) can be Vc c 1 changed using the RSL Pin . As show is the diagram, the RSL (Pin 2) is grounded through resistor Rs. By changing the Rs value, supply initiation current can be changed. Supply voltage (Vcc) vs. supply current (lcc) Rs 5 2 characteristics resulting from changes in the value of Rs are shown in the following diagram. G ND Ic c (m A) 4 Rs= 6.8K Rs= 10K Rs= 18K 3 2 1 10 20 Vc c (V) Figure 3.Ringing Start Voltage Te st Circuit 1N4004* 4 Tone Ringer 10uF/35 1 2 27V 1uF/250 680K 103 pF A C f=20H 104p F 8 7 6 5 100 4.7uF/50 8.2K + + 10K 3 4 3-5 2002/01.rev.A PJ31002 Tone Ringer For Telephone Set FIG. 4 Test Circuit (1) Isi Isus Tone Ringer IC 1 2 Vsi Vsus V Vcc 3 Rs 4 R1 C1 C2 Voh Vol 5 8 7 6 R2 5 5V V SW2 3 2 1 SW1 1 To Oscilloscope 2 10mA A • S WITCH POSITION IS THE FOLLOWING TABLE : PARAMETER SW1 SW2 Vsi , Isi Vsus , Isus Voh Vol 1 1 2 2 1 1 2 3 R1 R2 C1 C2 = 165 K (+/-) = 191 K (+/-) = 0.47 µF (+/-) = 0.0068 µF (+/-) 1% 1% 5% 5% FIG. 4 Te st Circuit (2) Isi.Isus To ne R in ge r IC 1 3 2 1 2 SW 1 3 4 5.5V C1 1 SW2 R1 8 7 6 5 C2 2 R2 f1 .fH1. fH2 To Oscillosco pe A Vsi. Vsus V Vcc Rs • S WITCH POSITION IS THE FOLLOWING TABLE : PARAMETER SW1 SW2 FL fH1 fH2 1 1 2 1 1 2 R1 R2 C1 C2 = 165 K (+/-) 1% = 191 K (+/-) 1% = 0.47 µF (+/-) 5% = 0.0068 µF ( +/- ) 5 % 4-5 2002/01.rev.A PJ31002 Tone Ringer For Telephone Set DIM A B C D G J K L M MILLIMETERS MIN MAX 9.07 9.32 6.22 6.48 3.18 4.43 0.35 0.55 2.54BSC 0.29 0.31 3.25 3.35 7.75 8.00 10° INCHES MIN MAX 0.357 0.367 0.245 0.255 0.125 0.135 0.019 0.020 0.10BSC 0.011 0.012 0.128 0.132 0.305 0.315 10° DIM A B C D F G K M P R MILLIMETERS MIN MAX 4.80 5.00 3.80 4.00 1.35 1.75 0.35 0.49 0.40 1.25 1.27BSC 0.10 0.25 0° 7° 5.80 6.20 0.25 0.50 INCHES MIN MAX 0.189 0.196 0.150 0.157 0.054 0.068 0.014 0.019 0.016 0.049 0.05BSC 0.004 0.009 0° 7° 0.229 0.244 0.010 0.019 5-5 2002/01.rev.A