15EMC6

CORCOM Product Guide Compact and Cost Effective Dual Stage RFI Power Line Filters EMC Series UL Recognized CSA Certified VDE Approved EMC6 EMC1 EMC Series The EMC series of RFI filters has been developed to reduce conducted noise to acceptable limits for equipment that must comply with the requirements of CISPR in Europe and the FCC specifications in the USA. The EMC series is the most compact dual stage filter available from Tyco Electronics. This cost effective design has a maximum current rating of 30 amps; higher than any similar catalog product. The EMC series was designed to address the need for more differential mode attenuation in the lower frequency range while still maintaining high common mode performance. This type of performance is typically needed for motor drives and switch mode power supplies with increased operating frequencies. The EMC series is ideal for applications that require a high level of performance in a compact, cost effective package. Specifications Maximum leakage current,each line-to-ground 3,6,10 Amp @ 120 VAC 60 Hz: .21 mA @ 250 VAC 50 Hz: .43 mA Hipot rating (one minute): line-to-ground line-to-line Operating frequency: Rated voltage (max.): Minimum insertion loss in dB: Line-to-ground in 50 ohm circuit Current Rating 03A 06A 10A 15A 20A 30A Frequency-MHz .05 .07 .11 .15 1 2 6 6 3 16 65 66 6 6 2 15 65 67 5 2 13 24 72 72 3 1 12 22 70 68 2 2 11 21 58 57 2 2 14 22 47 52 10 62 65 56 57 63 60 15,20,30 Amp .73 mA 1.52 mA 2250 VDC 1450 VDC 50/60 Hz 250 VAC Electrical Schematic 20 60 62 50 54 55 48 30 59 63 48 53 52 43 Line-to-line in 50 ohm circuit LINE LOAD Resistor location for reference only. Current Rating 03A 06A 10A 15A 20A 30A Frequency-MHz .05 .07 .11 .15 1 2 12 13 7 18 64 69 61 61 27 12 12 8 14 15 12 33 54 58 16 16 13 34 61 52 17 19 15 37 67 62 17 18 14 40 62 53 10 65 59 47 36 36 30 20 60 56 34 36 32 28 30 52 54 36 23 30 26 54 Catalog 1654001 Revised 05-07 Dimensions are in inches and millimeters unless otherwise specified. Values in italics are metric equivalents. Dimensions are shown for reference purposes only. Specifications subject to change. USA Cust. Svc.: 1-800-468-2023 CORCOM Prods: 1-847-680-7400 Germany: 49-89-6089-0 www.corcom.com www.tycoelectronics.com CORCOM Product Guide Compact and Cost Effective Dual Stage RFI Power Line Filters (Continued) EMC Series RFI Power Line Filters Case Styles EMC1 Case Dimensions Part No. 3EMC1 B A (max) 3.35 85.1 3.85 97.8 3.85 97.8 4.97 126.2 2.07 52.6 2.56 65.0 2.56 65.0 3.69 93.7 3.94 99.9 5.09 129.3 6.05 153.7 B (max) 1.81 46.0 2.07 52.6 2.07 52.6 2.25 57.2 1.81 46.0 2.07 52.6 2.07 52.6 2.25 57.2 2.07 52.6 2.25 57.2 3.12 79.2 C (max) 1.16 29.5 1.16 29.5 1.53 38.91 1.78 45.2 1.16 29.5 1.16 29.5 1.53 38.9 1.78 45.2 1.53 38.9 1.78 45.2 2.18 55.4 D (max) 2.375 60.3 2.938 74.6 2.938 74.6 4.063 103.2 2.375 60.3 2.938 74.6 2.938 74.6 4.063 103.2 2.938 74.6 4.063 103.2 3.50 88.9 E (max) 2.78 70.6 3.35 85.1 3.35 85.1 4.46 113.3 2.78 70.6 3.35 85.1 3.35 85.1 4.47 113.5 3.35 85.1 4.47 113.5 3.96 100.6 6EMC1 10EMC1 D E A C 15EMC1 20EMC1 3EMC3 Typical dimensions: Terminals: .250 [6.35] Mounting Holes: .187±.008 [4.75±.20] Dia.(2) 6EMC3 10EMC3 15EMC3 B EMC3 10EMC6 15EMC6 20EMC6 A D E C 30EMC6 Typical dimensions: 3,6,10A:18 AWG / 15A: 16 AWG Wire leads: 4.0 [101.6] min. Mounting Holes: .187±.008 [4.75±.20] Dia.(2) EMC6 B Part Numbers D E A Typical dimensions: Terminals: 8-32 (5) Mounting Holes: .187±.008 [4.75±.20] Dia.(2) 30EMC6 03EMC1 06EMC1 10EMC1 15EMC1 20EMC1 3EMC3 6EMC3 10EMC30 15EMC3 10EMC6 15EMC6 20EMC6 30EMC6 E D B A C Typical dimensions: Terminals: 10-32 (5) Slots: .203 x .156 [5.16 x 3.96] Dia.(4) 55 Catalog 1654001 Revised 05-07 Dimensions are in inches and millimeters unless otherwise specified. Values in italics are metric equivalents. Dimensions are shown for reference purposes only. Specifications subject to change. USA Cust. Svc.: 1-800-468-2023 CORCOM Prods: 1-847-680-7400 Germany: 49-89-6089-0 www.corcom.com www.tycoelectronics.com