EL0500(TA)

8 PIN SOP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER EL045X EL050X series Features • High speed 1Mbit/s •15kV/µs minimum commone mode transient immunity at VCM= 1500V (HCPL0453) • High isolation voltage between input and output (Viso=3750 Vrms ) • Guaranteed performance from 0°C to 70°C • Wide operating temperature range of -55°C to 100°C Schematic • Pb free and RoHS and Halogen free compliant • cUL approved (No. E214129) • VDE approved (No. 40028116) • SEMKO approved • NEMKO approved • DEMKO approved 1 8 1 8 2 7 2 7 3 6 3 6 4 5 4 5 • FIMKO approved Description The EL0500, EL0501, EL0452 and EL0453 devices each EL0500 / EL0501 EL0452 /EL0453 consist of an infrared emitting diode, optically coupled to a high speed photo detector transistor. A separate connection for the Pin Configuration Pin Configuration photodiode bias and output-transistor collector increase the 1. No Connection 1. No Connection speed by several orders of magnitude over conventional 2. Anode 2. Anode phototransistor couplers by reducing the base-collector 3. Cathode 3. Cathode capacitance of the input transistor. 4. No Connection 4. No Connection 5. Gnd 5. Gnd 6. Vout 6. Vout The devices are packaged in an 8-pin small outline package which conforms to the standard SO-8 footprint. Applications • Line receivers • Telecommunication equipments • Power transistor isolation in motor drives • Replacement for low speed phototransistor photo couplers • Feedback loop in switch-mode power supplies • Home appliances • High speed logic ground isolation Everlight Electronics Co., Ltd. Document No DPC-0000089 ： 1 Rev.2 http://www.everlight.com July 15, 2011 8 PIN SOP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER EL045X EL050X series Absolute Maximum Ratings (Ta=25°C) Parameter Input Symbol Rating Unit Forward current IF 25 mA Peak forward current (50% duty, 1ms P.W) IFP 50 mA Peak transient current (≤1µs P.W,300pps) IFtrans 1 A Reverse voltage VR 5 V Power dissipation PIN 45 mW Power dissipation PO 100 mW Emitter-Base reverse voltage EL0500 EL0501 VEBR 5 V Base current EL0500 EL0501 IB 5 mA Average Output current IO(AVG) 8 mA Peak Output current IO(PK) 16 mA Output voltage VO -0.5 to 20 V Supply voltage VCC -0.5 to 30 V VISO 3750 V rms Operating temperature TOPR -55 ~ +100 °C Storage temperature TSTG -55 ~ +125 °C TSOL 260 °C Output Isolation voltage *1 Soldering temperature *2 Notes *1 AC for 1 minute, R.H.= 40 ~ 60% R.H. In this test, pins 1, 2, 3, 4 are shorted together, and pins 5, 6, 7, 8 are shorted together. *2 For 10 seconds. Everlight Electronics Co., Ltd. Document No DPC-0000089 ： 2 Rev.2 http://www.everlight.com July 15, 2011 8 PIN SOP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER EL045X EL050X series Electrical Characteristics (TA=0 to 70°C unless specified otherwise) Input Parameter Symbol Min. Typ.* Max. Unit Forward voltage VF - 1.5 1.8 V IF = 16mA Reverse Voltage VR 5.0 - - V IR = 10µA ∆VF/∆TA - -1.6 - mV/°C IF =16mA Symbol Min. Typ.