LVC-LVC2010LF-R020-G

Miniature Current Sense Surface Mount Chip Resistors LVC Series • RoHS compliant • Tolerances to ±1% • Resistance range from 0.01Ω up to 1Ω • Available in 0402, 0603, 0805, 1206, 2010 and 2512 chip sizes IRC’s new LVC miniature surface mount chip resistors combine small size with precision tolerances for accurate current sense applications. Excellent power handling capability, low TCR, low inductance and resistance tolerances to ±1% make the LVC series an ideal choice for disk drive, computer power supply, and battery pack applications. Electrical Data Size Power Rating at 70°C Tolerance Resistance Range* 50mΩ - 100mΩ 0402 62.5mW 1%, 2%, 5% 101Ω - 500mΩ 501mΩ - 1000mΩ 20mΩ - 50mΩ 0603 100mW 1%, 2%, 5% 51mΩ - 100mΩ 101mΩ - 500mΩ 501mΩ - 1000mΩ 20mΩ - 50mΩ 0805 125mW 1%, 2%, 5% 51mΩ - 100mΩ 101mΩ - 500mΩ 501mΩ - 1000mΩ 10mΩ - 20mΩ 1206 250mW 1%, 2%, 5% 21mΩ - 50mΩ 51mΩ - 500mΩ 501mΩ - 1000mΩ 10mΩ - 20mΩ 2010 750mW 1%, 2%, 5% 21mΩ - 50mΩ 51mΩ - 500mΩ 501mΩ - 1000mΩ 10mΩ - 20mΩ 2512 1000mW 1%, 2%, 5% 21mΩ - 50mΩ 51mΩ - 500mΩ 501mΩ - 1000mΩ *Standard Values E24 Preferred General Note IRC reserves the right to make changes in product specification without notice or liability. All information is subject to IRC’s own data and is considered accurate at time of going to print. Absolute TCR ±400 ±300 ±300 ±600 ±400 ±300 ±200 ±600 ±400 ±300 ±200 ±600 ±400 ±300 ±200 ±600 ±400 ±300 ±200 ±600 ±400 ±300 ±200 Operating Temperature -55°C to +155°C Advanced Film Division • 4222 South Staples Street • Corpus Christi Texas 78411 USA Telephone: 361 992 7900 • Facsimile: 361 992 3377 • Website: www.irctt.com A subsidiary of TT electronics plc LVC Series Issue July 2008 Miniature Current Sense Surface Mount Chip Resistors Environmental Performance Data Environmental Test Thermal Shock Short Time Overload High Temperature Exposure Dielectric Withstanding Voltage Humidity (steady state) Load Life Low Temperature Operation Resistance to Solder Heat Insulation Resistance Solderability Test Method MIL-STD-202 Method 107G Condition B, -55°C +150°C, 100 cycles 6.25X Rated Power for 5 seconds 100 hours @150°C MIL-STD-202, Method 301 2.5X Rated Voltage, 1 minute MIL-STD-202 Method 103B 40°C, 90-95% RH, 1000 hours 1000 hours, Rated Power, 70°C 1.5 hours on, 30 minutes off 1 hour -65°C followed by rated power for 45 min MIL-STD-202 Method 210 260°C, 10 seconds MIL-STD-202 Method 302 100VDC, 1 minute MIL-STD-202 Method 208 245°C, 5 seconds Typical Performance ±0.5% + 1.0mΩ ±0.5% + 0.5mΩ ±0.5% + 0.5mΩ ±0.25% + 0.5mΩ ±0.5% + 0.5mΩ ±1.0% + 0.5mΩ ±0.5% + 0.5mΩ ±0.5% + 1.0mΩ >1000 megohms 95% min Coverage Physical Data (mm) Chip Dimensions L 0402 1.00 ±0.05 1.60 ±0.10 2.00 ±0.15 3.05 ±0.15 