MMCX-LR-SMT

Ultra Miniature Snap-on Coaxial Connector (PC Card Type 2 Mountable) MMCX Series Right-angle Receptacle Right-angle Receptacle Right-angle Receptacle + Straight Plug Right-angle Receptacle + Straight Plug sFeatures 1. Snap-on coupling mechanism makes it easy to engage and disengage. The rugged snap-on interface which uses no slotting in the outer conductor maintains mechanical stability by allowing constant mating force and rotation without degradation of electrical performance. Right-angle Receptacle + Right-angle Plug Right-angle Receptacle + Right-angle Plug 2. Low Profile accommodates PCMCIA type 2 cards The MMCX-LR-SMT with a height of only 3.51mm can be mounted on the bottom of the type 2 card. For installation on the PCB surface, the connector has a 0.36mm offset from the card centerline, which allows the card center axis to coincide with the connector center axis. Vertical Receptacle Vertical Receptacle 3. Designed for ultra thin cable Industry Standard RG-type coaxial cable ··· RG-178B/U (Ø1.8) ··· RG-316/U (Ø2.59 max.) Ø1.48 single shielded cable (one of the smallest available) ··· DFSS111-U1979 (Ø1.48) made by Junkosha Inc. ··· CO-6F·FH-SB (Ø1.48) made by Hitachi Cable Ltd. ··· RF-MF507 (Ø1.48) made by Nissei Electric Co., Ltd. Vertical Receptacle + Straight Plug Vertical Receptacle + Straight Plug 4. Cable Assemblies with multiple design options By using Ø1.48 single shielded cable, the opposite end of the assembly can be connected with N, BNC, HRM (SMA type), TNC and H.FL series. 5. Matched Excellent Impedance The interface is slotless to minimize RF leakage. High frequency characteristics achieve a maximum voltage standing-wave ratio (VSWR) of 1.2 at DC-6GHz (typical value, that is not applicable to all products). Vertical Receptacle + Right-angle Plug Vertical Receptacle + Right-angle Plug 6. Compatibility Mates will all industry standard MMCX connectors. B31 sProduct Specifications Nominal characteristic impedance Rating Rated frequency DC-6GHz Operating Relative Humidity 90% max. 50 ohms Operating Temperature Range -55ç to +85ç Item 01. Insulation Resistance 500M ohms min. Specification 500V DC 500V AC / 1 minute 100mA (DC or 1000Hz) Condition 02. Withstanding Voltage Neither short nor breakdown 03. Contact Resistance 10m ohms max. (center), 05m ohms max. (outer) 04. Female Contact Retention 0.2N to 2N 05. Insertion and withdrawal force (plug) Insertion force: 15N max. withdrawal force: 6 to 15N 1.2 max. 1.2 max. (MMCX-LR-SMT only) 1.4 max. (MMCX-LR-SMT only) Measured with the Ø0.37 pin gauge. Measured with an appropriate connector. DC to 6GHz DC to 4GHz 4GHz to 6GHz Measured at 0.45GHz to 6GHz Frequency: 10 to 500 Hz, single amplitude of 0.75 mm or acceleration of 98 m/s2(peak), 2 hours in each of the 3 directions. Acceleration of 735 m/s2, 6 ms duration, sine half-wave waveform, 3 cycles in each of the 3 axis 06. Voltage standing wave ratio 07. Vibration No electrical discontinuity of 1µs or more No damage, cracks, or parts looseness. No electrical discontinuity of 1µs or more No damage, cracks, or parts looseness. No damage, cracks, or parts looseness. Insulation resistance: 10M ohms min(High temperature) Insulation resistance: 500M ohms min(Dry) Contact resistance: 20m ohms max. (center) 08. Shock 09. Humidity 96 hours at temperature of 40ç and humidity of 90% to 95% 10. Temperature Cycle 10m ohms max. (outer) No damage, cracks, or parts looseness. Contact resistance: 20m ohms