SS22SDP2

Toggles Series SS Ultra-Miniature Slides Rockers General Specifications Electrical Capacity (Resistive Load) Programmable Illuminated PB Pushbuttons Power Level (silver): Logic Level (gold): Other Ratings Keylocks Indicators Touch Tilt Tactiles Slides Rotaries Materials & Finishes H Actuator: Upper Case: Lower Case: Movable Contactor: Interior Base: Terminals: Environmental Data Operating Temp Range: Humidity: Vibration: Shock: PCB Processing Soldering: Cleaning: 20 milliohms maximum for power level; 40 milliohms maximum for logic level 100 megohms minimum @ 500V DC 500V AC minimum 1 minute minimum 10,000 operations minimum 10,000 operations minimum SS12S & SS22S – Shorting (make-before-break) .079” (2.0mm) Polyamide Polyester for 3-On models; polyacetal for all other models Glass fiber reinforced polyester for 3-On models; glass fiber reinforced polybutylene terephthalate (thermoplastic) for other models Phosphor bronze with silver plating (code 2) or phosphor bronze with gold plating (code 4) Phenolic resin (thermoset) Brass with silver plating over copper plating or brass with gold plating –15°C through +60°C (+5°F through +140°F) 90 ~ 95% humidity for 96 hours @ 40°C (104°F) 10 ~ 55Hz with peak-to-peak amplitude of 1.5mm traversing the frequency range & returning in 1 minute; 3 right angled directions for 2 hours 50G (490m/s2) acceleration (tested in 6 right angled directions, with 5 shocks in each direction) Wave Soldering: For non-supported through-hole, see Profile B in Supplement section. For supported through-hole, 5 seconds maximum @ 250°C maximum. Manual Solder: See Profile B in Supplement section. These devices are not process sealed. Hand clean locally using alcohol based solution. Standards & Certifications The SS series devices have not been tested for UL recognition and CSA certification. These switches are designed for use in a low-voltage, low-current circuit. When used as intended in a low-voltage, low-current circuit, the results do not produce hazardous energy. Supplement Accessories Contact Resistance: Insulation Resistance: Dielectric Strength: Mechanical Life: Electrical Life: Contact Timing: Total Travel: 0.1A @ 30V DC 0.4VA maximum @ 28V AC/DC maximum (Applicable Range 0.1mA ~ 0.1A @ 20mV ~ 28V) Note: Find additional explanation of operating range in Supplement section. H44 www.nkk.com Toggles Series SS Ultra-Miniature Slides Rockers Distinctive Characteristics Pushbuttons Top or side actuation permits flexible board design. Programmable Illuminated PB Compact dimensions and low profile allow high density mounting and close stacking of PC boards. Crisp actuation positively indicates circuit status. Keylocks Double molded thermoset base and thermoplastic housing prevent loosening of terminals due to high soldering temperatures. H Insert molded terminals lock out flux, solvents, and other contaminants. Touch Tilt Tactiles Inch or metric terminal spacing for standard PC board grid (.100” x .100” or 2.0mm x 2.0mm). Slides Rotaries Award-winning STC mechanism with benefits unavailable in conventional mechanisms: smoother, positive detend actuation, increased contact stability, and unparalleled logic-level reliability. (Additional STC details in Terms and Acronyms in the Supplement section.) Supplement Accessories Indicators Actual Size www.nkk.com H45 Series SS Toggles Ultra-Miniature Slides Rockers SS Pushbuttons TYPICAL SWITCH ORDERING EXAMPLE Poles & Circuits Programmable Illuminated PB 12S SPDT ON 12S NONE D P 2 Terminal Spacing ON SS12S model has shorting contacts. * 14M SP3T ON ON ON 22S DPDT ON NONE ON B Metric 2.0mm x 2.0mm D Inch .100” x .100” Contact Material & Ratings 2 Silver Rated 0.1A @ 30V DC *4 Gold