1N5359B-TP

1N5338B THRU 1N5388B Features • Zener Voltage From 5.1V to 200V • Halogen Free Available Upon Request By Adding Suffix "-HF" • Moisture Sensitivity Level 1 • Epoxy Meets UL 94 V-0 Flammability Rating • Lead Free Finish/RoHS Compliant (Note1)("P" Suffix Designates Compliant. See Ordering Information) 5 Watt Zener Diode 5.1 to 200 Volts Maximum Ratings • • • • DO-15 Operating Junction Temperature Range(Note2): -55°C to +200°C Storage Temperature Range: -55°C to +200°C Maximum Thermal Resistence: 15oC/W from Junction to Lead Maximum Thermal Resistence: 83oC/W from Junction to Ambient Parameter Power Dissipation Symbol PD Power Derating Maximum Forward Voltage Rating 5.0W 67mW/oC VF 1.2V D Conditions TL= 75°C Above 75oC A Cathode Mark IF=1.0A Note: 1. High Temperature Solder Exemption Applied, See EU Directive Annex 7a. 2. Max Operating Temperature for DC Conditions is 150°C, But not to Exceed 200°C for Pulsed Conditions With Low Duty Cycle or Non−Repetitive. B D C DIM A B C D Rev.3-5-12012020 1/6 DIMENSIONS INCHES MM MIN MAX MIN MAX 0.230 0.300 5.80 7.60 0.104 0.140 2.60 3.60 0.026 0.035 0.70 0.90 1.000 ----- 25.40 ----- NOTE MCCSEMI.COM 1N5338B THRU 1N5388B Electrical Characteristics @ 25°C Unless Otherwise Specified MCC Part Number 1N5338B 1N5339B 1N5340B 1N5341B 1N5342B 1N5343B 1N5344B 1N5345B 1N5346B 1N5347B 1N5348B 1N5349B 1N5350B 1N5351B 1N5352B 1N5353B 1N5354B 1N5355B 1N5356B 1N5357B 1N5358B 1N5359B 1N5360B 1N5361B 1N5362B 1N5363B 1N5364B 1N5365B 1N5366B 1N5367B 1N5368B 1N5369B 1N5370B 1N5371B 1N5372B 1N5373B 1N5374B 1N5375B 1N5376B 1N5377B 1N5378B 1N5379B 1N5380B 1N5381B 1N5382B 1N5383B 1N5384B 1N5385B 1N5386B 1N5387B 1N5388B Rev.3-5-12012020 Regulator Voltage VZ V 5.1 5.6 6 6.2 6.8 7.5 8.2 8.7 9.1 10 11 12 13 14 15 16 17 18 19 20 22 24 25 27 28 30 33 36 39 43 47 51 56 60 62 68 75 82 87 91 100 110 120 130 140 150 160 170 180 190 200 Test Current IZ mA 240 220 200 200 175 175 150 150 150 125 125 100 100 100 75 75 70 65 65 65 50 50 50 50 50 40 40 30 30 30 25 25 20 20 20 20 20 15 15 15 12 12 10 10 8 8 8 8 5 5 5 Maximum Dynamic Impedance Maximum Reverse Current Test Voltage Maximum Regulator Current Maximum Dynamic Knee Impedance Maximum Surge Current ZZT Ω 1.5 1 1 1 1 1.5 1.5 2 2 2 2.5 2.5 2.5 2.5 2.5 2.5 2.5 2.5 3 3 3.5 3.5 4 5 6 8 10 11 14 20 25 27 35 40 42 44 45 65 75 75 90 125 170 190 230 330 350 380 430 450 480 IR µA 1 1 1 1 10 10 10 10 7.5 5 5 2 1 1 1 1 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 VR V 1 2 3 3 5.2 5.7 6.2 6.6 6.9 7.6 8.4 9.1 9.9 10.6 11.5 12.2 12.9 13.7 14.4 15.2 16.7 18.2 19 20.6 21.2 22.8 25.1 27.4 29.7 32.7 35.8 38.8 42.6 45.5 47.1 51.7 56 62.2 66 69.2 76 83.6 91.2 98.8 106 114 122 129 137 144 152 IZM mA 930 865 790 765 700 630 580 545 520 475 430 395 365 340 315 295 280 264 250 237 216 198 190 176 170 158 144 132 122 110 100 93 86 79 76 70 63 58 54.5 52.5 47.5 43 39.5 36.6 34 31.6 29.4 28 26.4 25 23.6 ZZK @1.0mA Ω 400 400 300 200 200 200 200 200 150 125 125 125 100 75 75 75 75 75 75 75 75 100 110 120 130 140 150 160 170 190 210 230 280 350 400 500 620 720 760 760 800 1000 1150 1250 1500 1500 1650 1750 1750 1850 