* Max. Unit - 0.001 0.5 - 0.01 1 - - 50 - 140 200 - 0.01 1 Temperature coefficient of forward voltage Conditions Output Parameter Logic High Output Current Logic Low Supply Current Logic High Supply Current IOH ICCL ICCH IF=0mA, VO=VCC=5.5V, TA=25°C µA - 2 IF=0mA, VO=VCC=15V, TA=25°C IF=0mA, VO=VCC=15V µA IF=16mA, VO=Open, VCC=15V IF=0mA, VO=Open, VCC=15V, TA=25°C µA - Conditions IF=0mA, VO=Open, VCC=15V * Typical values at TA = 25°C Everlight Electronics Co., Ltd. Document No DPC-0000089 ： 3 Rev.2 http://www.everlight.com July 15, 2011 8 PIN SOP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER EL045X EL050X series Transfer Characteristics (TA=0 to 70°C unless specified otherwise) Parameter Symbol EL0500 EL0501 EL0452 Current Transfer EL0453 Ratio EL0500 Logic Low Output Voltage Min. Typ.* Max. 7 - 50 19 - 50 5 - - CTR Unit Conditions IF = 16mA ,VO = 0.4V, VCC=4.5V, TA=25°C % IF = 16mA ,VO = 0.5V, VCC=4.5V EL0501 EL0452 EL0453 15 - - EL0500 - 0.18 0.4 IF = 16mA ,IO = 1.1mA, VCC=4.5V, TA=25°C EL0501 EL0452 EL0453 - 0.18 0.4 IF = 16mA ,IO = 3mA, VCC=4.5V, TA=25°C - - 0.5 IF = 16mA ,IO = 0.8mA, VCC=4.5V - - 0.5 IF=16mA ,IO=2.4mA, VCC=4.5V EL0500 VOL EL0501 EL0452 EL0453 V * Typical values at TA = 25°C Everlight Electronics Co., Ltd. Document No DPC-0000089 ： 4 Rev.2 http://www.everlight.com July 15, 2011 8 PIN SOP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER EL045X EL050X series Switching Characteristics (TA=0 to 70°C unless specified otherwise, IF=16mA, Vcc=5V) Parameter Propagation Delay Time to Logic Low (Fig.8) Propagation Delay Time to Logic High (Fig.8) Symbol Common Mode Transient Immunity at Logic Low *3 (Fig.9) Typ.* Max. - - 1.5 - - 2.0 Unit EL0501 EL0452 EL0453 TPHL µs - Conditions RL=4.1KΩ, TA=25°C EL0500 RL=4.1KΩ 0.8 RL=1.9KΩ, TA=25°C - - 1.0 RL=1.9KΩ - - 1.5 RL=4.1KΩ, TA=25°C - - 2.0 - - 0.8 - - 1.0 - 1,000 - - 1,000 - EL0453 15000 - - IF = 0mA , VCM=1500Vp-p, RL=1.9KΩ, TA =25°C EL0500 - 1,000 - IF = 16mA , VCM=10Vp-p, RL=4.1KΩ, TA =25°C - 1,000 - 15000 - - EL0500 EL0501 EL0452 EL0453 TPLH EL0500 Common Mode Transient Immunity at Logic High *3 (Fig.9) Min. EL0452 EL0501 EL0452 EL0501 CMH CML EL0453 µs RL=4.1KΩ RL=1.9KΩ, TA=25°C RL=1.9KΩ IF = 0mA , VCM=10Vp-p, RL=4.1KΩ, TA =25°C V/µs V/µs IF = 0mA , VCM=10Vp-p, RL=1.9KΩ, TA =25°C IF = 16mA , VCM=10Vp-p, RL=1.9KΩ, TA=25°C IF = 16mA, VCM=1500Vp-p, RL=1.9KΩ, TA=25°C * Typical values at TA = 25°C Everlight Electronics Co., Ltd. Document No DPC-0000089 ： 5 Rev.2 http://www.everlight.com July 15, 2011 8 PIN SOP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER EL045X EL050X series Typical Performance Curves Everlight Electronics Co., Ltd. Document No DPC-0000089 ： 6 Rev.2 http://www.everlight.com July 15, 2011 8 PIN SOP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER EL045X EL050X series Figure 8 Switching Time Test Circuit & Waveform Figure 9 Transient Immunity Test Circuit & Waveform Everlight Electronics Co., Ltd. Document No DPC-0000089 ： 7 Rev.2 http://www.everlight.com July 15, 2011 8 PIN SOP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER EL045X EL050X series Note: *3 Common mode transient immunity in logic high level is the maximum tolerable (positive) dVcm/dt on the leading edge of the common mode pulse signal VCM, to assure that the output will remain in a logic high state (i.e., VO > 2.0V). Common mode transient