2N6504G

Thyristors Datasheet 2N6504 Series SCRs-25 AMPERES RMS– 50 - 800V Pb Description The 2N6504 is designed primarily for half-wave AC control applications, such as motor controls, heating controls and power supply crowbar circuits. Features ■ Glass Passivated Junctions for Greater Parameter Uniformity and Stability ■ Blocking Voltage to 800 Volts ■ Small, Rugged, Thermowatt Construction for Low Thermal Resistance, High Heat Dissipation and Durability ■ Pb−Free Package is Available Additional Information ■ 300 A Surge Current Capability Functional Diagram G K A Resources Accessories Samples Pin Out 4 1 1 TO-220AB Case 221A Style 4 23 © 2021 Littelfuse, Inc. Specifications are subject to change without notice. Revised: GD. 06/03/21 Thyristors Datasheet 2N6504 Series SCRs-25 AMPERES RMS– 50 - 800V Maximum Ratings (TJ = 25°C unless otherwise noted) Rating 2N6504 2N6505 2N6507 2N6508 2N6509 Peak Repetitive Off-State Voltage (Note 1) (Gate Open, Sine Wave 50 to 60 Hz, TJ = 25 to 125°C) On-State RMS Current (180° Conduction Angles; TC = 85°C) Symbol Value Unit VDRM, VRRM 50 100 400 600 800 V IT 25 A Average On-State Current (180° Conduction Angles; TC = 85°C) IT (AV) 16 A Peak Non-repetitive Surge Current (1/2 Cycle, Sine Wave 60 Hz, TJ = 100°C) ITSM 250 A (RMS) Forward Peak Gate Power (Pulse Width ≤ 1.0 µs, TC = 85°C) PGM 20 W Forward Average Gate Power (t = 8.3 ms, TC = 85°C) PG(AV) 0.5 W Forward Peak Gate Current (Pulse Width ≤ 1.0 µs, TC = 85°C) IGM 2.0 A Operating Junction Temperature Range TJ -40 to +125 °C Storage Temperature Range Tstg -40 to +150 °C Stresses exceeding Maximum Ratings may damage the device. Maximum Ratings are stress ratings only. Functional operation above the Recommended Operating Conditions is not implied. Extended exposure to stresses above the Recommended Operating Conditions may affect device reliability. 1. VDRM and VRRM for all types can be applied on a continuous basis. Ratings apply for zero or negative gate voltage; however, positive gate voltage shall not be applied concurrent with negative potential on the anode. Blocking voltages shall not be tested with a constant current source such that the voltage ratings of the devices are exceeded. Thermal Characteristics Rating *Thermal Resistance, Junction to Case *Maximum Lead Temperature for Soldering Purposes, 1/8” from case for 10 seconds Symbol Value Unit RƟJC 1.5 °C/W TL 260 °C * Indicates JEDEC Registered Data. Electrical Characteristics - OFF (TC = 25°C unless otherwise noted) Characteristic †Peak Repetitive Blocking Current (VAK = VDRM = VRRM; Gate Open) TJ = 25°C TJ = 125°C Symbol Min Typ Max IDRM, IRRM - - 10 Unit µA - - 2.0 mA Electrical Characteristics - ON (TC = 25°C unless otherwise noted; Electricals apply in both directions) Characteristic * Forward On-State Voltage (Note 2) (ITM = 50 A) * Gate Trigger Current (Continuous dc) (VAK = 12 Vdc, RL = 100 ) TC = 25°C TC = -40°C Symbol Min VTM IGT Typ Max Unit − − 1.8 V − 9.0 30 − − 75 mA * Gate Trigger Voltage (Continuous dc) (VAK = 12 Vdc, RL = 100 Ω, TC = -40 °C) VGT − 1.0 1.5 V Gate Non-Trigger Voltage (VAK = 12 Vdc, RL = 100 Ω, TJ = 125°C) VGD 0.2 − − V - 18 40 - - 80 *Holding Current (VD = 12 Vdc, Initiating Current = 200 mA, Gate Open) TC = 25°C TC = -40°C * Turn-On Time (ITM = 25 A, IGT = 50 mAdc) Turn-Off Time (VDRM = rated voltage) IH mA tgt - 1.5 2.0 µs (ITM = 25 A, IR = 25 A) tq - 15 - µs (ITM = 25 A, IR = 25 A, TJ = 125 oC) tq - 35 - µs *Indicates JEDEC Registered Data 2. Pulse Test: Pulse Width ≤ 300 µsec, Duty Cycle ≤ 2%. 