1850 IZSM A 14.4 13.4 12.7 12.4 11.5 10.7 10 9.5 9.2 8.6 8 7.5 7 6.7 6.3 6 5.8 5.5 5.3 5.1 4.7 4.4 4.3 4.1 3.9 3.7 3.5 3.3 3.1 2.8 2.7 2.5 2.3 2.2 2.1 2 1.9 1.8 1.7 1.6 1.5 1.4 1.3 1.2 1.2 1.1 1.1 1 1 0.9 0.9 2/6 Maximum Voltage Regulation V 0.39 0.25 0.19 0.1 0.15 0.15 0.2 0.2 0.22 0.22 0.25 0.25 0.25 0.25 0.25 0.3 0.35 0.4 0.4 0.4 0.45 0.55 0.55 0.6 0.6 0.6 0.6 0.65 0.65 0.7 0.8 0.9 1 1.2 1.35 1.5 1.6 1.8 2 2.2 2.3 2.5 2.5 2.5 2.5 3 3 3 4 5 5 MARKING CODE 1N5338B 1N5339B 1N5340B 1N5341B 1N5342B 1N5343B 1N5344B 1N5345B 1N5346B 1N5347B 1N5348B 1N5349B 1N5350B 1N5351B 1N5352B 1N5353B 1N5354B 1N5355B 1N5356B 1N5357B 1N5358B 1N5359B 1N5360B 1N5361B 1N5362B 1N5363B 1N5364B 1N5365B 1N5366B 1N5367B 1N5368B 1N5369B 1N5370B 1N5371B 1N5372B 1N5373B 1N5374B 1N5375B 1N5376B 1N5377B 1N5378B 1N5379B 1N5380B 1N5381B 1N5382B 1N5383B 1N5384B 1N5385B 1N5386B 1N5387B 1N5388B MCCSEMI.COM 1N5338B THRU 1N5388B Remarks: 1. TOLERANCE AND VOLTAGE DESIGNATION - The JEDEC type numbers shown indicate a tolerance of+/-10% with guaranteed limits on only Vz, IR, Ir, and VF as shown in the electrical characteristics table. Units with guaranteed limits on all seven parameters are indicated by suffix “B” for+/-5% tolerance. 2. ZENER VOLTAGE (Vz) AND IMPEDANCE (ZZT & ZZK) - Test conditions for Zener voltage and impedance are as follows; Iz is applied 40+/-10 ms prior to reading. Mounting contacts are located from the inside edge of mounting clips to the body of the diode(Ta=25 C) o 3. SURGE CURRENT (Ir) - Surge current is specified as the maximum allowable peak, non-recurrent square-wave current with a pulse width, PW, of 8.3 ms. The data given in Figure 5 may be used to find the maximum surge current for a quare wave of any pulse width between 1 ms and 1000ms by plotting the applicable points on logarithmic paper. Examples of this, using the 6.8v , is shown in Figure 6. Mounting contact located as specified in Note 3. (TA=25 ć ). 4. VOLTAGE REGULATION (Vz) - Test conditions for voltage regulation are as follows: Vz measurements are made at 10% and then at 50% of the Iz max value listed in the electrical characteristics table. The test currents are the same for the 5% and 10% tolerance devices. The test current time druation for each Vz measurement is 40+/- 10 ms. (TA=25C ). Mounting contact located as specified in Note2. 5. MAXIMUM REGULATOR CURRENT (IZM) - The maximum current shown is based on the maximum voltage of a 5% type unit. Therefore, it applies only to the B-suffix device. The actual IZM for any device may not exceed the value of 5 watts divided by the actual Vz of the device. TL=75Cat maximum from the device body. APPLICATION NOTE: Since the actual voltage available from a given Zener diode is temperature dependent, it is necessary to determine junction temperature under any set of operating conditions in order to calculate its value. The following procedure is recommended: Lead Temperature, TL, should be determined from: TL = qLA PD + TA qLA is the lead‐to‐ambient thermal resistance and PD is the power dissipation. Junction Temperature, TJ, may be found from: TJ = TL + DTJL DTJL is the