max. (center) 10m ohms max. (outer) Temperature of: -55ç ➝+20 to 35ç ➝+85ç ➝+20 to 35ç Time: 30 minutes ➝5 minutes max. ➝30 minutes ➝5 minutes min. 5 cycles 500 cycles Exposed to density 5% salt water for 48 hours 11. Operating Life 12. Resistance to Corrosion No marked corrosion *Voltage standing wave ratio (V.S.W.R.) measuring system. The above voltage standing wave ratio (V.S.W.R.) standard value is measured in the measuring system as shown below. Network Analyzer Test Set Test Port D.U.T Test Post Cable Termination NOTE 1 : The cable connector is measured with double ended 15cm cable assembly. NOTE 2 : The PCB connector is mounted on the 50 ohms printed circuit board, to which Hirose's adaptor is connected. sMaterial Parts Body Male center contact Female center contact Male/female in-line contact Insulator Fixing ring Crimp sleeve Cover Material Brass Stainless steel (conversion adaptor) Phosphor bronze Beryllium bronze Beryllium copper (conversion adaptor) PTFE Beryllium copper (plug) Copper Brass (plug) Finish Gold plating Gold plating Gold plating Gold plating –– Gold plating Gold plating Gold plating B32 sOrdering Information MMCX – [***] – [***] q q Series name w Connector type P : Straight plug LP : Right Angle plug J : Straight jack R : Receptacle LR : Right Angle receptacle w e e Applicable cable, PCB mounting style 178B/U : RG-178B/U (Ø1.8) 316/U FHSB PC SMT : R/G-316/U (Ø2.59 max) : Ø1.48 single shielded cable : PCB Through Hole type : PCB Surface Mount type : MMCX BInterface Dimensions [Jack] 2.59MIN REF.PLANE 1.6±0.03 REF.PLANE [Plug] 2.69MIN 1.48±0.02 Ø2.38±0.02 Ø1.6±0.02 0.1 +0.15 –0.1 1.05±0.15 2.32±0.02 0.23MAX Ø0.4±0.02 0.2MAX 1.4MIN Ø0.7±0.02 60 ˚ 15 ˚ ˚ 30 Ø3.02±0.02 Ø2.88±0.02 70 ˚ B33 sRight Angle Plug q Ø1.48 Single Shield Cable 11 4 Ø0.9 7 5.25 Ø1.9 Part Number MMCX-LP-FHSB CL No. 339-0007-3 qRG-178B/U and equivalent 11 4 Ø0.9 7 5.25 Ø2.4 Part Number MMCX-LP-178B/U CL No. 339-0001-7 qR/G-316/U and equivalent 11 Ø1.6 12 Ø3 Ø3.5 4 7 5.25 Part Number MMCX-LP-316/U CL NO. 339-0006-0 B34 sStraight Plug qØ1.48 Single Shielded Cable 14 7 Ø0.9 Ø4 Ø1.9 Part Number MMCX-P-FHSB CL No. 339-0008-6 qRG-178B/U and equivalent 14 Ø0.9 Ø2.4 7 Ø4 Part Number MMCX-P-178B/U CL No. 339-0010-8 B35 sStraight Jack qØ1.48 Single Shielded Cable 14.8 7.8 Ø0.9 Ø4 Ø1.9 Part Number MMCX-J-FHSB CL No. 339-0009-9 qRG-178B/U and equivalent 14.8 7.8 Ø0.9 Ø4 Ø2.4 Part Number MMCX-J-178B/U CL No. 339-0011-0 B36 sReceptacle qRight Angle, PCB Surface Mount 7.37 3.51 Ø0.7 1.4 4.45 Ø4.47 3.4 0.36 Part Number MMCX-LR-SMT CL No. 339-0003-2 Packaging 50 pcs PER case qVertical, PCB Through Hole 3.5 2.54 Ø0.7 4-0.5 7.37 4.45 2.54 3.5 4-0.5 Ø3.5 Part Number MMCX-R-PC CL No. 339-0005-8 Packaging 50 pcs PER case qRight Angle, PCB Through Hole 3.5 2.54 Ø0.7 4-0.5 6.8 3.8 2.1 2.54 3.5 4-0.5 4.75 6.5 Part Number Ø3.5 CL No. 339-0013-6 Packaging 50 pcs PER case MMCX-LR-PC-1 7±0.05 4.6±0.1 3.5 +0.1 0 4-Ø1±0.1 2±0.1 2.54±0.05 2.54±0.05 2 1.6 4.5±0.05 7.5±0.05 3.5±0.1 3.5±0.1 5- Ø0 .9 +0 . 01 1±0.03 1.1 PCB mounting pattern (MMCX-LR-SMT) (Reference) Glass epoxy FR-4 t=0.8 ( s=4.6) PCB mounting pattern (MMCX-R-PC) (MMCX-LR-PC-1) B37 sConversion Adaptor qSMA Conversion Adaptor (Mating area: SMA side plug – MMCX side jack) 13.74 3.64 Ø4 8HEX Part Number HRMP-MMCXJ CL No. 311-0312-1 qSMA Conversion Adaptor (Mating area: SMA side jack – MMCX side plug) 14 4.05 6 Ø6.35 spanner engaged width : 5.6 1/4_36UNS_2A Part Number HRMJ-MMCXP CL NO. 311-0313-4 B38