Rated 0.4VA maximum @ 28V AC/DC maximum * Gold not available with SS14M. SS22S model has shorting contacts. See Poles & Circuits chart below. Actuation Rotaries Keylocks * 14M Circuit with silver contacts only. P Top Actuated H Side Actuated DESCRIPTION FOR TYPICAL ORDERING EXAMPLE Slides SS12SDP2 H Top Actuated Tilt Tactiles Silver Contacts Rated 0.1A @ 30V DC Touch Indicators Accessories Terminals with .100” Spacing POLES & CIRCUITS Slide Position Supplement SPDT ON-NONE-ON Circuit Right Pole Model SP SS12S Center Connected Terminals Left Right Center Throw & Schematics Left Note: Terminal numbers are not actually on switch. ON NONE ON 2-1 NONE 2-3 SPDT 3 SP SS14M ON ON ON 3-4 3-2 3-1 SP3T DP SS22S ON NONE ON 2-1 5-4 NONE 2-3 5-6 DPDT 4 3 (COM) 1 H46 www.nkk.com 2 (COM) 2 2 (COM) 1 ON-OFF-ON circuit can be created by not connecting terminal 2. 1 3 4 5 (COM) 6 Series SS Toggles Ultra-Miniature Slides Metric 2.0mm x 2.0mm with Black Base (2.0) Typ .079 (0.6) Typ .024 (3.4) .134 (10.2) .402 (3.4) .134 (10.0) .394 (6.0) .236 1 2 3 (4.0) .157 (2.0) Typ .079 (0.6) Typ .024 (4.0) .157 (2.0) Typ .079 4 1 5 6 2 4 (2.0) Typ .079 (4.0) .157 3 2 1 3 (0.8) Dia Typ .031 (0.8) Dia Typ .031 (2.0) Typ .079 (0.8) Dia Typ .031 (2.0) .079 On-None-On Single Pole Models On-None-On Double Pole Models 3-On Models Inch .100” x .100” with Gray Base (0.4) Typ .016 (2.54) Typ .100 (0.6) Typ .024 (4.0) .157 (0.4) Typ .016 (2.54) Typ .100 (3.4) .134 (0.4) Typ .016 (2.54) .100 (5.08) .200 (2.54) Typ .100 (0.6) Typ .024 (4.0) .157 (3.4) .134 (0.6) Typ .024 (10.2) .402 (6.54) .257 Keylocks D (3.4) .134 Pushbuttons (2.0) Typ .079 (0.6) Typ .024 (4.0) .157 (0.4) Typ .016 (2.0) .079 Programmable Illuminated PB (0.4) Typ .016 (0.4) Typ .016 (10.2) .402 (3.4) .134 Rotaries B Rockers TERMINAL SPACING 4 2 5 2 6 3 3 (0.8) Dia Typ .031 On-None-On Single Pole Models 3 (5.08) .200 2 1 (0.8) Dia Typ .031 (2.54) Typ .100 (2.54) .100 (0.8) Dia Typ .031 On-None-On Double Pole Models 3-On Models Top Actuated (2.0) .079 (1.2) .047 (1.5) .059 H Side Actuated (2.5) .098 (1.2) .047 Touch P Tilt ACTUATION (1.5) .059 Silver over Phosphor Bronze Power Level 0.1A @ 30V DC 4 Gold over Silver/Phosphor Bronze Logic Level 0.4VA max @ 28V AC/DC max Supplement 2 Accessories Indicators CONTACT MATERIALS & RATINGS Complete explanation of operating range in Supplement section. www.nkk.com H Slides (2.54) Typ .100 1 Tactiles 1 4 (2.54) Typ .100 H47 Series SS Toggles Ultra-Miniature Slides TYPICAL SWITCH DIMENSIONS Single & Double Pole Rockers Top Actuated (3.3) .130 Pushbuttons (2.0) Travel .079 Programmable Illuminated PB (1.2) .047 (1.5) .059 (2.0) .079 (1.2) .047 (4.0) .157 (3.0) .118 (0.6) Typ .024 (2.54) Typ .100 (0.4) .016 (4.5) .177 (6.54) .257 1 3 2 5 3 6 SS12SDP2 Side Actuated Single & Double Pole Keylocks (3.3) .130 (2.0) Travel .079 (3.3) .130 (1.2) .047 (3.5) .138 (2.0) Travel .079 (0.6) Typ .024 1 2 (1.5) .059 (2.5) .098 Rotaries Slides (10.2) .402 (0.4) Typ .016 (2.54) .100 (0.4) .016 (1.5) .059 (2.5) .098 (5.0) .197 (6.54) .257 (4.0) .157 (2.54) Typ .100 (0.4) .016 (3.0) .118 3 (10.2) .402 H 3-On Circuit • Top Actuated (0.4) .016 Single Pole (0.4) .016 Tactiles (2.0) Travel Typ .079 (0.6) Typ .024 (5.08) .200 4 3 2 (1.5) .059 (2.0) .079 Tilt (1.2) .047 (4.0) .157 (4.5) .177 (2.54) Typ .100 (3.0) .118 (15.8) .622 1 (0.4) .016 SS14MDP2 3-On Circuit • Side Actuated Single Pole Indicators (3.5) .138 (0.4) .016 (0.6) Typ .024 (2.0) Travel Typ .079 Accessories (5.08) .200 4 3 2 Supplement (1.5) .059 (2.5) .098 (4.0) .157 (1.2) .047 (5.0) .197 SS14MDH2 H48 (2.54) Typ .100 (3.0) .118 www.nkk.com 1 4 2 5 3 6 (10.2) .402 (0.4) Typ .016 (2.54) .100 SS12SDH2 Touch 4 1 (10.2) .402 2 (15.8) .622 1 (0.4) .016