EL2530

8 PIN DIP DUAL CHANNEL HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER EL253X series Features • High speed 1Mbit/s • High isolation voltage between input and output (Viso=5000 Vrms ) • Guaranteed performance from 0°C to 70°C • Wide operating temperature range of -40°C to 85°C • Pb free and RoHS compliant • UL approved (No. 214129) • VDE approved (No. 132249) • SEMKO approved • NEMKO approved • DEMKO approved • FIMKO approved • CSA approved • CQC approved Description The EL2530 and EL2531 dual channel devices each consist of an infrared emitting diode, optically coupled to a high speed photo detector transistor. A separate connection for the photodiode bias and output-transistor collector increase the speed by several orders of magnitude over conventional phototransistor couplers by reducing the base-collector capacitance of the input transistor. The devices are packaged in an 8-pin DIP package and available in wide-lead spacing and SMD option. Schematic Applications • Line receivers • Telecommunication equipments • Power transistor isolation in motor drives • Replacement for low speed phototransistor photo couplers • Feedback loop in switch-mode power supplies • Home appliances • High speed logic ground isolation Everlight Electronics Co., Ltd. Document No DPC-0000148 ： 1 Rev.1 Pin Configuration 1. Anode 2. Cathode 3. Cathode 4. Anode 5. Gnd 6. Vout2 7. Vout1 8. VCC http://www.everlight.com May 21, 2012 8 PIN DIP DUAL CHANNEL HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER EL253X series Absolute Maximum Ratings (Ta=25°C) Parameter Symbol Rating Unit Forward current IF 25 mA Peak forward current (50% duty, 1ms P.W) IFP 50 mA Peak transient current (≤1µs P.W,300pps) IFtrans 1 A Reverse voltage VR 5 V Power dissipation PIN 45 mW Power dissipation PO 35 mW Average Output current IO(AVG) 8 mA Peak Output current IO(PK) 16 mA Output voltage VO -0.5 to 20 V Supply voltage VCC -0.5 to 30 V VISO 5000 V rms Operating temperature TOPR -40 ~ +100 °C Storage temperature TSTG -40 ~ +125 °C TSOL 260 °C Input Output Isolation voltage *1 Soldering temperature *2 Notes *1 AC for 1 minute, R.H.= 40 ~ 60% R.H. In this test, pins 1, 2, 3, 4 are shorted together, and pins 5, 6, 7, 8 are shorted together. *2 For 10 seconds. Everlight Electronics Co., Ltd. Document No DPC-0000148 ： 2 Rev.1 http://www.everlight.com May 21, 2012 8 PIN DIP DUAL CHANNEL HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER EL253X series Electrical Characteristics (TA=0 to 70°C unless specified otherwise) Input Parameter Symbol Min. Typ.* Max. Unit Forward voltage VF - 1.45 1.8 V IF = 16mA, TA=25℃ Reverse Voltage VR  VF/ 5.0 - - V IR = 10µA - -1.9 - mV/°C IF =16mA CIN - 60 - pF Symbol Min. Typ.* Max. Unit - 0.001 0.5 Temperature coefficient of forward voltage Input Capacitance TA Conditions VF=0V, f=1MHz Output Parameter Logic High Output Current Logic Low Supply Current Logic High Supply Current µA IOH ICCL - - 50 - 140 400 - 0.01 1 - - 4 ICCH Conditions IF=0mA, VO=VCC=5.5V, TA=25°C IF=0mA, VO=VCC=15V TA=25°C µA IF1=IF216mA, VO=Open, VCC=15V IF=0mA, VO=Open, VCC=15V, TA=25°C µA IF=0mA, VO=Open, VCC=15V * Typical values at TA = 25°C Everlight Electronics Co., Ltd. Document No DPC-0000148 ： 3 Rev.1 http://www.everlight.com May 21, 2012 8 PIN DIP DUAL CHANNEL HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER EL253X series Transfer Characteristics (TA=0 to 70°C unless specified otherwise) Parameter Symbol Min. Typ.* Max. 7 - 50 19 - 50 EL2530 5 - - EL2531 15 - - EL2530 - 0.18 0.5 IF = 16mA ,IO = 1.1mA, VCC=4.5V, TA=25°C EL2531 - 0.25 0.5 IF = 16mA ,IO = 3mA, VCC=4.5V, TA=25°C - - 0.5 - - 0.5 EL2530 Current Transfer Ratio Logic Low Output Voltage EL2531 EL2530 CTR VOL EL2531 Unit Conditions IF = 16mA ,VO = 0.4V, VCC=4.5V, TA=25°C % IF = 16mA ,VO = 0.5V, VCC=4.5V V IF = 16mA ,IO = 0.8mA, VCC=4.5V IF=16mA ,IO=2.4mA, VCC=4.5V Switching Characteristics (TA=0 to 70°C unless specified otherwise, IF=16mA, Vcc=5V) Parameter Propagation Delay Time to Logic Low (Fig.8) Propagation Delay Time to Logic High (Fig.8) Common Mode Transient Immunity at Logic High *3 (Fig.9) Common Mode Transient Immunity at Logic Low (Fig.9)*3 Symbol EL2530 tPHL EL2531 EL2530 tPLH Min. Typ.