2 © 2021 Littelfuse, Inc. Specifications are subject to change without notice. Revised: GD. 06/03/21 Thyristors Datasheet 2N6504 Series SCRs-25 AMPERES RMS– 50 - 800V Dynamic Characteristics Characteristic Critical Rate of Rise of Off-State Voltage (Gate Open, Rated VDRM, Exponential Waveform) Symbol Min Typ Max Unit dv/dt − 50 − V/µs Voltage Current Characteristic of SCR +Current Symbol Parameter VDRM Peak Repetitive Forward Off State Voltage IDRM Peak Forward Blocking Current VRRM Peak Repetitive Reverse Off State Voltage IRRM Peak Reverse Blocking Current VTM Maximum On State Voltage IH Holding Current VTM On State IRRM at VRRM IH Quadrant 3 Main Terminal 2- Figure 1. AverageCurrent Derating Quadrant 1 Main Terminal 2+ IH Off State +Voltage IDRM at VDRM VTM Figure 2. Maximum On-State Power Dissipation 3 © 2021 Littelfuse, Inc. Specifications are subject to change without notice. Revised: GD. 06/03/21 Thyristors Datasheet 2N6504 Series SCRs-25 AMPERES RMS– 50 - 800V Figure 3. Typical On−State Characteristics Figure 4. Maximum Non−Repetitive Surge Current Figure 5. Thermal Response 4 © 2021 Littelfuse, Inc. Specifications are subject to change without notice. Revised: GD. 06/03/21 Thyristors Datasheet 2N6504 Series SCRs-25 AMPERES RMS– 50 - 800V Typical Trigger Characteristics Figure 6. Typical Gate Trigger Current vs. Junction Temperature Figure 7. Typical Gate Trigger Voltage vs. Junction Temperature Figure 8. Typical Holding Current vs.Junction Temperature 5 © 2021 Littelfuse, Inc. Specifications are subject to change without notice. Revised: GD. 06/03/21 Thyristors Datasheet 2N6504 Series SCRs-25 AMPERES RMS– 50 - 800V Dimensions Part Marking System SEATING PLANE B F 4 Q 12 C T S 4 A TO-220AB Case 221A Style 3 U 3 H K Z 1 R L V 23 J G D N Dim A B C D F G H J K L N Q R S T U V Z Inches Millimeters Min Max Min Max 0.590 0.380 0.178 0.025 0.142 0.095 0.110 0.018 0.540 0.060 0.195 0.105 0.085 0.045 0.235 0.000 0.045 --- 0.620 0.420 0.188 0.035 0.147 0.105 0.130 0.024 0.575 0.075 0.205 0.115 0.095 0.060 0.255 0.050 --0.080 14.99 9.65 4.52 0.64 3.61 2.41 2.79 0.46 13.72 1.52 4.95 2.67 2.16 1.14 5.97 0.00 1.15 --- 15.75 10.67 4.78 0.89 3.73 2.67 3.30 0.61 14.61 1.91 5.21 2.92 2.41 1.52 6.47 1.27 --2.04 Y M A AKA G 2N650xG YMAXX =Year =Month =Assembly Site =Diode Polarity =Pb-Free Package Pin Assignment 1 Cathode 2 Anode 3 Gate 4 Anode Ordering Information Device Package 2N6504 TO-220AB TO-220AB (Pb-Free) TO-220AB TO-220AB (Pb-Free) TO-220AB TO-220AB (Pb-Free) TO-220AB TO-220AB (Pb-Free) TO-220AB TO-220AB (Pb-Free) TO-220AB TO-220AB (Pb-Free) TO-220AB TO-220AB (Pb-Free) TO-220AB TO-220AB (Pb-Free) TO-220AB 2N6504G 2N6505 2N6505G 2N6505T 2N6505TG 2N6507 1. Dimensioning and tolerancing per ansi y14.5m, 1982. 2. Controlling dimension: inch. 3. Dimension z defines a zone where all body and lead irregularities are allowed. 2N6507G 2N6507T 2N6507TG 2N6508 2N6508G 2N6508TG 2N6509 2N6509G 2N6509T 2N6509TG Shipping 1000 Units / Box 1000 Units / Box 1000 Units / Box 1000 Units / Box 1000 Units / Box 1000 Units / Box 1000 Units / Box 1000 Units / Box Disclaimer Notice - Information furnished is believed to be accurate and reliable. However, users should independently evaluate the suitability of and test each product selected for their own applications. Littelfuse products are not designed for, and may not be used in, all applications. Read complete Disclaimer Notice at http://www.littelfuse.com/disclaimer-electronics. 6 © 2021 Littelfuse, Inc. Specifications are subject to change without notice. Revised: GD. 06/03/21