HAC500P-490

H HiTRON 03/29/2008 UNIVERSAL AC INPUT HARMONIC CORRECTION AC-DC HOT-SWAP CompactPCI QUAD OUTPUT 500 WATTS ACTIVE CURRENT SHARING SWITCHING POWER SUPPLIES HAC500P SERIES FEATURES: 500W 6U X 8HP EUROCARD PACKAGE MEET IEC 61000-3-2 HARMONIC CORRECTION INTERNAL OR-ING DIODES FOR N+1 REDUNDANCY HOT-SWAPPABLE THIRD-WIRE CURRENT SHARING EMI MEET EN 55022 / CLASS A CE MARKING COMPLIANCE FULLY COMPLIANT WITH PICMG SPECIFICATION INPUT SPECIFICATION Input Voltage: Typ. 90-264Vac. Input On/Off switch: Option. Power Factor Correction: Meet Harmonic Correction IEC 61000-3-2.Power Factor typ. 0.99. Input Connector: Positronic 47-pin PCIH47M400A1. Input Frequency: 47-63Hz. Inrush Current: ≤ 30.6A(rms) @ 230Vac. Input Current: 5.1A@115Vac/2.6A @230Vac. Dielectric Withstand: Meet IEC 60950-1 regulation. Transient Protection: MOV withstands transient as specified by EN 61000-4-4 level 3. EMI: Meet EN 55022 Class A. Hold-up Time: 22.4mS @ 115Vac,34mS @ 230Vac. Remote ON/OFF: Available at [INH#] & [EN#] pins. Power Fail Signal: Available at [FAL#] pin. Status LED: means valid input voltage. means a critical fault. Thermal Protection (OTP): Installed NTC and thermostat for thermal sensor at [DEG#] pin. Leakage Current: Typ. 0.7mA @ 230Vac. OUTPUT SPECIFICATION Output Voltage: See Ratings Chart. Output Current: See Ratings Chart. Output Power: Typ. 500W continuous. Output Connector: Positronic 47-pin PCIH47M400A1. Line Regulation: Typ. 0.1%. Load Regulation: VO1 & VO2 typ. ±0.5%. VO3 typ. ±1.0%, VO4 typ. ±3.0%. Noise & Ripple: Typ. 1% peak-peak or 50mV, whichever is greater. OVP: Built-in at all outputs. Adjustability: Available at VO1,2,3 & 4. Output Trim: Electrical trim available at VO1/2. [ADJ #]. Remote Sensing: Available at VO1,VO2 & VO3. Hot-Swap: Available. N+1 Redundancy: Installed with internal OR-ing diodes at all outputs and third-wire current sharing method for N+1 redundancy operation. Current Sharing: Third-wire current sharing at VO1,2 & 3. DC OK Signal: Available for all outputs. Power OK Signal: Available for all outputs. Over Current Protection (OCP): Installed at each rail. Overload Protection (OLP): Fully protected against output overload or short circuit. Typ. 120-130% max. load. Consult the factory for special OLP setting. GENERAL SPECIFICATION Efficiency: Typ. 77-80 %. Switching Frequency: 120K Hz. Circuit Topology: Forward circuit. Transient Response: Peak transient less than 250mV and returns to within 1% less than 0.5ms for 50% load-change. Safety Standard: IEC 60950-1 Class I. Construction: Eurocard 6U X 8HP X 160mm CompactPCI format. Front Panel with Extractor handle. Operating Temperature: -30 to +50 °C at full load with specified air flow. Derates linearly to 50% at +70 °C. Storage Temperature: -30 to +85 °C. Temperature Coefficient: Typ. ±0.04% / °C. Cooling: At least 800LFM moving air is required to achieve full rating power 500W in a confined area. Power Density: 5.0 Watts/ Cubic Inch. Note: Due to requests in market and advances in technology, specifications subject to change without notification. Hitron Electronics Cororation. B4-11, P.O. Box 26-110 Kaohsiung Export Processing Zone Kaohsiung 806 Taiwan TEL: 886-7-8210410/FAX: 886-7-8419917, 886-7-8210511/E-mail: sales@hitron-e.com/8210511@seed.net.tw /Web-site: www.hitron-e.com For the details of safety approval, please consult the factory. 1 OUTPUT VOLTAGE / CURRENT RATINGS CHART QUAD OUTPUT MAIN +VO1 @★#≡☉ MODEL NO. Min. HAC500P-490 4A Typ. 50A Volt. +5V Max. 60A Min. 0A Typ. Volt. Max. Min. Typ. Volt. Max. Pk. Min. Typ. Volt. Max. Pk. 0A 10A +12V 14A 15A 0A 3A -12V 4A 5A AUX. +VO2 ▲@★#≡☉ AUX. +VO3 ▲≡#☉★@ AUX. –VO4 @▲☉★ 30A +3.3V 60A Symbol: "★" OVP built-in. "@" Adjustable. "#" Remote sensing. "≡" 3rd-wire Load Sharing. "☉" Installed with Or-ing diode. "▲" Magnetic Amplifier. "●" Installed with Post-regulator. . Remark: Peak load less than 60sec. with duty cycle