Series GB
Toggles
Ultra-Miniature Fully Illuminated Plungers
Rockers
General Specifications
Electrical Capacity (Resistive Load)
Logic Level: 0.4VA maximum @ 28V AC/DC maximum (Applicable Range 0.1mA ~ 0.1A @ 20mV ~ 28V) Note: Find additional explanation of operating range in Supplement section.
Pushbuttons
Programmable Illuminated PB
Other Ratings
D
Contact Resistance: Insulation Resistance: Dielectric Strength: Mechanical Life: Electrical Life: Nominal Operating Force: Travel:
80 milliohms maximum 500 megohms minimum @ 500V DC 500V AC minimum for 1 minute minimum 50,000 operations minimum 50,000 operations minimum 1.70N Pretravel .035” (0.9mm); Overtravel .008” (0.2mm); Total Travel .043” (1.1mm)
Keylocks
Materials & Finishes
Slides
Plunger: Case: Sealing Rings: Movable Contact: Stationary Contacts: Base: Switch Terminals: Lamp Terminals:
Polyamide Glass fiber reinforced polyamide Nitrile butadiene rubber Phosphor bronze with gold plating Phosphor bronze with gold plating Glass fiber reinforced polyamide Phosphor bronze with gold plating Phosphor bronze with gold plating
Rotaries
Environmental Data
Tactiles
Operating Temperature Range: Humidity: Vibration: Shock:
–25°C through +55°C (–13°F through +131°F) 90 ~ 95% humidity for 240 hours @ 40°C (104°F) 10 ~ 500Hz with peak-to-peak amplitude of 1.5mm traversing the frequency range & returning in 15 minutes; 3 right angled directions for 2 hours 50G (490m/s2) acceleration (tested in 6 right angled directions, with 5 shocks in each direction)
Tilt
PCB Processing
Touch
Soldering: Cleaning:
Wave Soldering recommended. See Profile A in Supplement section. Manual Soldering: See Profile A in Supplement section. Automated alcohol based cleaning recommended, 5 minutes maximum. Do not use high-purity alcohol (50% alcohol or more) or organic solvent. High alcohol solution can damage clear plastic. See Cleaning specifications in Supplement section.
Indicators
Standards & Certifications
Supplement
Accessories
The GB Series illuminated pushbuttons have not been tested for UL recognition or CSA certification. These switches are designed for use in a low-voltage, low-current, logic-level circuit. When used as intended in a logic-level circuit, the results do not produce hazardous energy.
D8
www.nkk.com
Ultra-Miniature Fully Illuminated Plungers
Series GB
Toggles
D
.100” x .100” (2.54mm x 2.54mm) terminal spacing conforms to standard PC board grid spacing. Round terminals facilitate easier through-hole mounting on PC boards. Nonilluminated pushbuttons available and shown in the Pushbutton section.
www.nkk.com
D9
Supplement
Accessories
Indicators
Actual Size
Touch
Tilt
Tactiles
Slides
Award-winning STC contact mechanism with benefits unavailable in conventional mechanisms: smooth, positive detent actuation, increased contact stability, and unparalleled logic-level reliability. (Additional STC details in Terms & Acronyms; see Supplement section.)
Rotaries
Keylocks
Totally sealed body construction prevents contact contamination and allows time- and money-saving automated soldering and cleaning. Insert-molded terminals lock out flux, solvents, and other contaminants.
Programmable Illuminated PB
Ultra-miniature size allows high density mounting, and extremely light weight makes these switches ideal for handheld equipment.
Pushbuttons
Fully illuminated plunger for highly visible status indication with single color LED in red, green, or amber.