* Max. Unit Conditions - 0.35 1.5 - - 2.0 - 0.35 0.8 - - 1.0 RL=1.9KΩ - 0.5 1.5 RL=4.1KΩ, TA=25°C - - 2.0 RL=4.1KΩ, TA=25°C µs RL=4.1KΩ RL=1.9KΩ, TA=25°C RL=4.1KΩ µs - 0.3 0.8 - - 1.0 1,000 10,000 - EL2531 1,000 10,000 - IF = 0mA , VCM=1000Vp-p, RL=1.9KΩ, TA =25°C EL2530 1,000 10,000 - IF = 16mA , VCM=10Vp-p, RL=4.1KΩ, TA =25°C EL2531 EL2530 CMH RL=1.9KΩ IF = 0mA , VCM=10Vp-p, RL=4.1KΩ, TA =25°C V/µs CML EL2531 V/µs 1,000 10,000 - RL=1.9KΩ, TA=25°C IF = 16mA , VCM=1000Vp-p, RL=1.9KΩ, TA=25°C * Typical values at TA = 25°C Everlight Electronics Co., Ltd. Document No DPC-0000148 ： 4 Rev.1 http://www.everlight.com May 21, 2012 8 PIN DIP DUAL CHANNEL HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER EL253X series Typical Performance Curves Everlight Electronics Co., Ltd. Document No DPC-0000148 ： 5 Rev.1 http://www.everlight.com May 21, 2012 8 PIN DIP DUAL CHANNEL HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER EL253X series Figure 8 Switching Time Test Circuit & Waveform Figure 9 Transient Immunity Test Circuit & Waveform Note: *3 Common mode transient immunity in logic high level is the maximum tolerable (positive) dVcm/dt on the leading edge of the common mode pulse signal VCM, to assure that the output will remain in a logic high state (i.e., VO > 2.0V). Common mode transient immunity in logic low level is the maximum tolerable (negative) dVcm/dt on the trailing edge of the common mode pulse signal, VCM, to assure that the output will remain in a logic low state (i.e., VO < 0.8V). Everlight Electronics Co., Ltd. Document No DPC-0000148 ： 6 Rev.1 http://www.everlight.com May 21, 2012 8 PIN DIP DUAL CHANNEL HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER EL253X series Order Information Part Number EL253XY(Z)-V Note X = Part no. (0 or 1) Y = Lead form option (S, S1, M or none) Z = Tape and reel option (TA, TB or none) V = VDE (optional) Option Description Packing quantity None Standard DIP-8 45 units per tube M Wide lead bend (0.4 inch spacing) 45 units per tube S (TA) Surface mount lead form + TA tape & reel option 1000 units per reel S (TB) Surface mount lead form + TB tape & reel option 1000 units per reel S1 (TA) Surface mount lead form (low profile) + TA tape & reel option 1000 units per reel S1 (TB) Surface mount lead form (low profile) + TB tape & reel option 1000 units per reel Everlight Electronics Co., Ltd. Document No DPC-0000148 ： 7 Rev.1 http://www.everlight.com May 21, 2012 8 PIN DIP DUAL CHANNEL HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER EL253X series Package Drawing (Dimensions in mm) Standard DIP Type Option M Type Everlight Electronics Co., Ltd. Document No DPC-0000148 ： 8 Rev.1 http://www.everlight.com May 21, 2012 8 PIN DIP DUAL CHANNEL HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER EL253X series Option S Type Option S1 Type Everlight Electronics Co., Ltd. Document No DPC-0000148 ： 9 Rev.1 http://www.everlight.com May 21, 2012 8 PIN DIP DUAL CHANNEL HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER EL253X series Recommended pad layout for surface mount leadform Device Marking EL 2530 YWWV Notes 2530 denotes Device Number Y denotes 1 digit Year code WW denotes 2 digit Week code V denotes VDE (optional) Everlight Electronics Co., Ltd. Document No DPC-0000148 ： 10 Rev.1 http://www.everlight.com May 21, 2012 8 PIN DIP DUAL CHANNEL HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER EL253X series Tape & Reel Packing Specifications Option TA Option TB Direction of feed from reel Direction of feed from reel Tape dimensions Dimension No. A B Do D1 E F Dimension(mm) 10.4±0.1 10.0±0.1 1.5±0.1 1.5±0.1 1.75±0.1 7.5±0.1 Dimension No. Po P1 P2 t W K Dimension(mm) 4.0±0.1 12.0±0.1 2.0±0.1 0.4±0.1 Everlight Electronics Co., Ltd. Document No DPC-0000148 ： 11 Rev.1 16.0+0.3/ -0.1 4.5±0.1 http://www.everlight.com May 21, 2012 8 PIN DIP DUAL CHANNEL HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER EL253X series Solder Reflow Temperature Profile 260 °C (peak,10 Sec Max) >255 °C ( 30s Max ) 217°°C 1-3 °C/Sec Max 200°°C 60 – 120 Sec 150°°C 60 – 100 Sec 1-3 °C/Sec Max TIME (S) Everlight Electronics Co., Ltd. Document No DPC-0000148 ： 12 Rev.1 http://www.everlight.com May 21, 2012 8 PIN DIP DUAL CHANNEL HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER EL253X series DISCLAIMER 1. Above specification may be changed without notice. EVERLIGHT will reserve authority on material change for above specification. 2. When using this product, please observe the absolute maximum ratings and the instructions for using outlined in these specification sheets. EVERLIGHT assumes no responsibility for any damage resulting from use of the product which does not comply with the absolute maximum ratings and the instructions included in these specification sheets. 3. These specification sheets include materials protected under copyright of EVERLIGHT corporation. Please don’t reproduce or cause anyone to reproduce them without EVERLIGHT’s consent. Everlight Electronics Co., Ltd. Document No DPC-0000148 ： 13 Rev.1 http://www.everlight.com May 21, 2012