immunity in logic low level is the maximum tolerable (negative) dVcm/dt on the trailing edge of the common mode pulse signal, VCM, to assure that the output will remain in a logic low state (i.e., VO < 0.8V). Order Information Part Number EL050X(Z)-V Or EL045X(Z)-V Note X Z V = Part No. (X = 0 or 1) for EL050x; (x=2 or 3) for EL045x = Tape and reel option (TA, TB or none) = VDE (optional) Option Description Packing quantity None Standard 100 units per tube -V Standard + VDE 100 units per tube (TA) TA tape & reel option 2000 units per reel (TB) TB tape & reel option 2000 units per reel (TA)-V TA tape & reel option + VDE 2000 units per reel (TB)-V TB tape & reel option + VDE 2000 units per reel Everlight Electronics Co., Ltd. Document No DPC-0000089 ： 8 Rev.2 http://www.everlight.com July 15, 2011 8 PIN SOP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER EL045X EL050X series Package Drawing (Dimensions in mm) Recommended pad layout for surface mount leadform Everlight Electronics Co., Ltd. Document No DPC-0000089 ： 9 Rev.2 http://www.everlight.com July 15, 2011 8 PIN SOP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER EL045X EL050X series Device Marking EL 0501 YWWV Notes EL denotes EVERLOGHT 0501 denotes Device Number Y denotes 1 digit Year code WW denotes 2 digit Week code V denotes VDE (optional) Everlight Electronics Co., Ltd. Document No DPC-0000089 ： 10 Rev.2 http://www.everlight.com July 15, 2011 8 PIN SOP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER EL045X EL050X series Tape & Reel Packing Specifications Option TA Option TB Direction of feed from reel Direction of feed from reel Tape dimensions Dimension No. A0 A1 B0 D0 D1 E F Dimension(mm) 6.2±0.1 4.1±0.1 5.28±0.1 1.5±0.1 1.5±0.3 1.75±0.1 5.5±0.1 Dimension No. Po P1 P2 t W K0 K1 Dimension(mm) 4.0±0.1 8.0±0.1 2.0±0.1 0.4±0.1 3.7±0.1 0.3±0.1 Everlight Electronics Co., Ltd. Document No DPC-0000089 ： 11 Rev.2 12.0+0.3/ -0.1 http://www.everlight.com July 15, 2011 8 PIN SOP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER EL045X EL050X series Solder Reflow Temperature Profile 260 °C (peak) >255 °C (30s Max) 217°°C 1-3 °C/Sec Max 200°°C 60 – 100 Sec 150°°C 60 – 120 Sec 1-3 °C/Sec Max TIME (S) Everlight Electronics Co., Ltd. Document No DPC-0000089 ： 12 Rev.2 http://www.everlight.com July 15, 2011 8 PIN SOP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER EL045X EL050X series DISCLAIMER 1. Above specification may be changed without notice. EVERLIGHT will reserve authority on material change for above specification. 2. When using this product, please observe the absolute maximum ratings and the instructions for using outlined in these specification sheets. EVERLIGHT assumes no responsibility for any damage resulting from use of the product which does not comply with the absolute maximum ratings and the instructions included in these specification sheets. 3. These specification sheets include materials protected under copyright of EVERLIGHT corporation. Please don’t reproduce or cause anyone to reproduce them without EVERLIGHT’s consent. Everlight Electronics Co., Ltd. Document No DPC-0000089 ： 13 Rev.2 http://www.everlight.com July 15, 2011