Rockers
Distinctive Characteristics
Series GB
Toggles
Ultra-Miniature Fully Illuminated Plungers
TYPICAL SWITCH ORDERING EXAMPLE
Pushbuttons
Rockers
GB
Pole
1 SPDT 5
1
Circuit
ON (ON)
5
Actuator
J Clear
J
P H V
H
PC Terminals
Straight Right Angle Vertical C D F
F
LEDs
Red Amber Green
( ) = Momentary
Programmable Illuminated PB
D
DESCRIPTION FOR TYPICAL ORDERING EXAMPLE
GB15JHF
SPDT ON-(ON) Circuit Clear Plunger, Green LED Right Angle PC Terminals
Keylocks
POLE & CIRCUIT
Plunger Position ( ) = Momentary Normal Pole Model Down Connected Terminals Normal Down Throw & Switch/Lamp Schematics Note: Terminal numbers are not actually on the switch. LED circuit is isolated and requires an external power source. SPDT
5 (COM)
(1) (3)
Slides
Rotaries
SP
Tactiles
GB15
ON
(ON)
5-6
5-4
4
6
ACTUATOR J
Clear Plunger
(4.0) Dia .157 (3.3) .130 (1.6) .063 (2.0) Dia .079
Touch
Tilt
LED COLORS & SPECIFICATIONS
LEDs are an integral part of the switch and not available separately. The electrical specifications shown are determined at a basic temperature of 25°C. If the source voltage exceeds the rated voltage, a ballast resistor is required. The resistor value can be calculated by using the formula in the Supplement section.
D10
Indicators
C
Colors Forward Peak Current Continuous Forward Current Forward Voltage Reverse Peak Voltage Current Reduction Rate Above 25°C Ambient Temperature Range
www.nkk.com
D
Amber 30mA 20mA 1.9V 5V 0.43mA/°C –25° ~ +55°C
F
Green 25mA 20mA 2.1V 5V 0.36mA/°C
Red 30mA 20mA 1.9V 5V 0.43mA/°C
I FM IF VF VRM ∆I F
Supplement
Accessories
Ultra-Miniature Fully Illuminated Plungers
PC TERMINALS P
Straight
Series GB
V
Vertical
(2.54) Typ .100 (2.54) Typ .100 (0.5) Typ .020 (7.0) .276 (4.5) .177 (0.4) Dia Typ .016
(2.6) .102
(2.54) Typ .100 (7.0) .276 (4.5) .177
(7.0) .276
TYPICAL SWITCH DIMENSIONS
Straight PC
P/N This Side (0.4) Dia Typ .016
1 4 5 3 6
D
(2.54) .100 4 (7.0) .276 (0.6) Dia Typ .024
5 6
1
3
Slot (4.5) .177
(2.0) Dia .079 (3.3) .130
(1.6) .063 (7.0) .276
(2.54) Typ .100 (2.6) .102 (2.54) .100
Terminals 1 & 3 are lamp terminals.
GB15JPD
3
1
(0.4) .016 (4.9) .193
(2.54) Typ .100 1
4 5
3 6
Slot (0.4) Dia Typ .016 (5.08) .200 (7.8) .307
(2.0) Dia .079
(2.6) .102 (5.08) .200 (1.6) .063 (10.22) .402 (0.5) .020 (2.54) .100
6
5
4
(0.6) Dia Typ .024 (0.4) Dia Typ .016 (2.54) Typ .100
(5.08) .200
Terminals 1 & 3 are lamp terminals.
GB15JHF
Vertical PC
(0.4) .016
1 4 5 3 6
4 5 6
1
(4.0) Dia .157 Slot (0.4) Dia Typ .016 (2.54) .100 (5.3) .209 (3.3) .130 (2.0) Dia .079 (5.08) .200 (1.6) .063 (12.76) .502 (2.6) .102 (0.5) Typ .020 (2.54) Typ .100 (4.5) .177
(7.4) .292 (0.6) Dia Typ .024
(2.54) Typ .100
3
(0.4) Dia Typ .016 (2.54) .100
Terminals 1 & 3 are lamp terminals.
www.nkk.com
GB15JVC D11
Supplement
Accessories
(5.08) .200
Indicators
(2.54) .100
Touch
Tilt
(3.3) .130
(7.0) .276
Tactiles
(4.0) Dia .157
(2.54) .100
Slides
Right Angle PC
Rotaries
Keylocks
(4.0) Dia .157
(2.54) Typ .100
Programmable Illuminated PB
(4.5) .177 (2.54) Typ .100
Pushbuttons
(2.54) Typ .100 (0.4) Dia Typ .016
(2.54) Typ .100
(0.5) Typ .020 (0.4) Dia Typ .016
Rockers
H
Right Angle
Toggles
很抱歉,暂时无法提供与“GB15JVC”相匹配的价格&库存,您可以联系我们找货
免费人工找货