GW12LJVC

Series GW Toggles Ultra-Thin Fully Illuminated Paddles General Specifications B Electrical Capacity (Resistive Load) Logic Level: 0.4VA maximum @ 28V AC/DC maximum (Applicable Range 0.1mA ~ 0.1A @ 20mV ~ 28V) Note: Find additional explanation of operating range in Supplement section. Pushbuttons Rockers Programmable Illuminated PB Other Ratings Contact Resistance: Insulation Resistance: Dielectric Strength: Mechanical Life: Electrical Life: Nominal Operating Force: Angle of Throw: 80 milliohms maximum 500 megohms minimum @ 500V DC 500V AC minimum for 1 minute minimum 50,000 operations minimum 50,000 operations minimum 1.0N 28° Keylocks Materials & Finishes Actuator: Case: Sealing Ring: Base: Movable Contact: Stationary Contact: Terminals: Polycarbonate resin (UL94V-0) Glass fiber reinforced polyamide (UL94V-0) Nitrile butadiene rubber Glass fiber reinforced polyamide Phosphor bronze with gold plating Phosphor bronze with gold plating Phosphor bronze with gold plating Slides Rotaries Environmental Data Tactiles Operating Temperature Range: Humidity: Vibration: Shock: –25°C through +55°C (–13°F through +131°F) 90 ~ 95% humidity for 240 hours @ 40°C (104°F) 10 ~ 55Hz with peak-to-peak amplitude of 1.5mm traversing the frequency range & returning in 5 minutes; 3 right angled directions for 2 hours 50G (490m/s2) acceleration (tested in 3 right angled directions, with 5 shocks in each direction) Tilt PCB Processing Soldering: Cleaning: Wave Soldering recommended. See Profile A in Supplement section. Manual Soldering: See Profile A in Supplement section. These devices are not process sealed. Hand clean locally using alcohol based solution. Touch Standards & Certifications Flammability Standard: UL94V-0 actuator & case The GW Series illuminated paddles have not been tested for UL recognition or CSA certification. These switches are designed for use in a low-voltage, low-current, logic-level circuit. When used as intended in a logic-level circuit, the results do not produce hazardous energy. Supplement Accessories Indicators B36 www.nkk.com Ultra-Thin Fully Illuminated Paddles Series GW Toggles Distinctive Characteristics World’s smallest fully illuminated paddles (patent pending) for highly visible status indication; LEDs available in red, green, or amber for single color and red/green for bicolor. B Insert molded terminals prevent entry of flux and other contaminants. Award-winning STC contact mechanism with benefits unavailable in conventional mechanisms: smoother, positive detent actuation, increased contact stability, and unparalleled logic-level reliability. (Additional STC details in Terms & Acronyms; see Supplement section.) Actual Size www.nkk.com B37 Supplement Accessories Indicators Touch Tilt Tactiles .100” x .100” (2.54mm x 2.54mm) terminal spacing conforms to standard PC board grid spacing for straight and angle mounting. Slides Rotaries Keylocks Programmable Illuminated PB Specially designed switching mechanism provides crisp actuation feedback to positively indicate circuit transfer (patent pending). Pushbuttons Rockers Series GW Toggles Ultra-Thin Fully Illuminated Paddles TYPICAL SWITCH ORDERING EXAMPLE Rockers B GW Pole 1 SPDT 2 ON 1 Circuit NONE ON 2 Actuator L Paddle L J P PC Terminals P Straight Right Angle Vertical C D F CF H V D LED Colors Single Color Red Amber Green Bicolor Red/Green Pushbuttons Programmable Illuminated PB Actuator Color J Clear DESCRIPTION FOR TYPICAL PADDLE ORDERING EXAMPLE GW12LJPD Clear Paddle Amber LED SPDT ON-NONE-ON Circuit Keylocks Rotaries Straight PC Terminals P OLE & CIRCUIT Paddle Position Connected Terminals Up Center Down Throw & Schematics Note: Terminal numbers are not actually on the switch. LED circuit is isolated and requires an external power source. 2 (COM) (4) Red (5) (6) (5) (6) Green Slides Up Pole Model Center Down Tactiles SP GW12 ON NONE ON 2-3 OPEN 2-1 SPDT 3 1 Single Color Bicolor LED COLORS & SPECIFICATIONS Single Color Bicolor Tilt Touch Supplement LEDs are an integral part of the the switch and not available separately. The electrical specifications shown are determined at a basic temperature of 25°C. If the source voltage exceeds the rated voltage, a ballast resistor is required. The resistor value can be calculated by using the formula in the Supplement section. C Colors Forward Peak Current Continuous Forward Current Forward Voltage Reverse Peak Voltage I FM IF VF VRM Red 25mA 20mA 2.0V 4V D Amber 25mA 20mA 2.1V 4V F Green 25mA 20mA 2.1V 4V CF Red/Green 25mA/25mA 20mA/20mA 2.0V/2.1V 4V/4V 0.33mA/°C Accessories Indicators Current Reduction Rate Above 25°C ∆I F 0.33mA/°C 0.33mA/°C 0.33mA/°C Ambient Temperature Range www.nkk.com –25°C ~ +55°C B38 Ultra-Thin Fully Illuminated Paddles TYPICAL SWITCH DIMENSIONS Series GW Straight PC Toggles B (0.25) Typ .010 (3.0) .118 P/N This Side (0.4) Dia Typ .016 28° (2.54) Typ .100 (4.5) .177 (3.8) .150 (7.0) .276 (2.6) .102 (2.54) .100 (2.54) .100 1 2 3 4 5 6 4 5 6 1 2 3 (7.0) .276 5 & 6 are LED terminals; 4 is a support pin on single color models & an LED terminal on bicolor models. G W12LJPC Right Angle PC 28° (0.25) .010 (5.15) .203 (2.9) .114 (7.0) .276 (2.6) .102 (3.0) .118 (0.5) Typ .020 P/N This Side 3 2 1 (4.5) .177 (2.75) .108 (0.25) .010 (5.08) .200 (10.22) .402 (0.5) .020 (2.54) .100 6 5 4 1 4 2 5 (2.54) Typ .100 (2.54) 3 .100 6 (5.08) .200 (0.4) Dia Typ .016 (2.54) Typ .100 (0.6) Dia Typ .024 Vertical PC (0.25) Typ .010 (4.5) .177 P/N This Side 1 4 5 6 4 5 6 1 2 3 (7.65) .301 (4.15) .163 28° (2.75) .108 2 3 (2.54) Typ .100 (5.08) .200 (5.0) .197 (3.8) .150 (5.08) .200 (12.76) .502 (0.4) Dia .016 (2.54) .100 (0.6) Dia Typ .024 5 & 6 are LED terminals; 4 is a support pin on single color models & an LED terminal on bicolor models. GW12LJVCF www.nkk.com B39 Supplement Accessories (0.5) Typ .020 (2.54) .100 (0.25) .010 (0.5) Typ .020 (2.54) Typ .100 Indicators (2.54) .100 Touch Tilt 5 & 6 are LED terminals; 4 is a support pin on single color models & an LED terminal on bicolor models. G W12LJHD Tactiles (5.08) .200 (7.5) .295 Slides Rotaries (3.8) .150 Keylocks Programmable Illuminated PB (2.6) .102 (0.25) Typ .010 (2.54) Typ .100 (0.6) Dia Typ .024 Pushbuttons Rockers