increase in junction temperature above the lead temperature and may be found from Figure 7 for a train of power pulses or from Figure 1 for dc power. DTJL = qJL PD Rev.3-5-12012020 3/6 For worst‐case design, using expected limits of IZ, limits of PD and the extremes of TJ (DTJ) may be estimated. Changes in voltage, VZ, can then be found from: DV = qVZ DTJ qVZ, the Zener voltage temperature coefficient. Under high power‐pulse operation, the Zener voltage will vary with time and may also be affected significantly by the zener resistance. For best regulation, keep current excursions as low as possible. Data of Figure 7 should not be used to compute surge capability. Surge limitations are given in Figure 5. They are lower than would be expected by considering only junction temperature, as current crowding effects cause temperatures to be extremely high in small spots resulting in device degradation should the limits of Figure 5 be exceeded. MCCSEMI.COM 1N5338B THRU 1N5388B Curve Characteristics Fig. 1 - Power Derating Curve Fig. 2 - Typical Zener Breakdown Characteristics 10000 6 VZ - 6.0 thru 10 Volts 1000 Zener Current (mA) Power Dissipation (W) 5 4 3 2 100 10 1 1 0 0 25 50 75 100 125 0.1 150 0 1 2 3 4 Fig. 3 - Typical Zener Breakdown Characteristics 6 7 8 9 10 11 Fig. 4 - Typical Zener Breakdown Characteristics 1000 1000 VZ - 11 thru 75 Volts 500 5 Zener Voltage (V) Lead Temperature (°C) VZ - 82 thru 200 Volts 200 100 50 Zener Current (mA) Zener Current (mA) 100 20 10 5 2 10 1 1 0.5 0.2 0.1 10 20 30 40 50 60 70 0.1 80 80 100 120 140 160 180 Fig. 5 - Surge Current Characteristics 220 Fig. 6 - Peak Surge Current VS Pulse Width 30 40 VZ=6.8V PW=1ms 10 10 PW=8.3ms Peak Surge Current (A) Peak Surge Current (A) 200 Zener Voltage (V) Zener Voltage (V) 1 PW=1000ms Plotted From Information Given in Figure 5 1 Sine / Square Wave PW=100ms 0.1 0.1 3 10 100 200 Rev.3-5-12012020 1 10 100 1000 Pulse Width (ms) Nominal Zener Voltage (V) 4/6 MCCSEMI.COM 1N5338B THRU 1N5388B Curve Characteristics Fig. 7 - Typical Thermal Resistace O Junction to Lead Thermal Resistance (C /W) 40 30 20 10 MOUNT ON 8.0mm2 Copper Pads to Each Terminal 0 0.0 0.2 0.4 0.6 0.8 1.0 Lead Length to Heat Sink (inch) Rev.3-5-12012020 5/6 MCCSEMI.COM 1N5338B THRU 1N5388B Ordering Information Device Packing (Part Number)-TP Tape&Reel: 4Kpcs/Reel (Part Number)-AP Ammo Packing: 3Kpcs/Ammo Box (Part Number)-BP Bulk:500pcs/Box,25Kpcs/Carton Note : Adding "-HF" Suffix For Halogen Free, eg. Part Number-TP-HF ***IMPORTANT NOTICE*** Micro Commercial Components Corp UHVHUYHV WKH ULJKW WR PDNH FKDQJHV ZLWKRXW IXUWKHU QRWLFH WR DQ\ SURGXFW KHUHLQ WR PDNH FRUUHFWLRQV PRGLILFDWLRQV  HQKDQFHPHQWV  LPSURYHPHQWV  RU RWKHU FKDQJHV  Micro Commercial Components Corp  GRHV QRW DVVXPH DQ\ OLDELOLW\ DULVLQJ RXW RI WKH DSSOLFDWLRQ RU XVH RI DQ\ SURGXFW GHVFULEHG KHUHLQ QHLWKHU GRHV LW FRQYH\DQ\OLFHQVHXQGHULWVSDWHQWULJKWVQRUWKHULJKWVRIRWKHUV7KHXVHURISURGXFWVLQVXFKDSSOLFDWLRQVVKDOODVVXPHDOO ULVNVRIVXFKXVHDQGZLOODJUHHWRKROGMicro Commercial Components Corp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ev.3-5-12012020 6/6 MCCSEMI.COM