1EGG1-1

CORCOM Product Guide Smallest Filtered Power Entry Modules with Metric Fuseholders GG/HG Series UL Recognized CSA Certified VDE Approved HG1/GG1 GG8 GG Series The GG series power entry modules combine the functions of a general purpose RFI filter with an IEC power cord connector and single or dual metric fusing, in the smallest possible panel space. A choice of .250” terminals or wire leads is available for the load-side terminations. For maximum cost effectiveness, 6 amp models should be used for all applications rated 6 amps or less, unless the higher performance of the 3 amp models, or the much higher performance of the 1 amp models, is needed. Models with C-suffix additionally incorporate a ground choke1 to isolate the equipment chassis from external ground at RF frequencies. Specifications Maximum leakage current,each line-to-ground HG Models @ 120 VAC 60 Hz: 2µA @ 250 VAC 50 Hz: 5µA Hipot rating (one minute): line-to-ground line-to-line Operating frequency: Rated voltage (max.): Fuse (not included): GG Models .25 mA .42 mA 1550 VAC 1450 VDC 50/60 Hz 250 VAC Accepts one 5x20mm fuse (-1 models) or two 5 x 20 mm fuses (-2 models) HG Series A medical version of our GG series, these filters offer the same compact design but reduce the line-to-ground capacitance in order to meet UL 2601 patient care requirements. For more information on UL2601 specification, see Appendix C. Note: When using the models with an IEC connector, remember that the leakage current of the companion line cord, GA400, is more significant than that of the filter which may disqualify this line cord from use in patient care applications. Current Rating .01 GG/GS Models 1A 12 3A – – 6A HG Models 1A 12 3A – 6A – Minimum insertion loss in dB: Line-to-ground in 50 ohm circuit .05 23 10 1 23 10 4 Frequency-MHz .10 .15 .5 1 5 29 15 4 29 15 10 32 19 10 32 19 14 41 30 16 40 25 18 47 36 22 40 26 18 50 48 36 28 22 14 10 50 50 40 22 21 14 30 55 53 50 18 21 14 Electrical Schematics GG/GS/HG LINE Note 1 LOAD Line-to-line in 50 ohm circuit Current Rating .01 1 1 1 1 1 1 .15 3 2 2 3 2 2 Frequency-MHz .5 1 3 5 14 11 10 26 30 30 23 14 13 35 30 30 41 25 23 35 30 30 47 38 33 35 30 30 10 50 44 39 27 30 30 30 44 40 42 20 30 30 Note 2 GG-C LINE Note 1 LOAD Note 2 Resistor location for reference only. Note 1: Depicts single fuse for -1 models. Note 2: For HG delete line-to-ground capacitors. CAUTION: DO NOT ATTEMPT TO OPERATE A SINGLE-FUSED MODEL WITHOUT THE FUSE DOOR IN PLACE! GG/GS Models 1A 3A 6A HG Models 1A 3A 6A 112 Catalog 1654001 Revised 05-07 Dimensions are in inches and millimeters unless otherwise specified. Values in italics are metric equivalents. Dimensions are shown for reference purposes only. Specifications subject to change. USA Cust. Svc.: 1-800-468-2023 CORCOM Prods: 1-847-680-7400 Germany: 49-89-6089-0 www.corcom.com www.tycoelectronics.com CORCOM Product Guide Smallest Filtered Power Entry Modules with Metric Fuseholders (Continued) GG/HG Series Case Styles GG1/HG1 D C EGS C E D E A A B B Power Entry Modules Recommended Panel Cutouts GG / HG Front or Back Mount 1.14 29.0 GS / HGS Front Mount Only 1.24 31.5 Typical dimensions: Holes: .07 [1.8] Dia. Terminals: .250 [6.35] (3) Mounting Holes: .126 [3.20] Dia. (2) 1.30 33.0 1.29 32.8 GG8 Blue Green/Yellow Brown 1.417 36.0 for panel thickness .032-.080 [.81-2.03] Radius: 0.138 [0.35] Case Dimensions B C .6 15.2 D E A Typical dimensions: Wire leads: 5.0 [127.0] Min. 18 AWG Mounting Holes: .126 [3.20] Dia. (2) A Part No. (max) EGG1-1/EGG1-2/ 2.15 EHG1-2 54.5 EGG8-1/EGG8-2 2.02 EGG8C-1/EGG8C-2 51.1 EGS1-1/EGS1-2 2.13 EHGS1-2 54.0 EGG1C-1-1/EGG1C-2 2.45 62.23 *max B (max) 1.13 28.7 1.13 28.7 1.13 28.7 1.13 28.7 C (max) 1.29 32.8 1.29 32.8 1.28 32.5 1.28 32.5 D ± .015 ± .38 1.417 36.0 1.417 36.0 1.46* 36.0 1.46* 36.0 E (max) 1.76 44.7 1.76 44.7 1.42 36.1 1.42 36.1 Part Number1 RFI Filter Type2 Current Rating3 Metric Fuseholders 1EGG1-1 General Purpose2 1 1 1EGG1-2 General Purpose 1 2 1EGG8-1 General Purpose 1 1 1EGG8-2 General Purpose 1 2 1 1 1EGS1-1 General Purpose 2 General Purpose 1 1EGS1-2 3EGG1-1 General Purpose 3 1 3EGG1-2 General Purpose 3 2 3 1 General Purpose 3EGG8-1 3EGG8-2 General Purpose 3 2 3EGS1-1 General Purpose 3 1 3EGS1-2 General Purpose 3 2 General Purpose 6 1 6EGG1-1 2 6 General Purpose 6EGG1-2 1 6 General Purpose 6EGG8-1 6EGG8-2 General Purpose 6 2 6EGS1-1 General Purpose 6 1 6 2 General Purpose 6EGS1-2 1EHG1-2 Medical 1 2 3EHG1-2 Medical 3 2 6EHG1-2 Medical 6 2 1EHGS1-2 Medical 1 2 2 3 Medical 3EHGS1-2 2 6 Medical 6EHGS1-2 1 Ground choke available on general purpose models. Add suffix "C" (1EGG1C-1). Does not include EGS models. 2 General purpose filter for susceptibility applications. 3 Current rating @120 VAC and 250 VAC. Load Side Terminations .250 [6.35] Terminals (3) .250 [6.35] Terminals (3) 5.0 [127.0] Wire Leads 5.0 [127.0] Wire Leads .250 [6.35] Terminals (3) .250 [6.35] Terminals (3) .250 [6.35] Terminals (3) .250 [6.35] Terminals (3) 5.0 [127.0] Wire Leads 5.0 [127.0] Wire Leads .250 [6.35] Terminals (3) .250 [6.35] Terminals (3) .250 [6.35] Terminals (3) .250 [6.35] Terminals (3) 5.0 [127.0] Wire Leads 5.0 [127.0] Wire Leads .250 [6.35] Terminals (3) .250 [6.35] Terminals (3) .250 [6.35] Terminals (3) .250 [6.35] Terminals (3) .250 [6.35] Terminals (3) .250 [6.35] Terminals (3) .250 [6.35] Terminals (3) .250 [6.35] Terminals (3) 113 Catalog 1654001 Revised 05-07 Dimensions are in inches and millimeters unless otherwise specified. Values in italics are metric equivalents. Dimensions are shown for reference purposes only. Specifications subject to change. USA Cust. Svc.: 1-800-468-2023 CORCOM Prods: 1-847-680-7400 Germany: 49-89-6089-0 www.corcom.com www.tycoelectronics.com