6-1617804-2

SERIES FCAV-325 RELAY-NONLATCH 10 Ampere/ 230VAC-400 Hz, 3PDT* *Contacts rated at 230 VAC for higher voltage systems on more electric aircraft. PRODUCT FACTS: o Non latching Hermetically Sealed Relay. o Balanced force design. o Permanent magnet drive. Polarized single side stable design. o All welded construction. o Coils available: DC: 6, 12, 28, 48 VDC. AC: 28,115 VAC (50/400 Hz). o Contacts: Silver Cadmium oxide with Gold plating. o Designed and built in accordance to MIL- PRF-83536. o Weight 82 grams (2.89 ounces) Max. PRODUCTION DATA SHEET 11JUN10 Rev PH. 828-338-1087 FAX 828-338-1103 1396 CHARLOTTE HIGHWAY, FAIRVIEW, NC 28730 , CARPINTERIA, CA 93013 Dimensions shown for reference Only. Specifications subject to change. SERIES FCAV-325 CAGE CODE SHEET SCALE NONE REV 11/06/10 1 of 6 GENERAL CHARACTERISTICS Temperature range Altitude -70° C to +125° C 300,000 feet Dielectric strength at sea level - All circuits to ground and circuit to circuit. - Coil to ground 1250 Vrms 1000 Vrms Dielectric strength at altitude 80,000 ft (all points) Initial Insulation resistance at 500 Vdc 350 Vrms 100 MΩ min 100 MΩmin. min. 50 MΩ Insulation resistance after life or environmental test 30g/ 33-3000 Hz Sinusoidal vibration:* Z, Y& X Enclosures W Enclosures(STUD MTG) Random vibration:* Z, Y & X Enclosures W Enclosures (STUD MTG) Shock:* Z, Y & X Enclosures W Enclosures (STUD MTG) Operate time at nominal voltage :DC Relays : AC relays Release time at nominal voltage :DC Relays :AC Relays 20g/ 33 – 3000 Hz 0.4g2/ Hz 50-2000 Hz 0.2g2/ Hz 50-2000 Hz 200g for 6 ms 100g for 6 ms 15 ms max. 20 ms max. 15 ms max. 50 ms max. *Max. Contact opening under vibration or shock 10 microseconds. COIL DATA Coil Code 1 2 3 4(A) 5 6 7 8 9 Nominal Voltages Freq. HZ 6 12 28 28 48 28 VAC 28 VAC 115 VAC 115 VAC DC DC DC DC DC 400 Hz 50/400 Hz 400 Hz 50/400 Hz DC Res. AC AMPS(B) 18 Ohms 70 Ohms 290 Ohms 290 Ohms 865 Ohms 225 mA 120 mA 40 mA 30 mA Over Temperature Range Pick up or Dropout or Below Volts above Volts 4.5 0.3 9.0 0.75 18.0 1.5 18.0 1.5 32.0 2.5 22.0 1.25 22.0 1.25 90.0 5.0 95.0 5.0 Must Hold voltage(C) 2.5 4.5 7.0 7.0 14.0 10.0 10.0 40.0 40.0 PRODUCTION DATA SHEET 11JUN10 Rev PH. 828-338-1087 FAX 828-338-1103 1396 CHARLOTTE HIGHWAY, FAIRVIEW, NC 28730 , CARPINTERIA, CA 93013 Dimensions shown for reference Only. Specifications subject to change. SERIES FCAV-325 CAGE CODE SHEET SCALE NONE REV 11/06/10 2 of 6 A. Code 4 coils have back EMF suppression to 42 Volt max. B. DC Coil Resistance ± 10% at 25°C. C.Relay will stay in picked-up state down to Must Hold Voltages shown. D. Max Overvoltage: 6 & 12 VDC Coils 120% of Nominal; All others 110% of nominal. E.Coils available for other voltages and for AC 50/60 Hz. CONTACT ELECTRICAL CHARACTERISTICS Type of Load Resistive Inductive Motor Lamp Life(Min.) Cycles X103 28VDC 115VAC 400 Hz 230VAC 400Hz 50 25 25 10 10 12 10 50 10 5 50 5 * 60 Hz Loads rated for 10000 operations 115/200 VAC 3φ 400Hz 60Hz* 25 2.5 2.5 10 2 5 1 A. Overload Current 50 Amps DC, 80 Amps 400 Hz. B. Rupture Current 60 Amps DC, 100 Amps 400 Hz. C. Contact Make Bounce 1 Millisecond at Nominal Voltage. D. Max. Contact drop at 25 Amps: initial 0.150 Volts. E. End of Life 0.175 Volts. All endurance ratings are subject to validation - consult factory PART NUMBERING SYSTEM How to order-: (Example) FCAV- 325 A Y 4 RELAY TYPE TERMINALS (Socket Pins, DC Coil) ENCLOSURE (With Flanges) COIL (28 VDC with transient Suppression) PRODUCTION DATA SHEET 11JUN10 Rev PH. 828-338-1087 FAX 828-338-1103 1396 CHARLOTTE HIGHWAY, FAIRVIEW, NC 28730 , CARPINTERIA, CA 93013 Dimensions shown for reference Only. Specifications subject to change. SERIES FCAV-325 CAGE CODE SHEET SCALE NONE REV 11/06/10 3 of 6 TERMINALS CODE “B” CODE “A’’ CODE “C” TERMINAL LAYOUT *Dimensions are shown in inches ± 0.010 and (Millimeters ± 0.25) PRODUCTION DATA SHEET 11JUN10 Rev PH. 828-338-1087 FAX 828-338-1103 1396 CHARLOTTE HIGHWAY, FAIRVIEW, NC 28730 , CARPINTERIA, CA 93013 Dimensions shown for reference Only. Specifications subject to change. SERIES FCAV-325 CAGE CODE SHEET SCALE NONE REV 11/06/10 4 of 6 ENCLOSURES CODE “V” CODE “X” CODE “Z” CODE “W” CODE “Y” Note: All Enclosures have Cupro-Nickel Cans bright acid tin/lead plated after Assembly to terminal headers.Dimensions: inches ±.010 (mm ± .25) For Socket pin terminals: specify ’’Y’’ enclosure with DC Coils &’’V’’enclosures with AC Coils. PRODUCTION DATA SHEET 11JUN10 Rev PH. 828-338-1087 FAX 828-338-1103 1396 CHARLOTTE HIGHWAY, FAIRVIEW, NC 28730 , CARPINTERIA, CA 93013 Dimensions shown for reference Only. Specifications subject to change. SERIES FCAV-325 CAGE CODE SHEET SCALE NONE REV 11/06/10 5 of 6 TERMINAL WIRING DIAGRAM NOTE: 1. THESE RELAYS ARE POLARIZED WITH PERMANENT MAGNET. 2. DIODES USED IN TRANSIENT SUPPRESSION CIRCUITS HAVE PEAK INVERSE VOLTAGE RATING OF 600 VDC MIN. ZENER DIODES HAVE MIN. RATING OF 1 WATT. 3. TERMINAL DESIGNATIONS ARE FOR REFERENCE ONLY & DO NOT APPEAR ON THE HEADER. PRODUCTION DATA SHEET 11JUN10 Rev PH. 828-338-1087 FAX 828-338-1103 1396 CHARLOTTE HIGHWAY, FAIRVIEW, NC 28730 , CARPINTERIA, CA 93013 Dimensions shown for reference Only. Specifications subject to change. SERIES FCAV-325 CAGE CODE SHEET SCALE NONE REV 11/06/10 6 of 6