3EF8

CORCOM Product Guide Compact RFI Filter with IEC Connectors EF Series EF8 UL Recognized CSA Certified VDE Approved* EF1F/EF1FC EF2F EF4 EF Series This rugged international series of RFI filters incorporates the special IEC power line connector. They are UL recognized, CSA certified, and VDE approved. Electrically the EF international series are general purpose filters effectively providing RFI control of line-toground noise. The design is compact and meets the very low leakage current requirements of VDE portable equipment as well as (120 Volt) UL544 non-patient medical equipment. Models with F suffix have .250” terminals on load side; EF4 and EF8 have wire leads. Model 10EF1FC additionally incorporates a separate ground-circuit inductor to isolate the equipment chassis from power line ground at RF frequencies. *15EF1F UL, CSA 15 Amps/250 VAC VDE 10 Amps/250 VAC Specifications Maximum leakage current,each line-to-ground @ 120 VAC 60 Hz: @ 250 VAC 50 Hz: Hipot rating (one minute): line-to-ground line-to-line Operating frequency: Rated voltage (max.): Minimum insertion loss in dB: Line-to-ground in 50 ohm circuit Current Frequency-MHz Rating .15 .5 1 5 EF1F, EF2F 01A 03A 06A 10A 15A EF4, EF8 01A 03A 06A EF1FC 10A 22 15 9 8 – 22 15 9 8 35 25 20 15 6 35 25 20 15 40 30 25 20 12 40 30 25 20 46 45 41 34 20 46 45 41 34 .21 mA .36 mA 2250 VDC 1450 VDC 50/60 Hz 250 VAC 10 50 50 45 39 25 50 50 45 39 30 49 54 50 44 25 49 54 47 44 Electrical Schematics EF & EF-F Models LINE LOAD EF1FC Model LINE LOAD Line Cord Line Cord No. GA400: 71/2 foot, 3-conductor line cord to mate with EF series. Resistor location for reference only. 42 Catalog 1654001 Revised 05-07 Dimensions are in inches and millimeters unless otherwise specified. Values in italics are metric equivalents. Dimensions are shown for reference purposes only. Specifications subject to change. USA Cust. Svc.: 1-800-468-2023 CORCOM Prods: 1-847-680-7400 Germany: 49-89-6089-0 www.corcom.com www.tycoelectronics.com CORCOM Product Guide Compact RFI Filter with IEC Connectors (Continued) EF Series RFI Power Line Filters Case Styles EF1F & EF1FC C Case Dimensions A Part No. (max) 1EF1F, 3EF1F 1EF2F, 3EF2F 1EF4, 3EF4 1EF8, 3EF8 2.20 55.9 1.55 39.4 1.55 39.4 1.55 39.4 2.20 6EF1F 55.9 1.55 6EF2F 39.4 1.55 6EF4 39.4 1.55 6EF8 39.4 10EF1F 2.62 66.5 10EF1FC 2.62 66.5 15EF1F* 2.62 66.5 Blue B (max) 1.19 30.2 1.19 30.2 1.19 30.2 1.19 30.2 1.19 30.2 1.19 30.2 1.19 30.2 1.19 30.2 1.19 30.2 1.19 30.2 1.19 30.2 C (max) 0.81 20.6 0.85 21.6 0.85 21.6 0.81 20.6 0.81 20.6 0.85 21.6 0.85 21.6 0.81 20.6 0.81 20.6 0.81 20.6 0.81 20.6 D ± .015 ± .38 E (max) 1.98 50.3 1.98 50.3 1.98 50.3 1.98 50.3 1.98 50.3 1.98 50.3 1.98 50.3 1.98 50.3 1.98 50.3 1.98 50.3 1.98 50.3 F (ref) — — .295 7.5 .295 7.5 — — .295 7.5 .295 7.5 — — — A B D E EF2F C .65 Max. 16.5 D E A B Typical dimensions: Terminals: .250 [6.35] (3) Slot: .07 x .16 [1.8 x 4.1] Holes: .07 [1.8] Dia.(2) EF4 C Brown Green/Yellow 1.575 40.01 1.575 40.01 1.575 40.01 1.575 40.01 1.575 40.01 1.575 40.01 1.575 40.01 1.575 40.01 1.575 40.01 1.575 40.01 1.575 40.01 D E A F Part Numbers 1EF1F 1EF2F 1EF4 1EF8 3EF1F 3EF2F 3EF4 3EF8 Line Cord No. Insulating Boot No. *15EF1F UL, CSA — 15 Amps/250 VAC VDE — 10 Amps/250 VAC B F 06EF1F 06EF2F 06EF4 06EF8 10EF1F 10EF1FC 15EF1F* GA400 FA601 EF8 Brown F B F DE Green/Yellow Blue Recommended Panel Cutouts .820 20.8 .900 22.9 .140 Dia. (2) 3.56 .140 Dia. (2) 3.56 A 1.200 30.48 1.200 30.48 1.575 40.01 C 1.575 40.01 .062 R 1.58 .234 R 5.94 Front Mount Back Mount Tolerance ±.005 [0.13] Typical dimensions: Wire leads 4.0 [101.6] Min. 18 AWG Tolerance ±.005 [0.13] Mounting Holes: .132 [3.35] Dia.(2) Note 1: EF1F, EF1FC and EF8 allow front or back mounting. Note 2: EF2F and EF4 allow back mounting only. 43 Catalog 1654001 Revised 05-07 Dimensions are in inches and millimeters unless otherwise specified. Values in italics are metric equivalents. Dimensions are shown for reference purposes only. Specifications subject to change. USA Cust. Svc.: 1-800-468-2023 CORCOM Prods: 1-847-680-7400 Germany: 49-89-6089-0 www.corcom.com www.tycoelectronics.com