1607523

https://www.phoenixcontact.com/us/products/1607523 Contact insert - VC-AML 5 - 1607523 Please be informed that the data shown in this PDF Document is generated from our Online Catalog. Please find the complete data in the user's documentation. Our General Terms of Use for Downloads are valid (http://phoenixcontact.com/download) Contact insert module, for panel mounting frames, with 90° PCB connection, 4-pos. + PE, 690 V / 63 A The figure shows the product version VC-AML 5 Your advantages  Compact design  Proven COMBICON technology  Can be keyed to prevent incorrect connection  Direct PCB connection Key Commercial Data Packing unit 1 pc Minimum order quantity 5 pc GTIN GTIN 4017918969172 Weight per Piece (excluding packing) 34.770 g Custom tariff number 85366990 Country of origin Poland Technical data General Note Connectors may only be connected/disconnected when under no load. Connection technology Solder connection Connection method Solder connection Degree of pollution 3 11/03/2019   Page 1 / 8 https://www.phoenixcontact.com/us/products/1607523 Contact insert - VC-AML 5 - 1607523 Technical data General Number of positions 4+PE Insertion/withdrawal cycles ≥ 50 Size VC3 Ambient conditions Ambient temperature (operation) -40 °C ... 100 °C Material data Housing material PA Contact material CuZn Contact surface material hard-silver plated Contact carrier material PA Electrical characteristics Rated voltage (III/3) 690 V Nominal voltage UN 690 V Rated surge voltage 6 kV 6 kV Rated current 63 A 70 A Standards and Regulations Connection in acc. with standard CUL Flammability rating according to UL 94 V0 CE safety note WARNING: The connectors may not be plugged in or disconnected under load. Ignoring the warning or improper use may damage persons and/or property. • WARNING: Commission properly functioning products only. The products must be regularly inspected for damage. Decommission defective products immediately. Replace damaged products. Repairs are not possible. • WARNING: Only electrically qualified personnel may install and operate the product. They must observe the following safety notes. The qualified personnel must be familiar with the basics of electrical engineering. They must be able to recognize and prevent danger. The relevant symbol on the packaging indicates that only personnel familiar with electrical engineering are allowed to install and operate the product. • The products are suitable for applications in plant, controller, and electrical device engineering. • When operating the connectors in outdoor applications, they must be separately protected against environmental influences. • Assembled products may not be manipulated or improperly opened. • Only use mating connectors that are specified in the technical data of the standards listed (e.g. the ones listed in the product accessories online at phoenixcontact.com/products). 11/03/2019   Page 2 / 8 https://www.phoenixcontact.com/us/products/1607523 Contact insert - VC-AML 5 - 1607523 Technical data Standards and Regulations • When using the product in direct connection with third-party manufacturers, the user is responsible. • For operating voltages > 50 V AC, conductive connector housings must be grounded • Ensure that the protective or functional ground has been properly connected. • VDE 0100/1.97 § 411.1.3.2 and DIN EN 60 204/11.98 § 14.1.3 are applicable when combining several circuits in a cable and/or connector • Observe the corresponding technical data. You will find information: o On the product o On the packing label o In the supplied documentation o Online at phoenixcontact.com/products under the product • Only use tools recommended by Phoenix Contact • The installation notes/Design In documents online on the download page at phoenixcontact.com/products must be observed for this product. • Use a protective cap to protect connectors that are not in use. The suitable accessories are available online in the accessory section of the product at phoenixcontact.com/products • Operate the connector only when it is fully plugged in. • Ensure that when laying the cable, the tensile load on the connectors does not exceed the upper limit specified in the standards. • Observe the minimum bending radius of the cable. Lay the cable without twisting it. Environmental Product Compliance China RoHS Environmentally friendly use period: unlimited = EFUP-e No hazardous substances above threshold values Drawings 11/03/2019   Page 3 / 8 https://www.phoenixcontact.com/us/products/1607523 Contact insert - VC-AML 5 - 1607523 Dimensional drawing 11/03/2019   Page 4 / 8 https://www.phoenixcontact.com/us/products/1607523 Contact insert - VC-AML 5 - 1607523 Diagram 11/03/2019   Page 5 / 8 https://www.phoenixcontact.com/us/products/1607523 Contact insert - VC-AML 5 - 1607523 Dimensional drawing Classifications eCl@ss eCl@ss 4.0 27140800 eCl@ss 4.1 27140800 eCl@ss 5.0 27143400 eCl@ss 5.1 27261200 eCl@ss 6.0 27261200 eCl@ss 7.0 27440205 eCl@ss 8.0 27440205 eCl@ss 9.0 27440205 ETIM ETIM 2.0 EC000438 ETIM 3.0 EC000438 ETIM 4.0 EC000438 ETIM 5.0 EC000438 ETIM 6.0 EC000438 ETIM 7.0 EC000438 UNSPSC UNSPSC 6.01 30211923 UNSPSC 7.0901 39121522 11/03/2019   Page 6 / 8 https://www.phoenixcontact.com/us/products/1607523 Contact insert - VC-AML 5 - 1607523 Classifications UNSPSC UNSPSC 11 39121522 UNSPSC 12.01 39121522 UNSPSC 13.2 39121522 Approvals Approvals Approvals UL Recognized / cUL Recognized / EAC / cULus Recognized Ex Approvals Approval details UL Recognized    http://database.ul.com/cgi-bin/XYV/template/LISEXT/1FRAME/index.htm     Nominal voltage UN 600 V Nominal current IN 55 A cUL Recognized    http://database.ul.com/cgi-bin/XYV/template/LISEXT/1FRAME/index.htm     Nominal voltage UN 600 V Nominal current IN 45 A  FILE E 118976  FILE E 118976 EAC      B.01742 cULus Recognized       11/03/2019   Page 7 / 8 https://www.phoenixcontact.com/us/products/1607523 Contact insert - VC-AML 5 - 1607523 Accessories Accessories Coding element Coding profile - CP-HCC 4 - 1600027 Coding profile, number of positions: 1, pitch: 0 mm, color: red     Phoenix Contact 2019 © - all rights reserved http://www.phoenixcontact.com 11/03/2019   Page 8 / 8