5.00 ±0.20 6.35 ±0.20 W 0.50 ±0.05 0.80 ±0.10 1.25 ±0.15 1.55 ±0.15 2.45 ±0.15 3.15 ±0.15 T 0.32 ±0.10 0.45 ±0.10 0.55 ±0.10 0.55 ±0.10 0.60 ±0.15 0.60 ±0.10 C 0.25 ±0.10 0.30 ±0.20 0.30 ±0.20 0.50 ±0.30 0.60 ±0.30 0.60 ±0.30 A 0.20 ±0.10 0.30 ±0.20 0.40 ±0.25 0.40 ±0.25 0.50 ±0.25 0.55 ±0.25 IPC Recommended Landing Pad Dimensions D 0.65 E 0.65 F L W 0.90 0603 1.00 0.90 1.60 T 0805 1.40 0.95 2.00 E 1206 1.75 1.00 3.00 D R A 0 F 2010 2.70 1.20 4.70 2512 3.40 1.10 6.10 Advanced Film Division • 4222 South Staples Street • Corpus Christi Texas 78411 USA Telephone: 361 992 7900 • Facsimile: 361 992 3377 • Website: www.irctt.com 2 7 LVC Series Issue July 2008 C Miniature Current Sense Surface Mount Chip Resistors Tape & Reel Packaging Data (mm) Bottom Tape Top Tape Ø D0 E A F W B Ø 1.4 min. direction of unreeling T Resistor P1 P2 P0 A 0402 0603 0805 1206 0.70±0.05 1.10 ±0.05 1.60 ±0.05 2.00±0.05 B 1.16±0.05 1.90 ±0.05 2.37 ±0.05 3.55±0.05 E 1.75 ±0.05 1.75 ±0.05 1.75 ±0.05 1.75±0.05 F 3.5 ±0.05 3.5 ±0.05 3.5 ±0.05 3.5±0.05 W 8.00 ±1.0 8.00 ±1.0 8.00 ±1.0 8.0±1.0 T 0.40 ±0.03 0.60 ±0.03 0.75 ±0.05 0.75±0.05 P0 4.00 ±0.10 4.00 ±0.10 4.00 ±0.10 4.00 ±0.10 P1 2.00±0.5 4.00±0.5 4.00±0.5 4.00±0.5 P2 2.00±0.05 2.00±0.05 2.00±0.05 2.00±0.05 ØD0 1.55±0.05 1.55±0.05 1.55±0.05 1.55±0.05 Qty/ Reel 10k 5k 5k 5k Emboss Plastic Tape Packaging Data (mm) Top Tape Ø D0 E A F W B Ø 1.4 min. direction of unreeling T Emboss Tape Resistor P1 P2 P0 A 2010 2512 2.85±0.10 3.40±0.10 B 5.45±0.10 6.65±0.10 E 1.75±0.10 1.75±0.10 F 5.5±0.05 5.5±0.05 W 12.0±0.10 12.0±0.10 T 1.00±0.20 1.00±0.20 P0 4.00±0.05 4.00±0.05 P1 4.00±0.10 4.00±0.10 P2 2.00±0.05 2.00±0.05 ØD0 1.50±0.10 1.50±0.10 Qty/ Reel 4k 4k Advanced Film Division • 4222 South Staples Street • Corpus Christi Texas 78411 USA Telephone: 361 992 7900 • Facsimile: 361 992 3377 • Website: www.irctt.com LVC Series Issue July 2008 Miniature Current Sense Surface Mount Chip Resistors Power Derating Data 100 Ordering Data Prefix LVC - LVC0805LF - R020 - F Model LVC0402LF; LVC0603LF; LVC0805LF LVC1206LF; LVC2010LF; LVC2512LF % Of Rated P ower 50 Resistance Code 4-Digit resistance code. Ex: R050 = 0.050Ω; 1R00 = 1Ω 10 25° 70° 150° Tolerance Code F = ±1%; G = ±2%; J = ±5% For additional information or to discuss your specific requirements, please contact our Applications Team using the contact details below. Temperature in °C Marking Information 0402 chips will be marked with 3-digit resistance code. Ex: 1R0 = 1Ω, R10 = 0.1Ω, R01 = 0.01Ω All other sizes will have 4-digit marking Advanced Film Division • 4222 South Staples Street • Corpus Christi Texas 78411 USA Telephone: 361 992 7900 • Facsimile: 361 992 3377 • Website: www.irctt.com LVC Series Issue July 2008