1885486

Cable gland - VC-M-KV-PG16 1X5/1X9 1885486 https://www.phoenixcontact.com/us/products/1885486 Please be informed that the data shown in this PDF document is generated from our Online Catalog. Please find the complete data in the user documentation. Our General Terms of Use for Downloads are valid. Pg16 multiple screw connection, metal, comprising rubber seal with multiple holes (1 x 5 mm/1 x 9 mm) and a pressure screw, for VC-M-KV-PG16... cable glands Commercial Data Item number 1885486 Packing unit 1 pc Minimum order quantity 5 pc Note Made to Order (non-returnable) Sales Key A16 Product Key ABLAZA Catalog Page Page 46 (C-2-2013) GTIN 4017918176587 Weight per Piece (including packing) 17.24 g Weight per Piece (excluding packing) 17.24 g Customs tariff number 74153300 Country of origin PL Dec 9, 2022, 3:22 PM Page 1 (8) Cable gland - VC-M-KV-PG16 1X5/1X9 1885486 https://www.phoenixcontact.com/us/products/1885486 Technical Data Notes Safety note Safety note WARNING: The connectors may not be plugged in or disconnected under load. Ignoring the warning or improper use may damage persons and/or property. • WARNING: Commission properly functioning products only. The products must be regularly inspected for damage. Decommission defective products immediately. Replace damaged products. Repairs are not possible. • WARNING: Only electrically qualified personnel may install and operate the product. They must observe the following safety notes. The qualified personnel must be familiar with the basics of electrical engineering. They must be able to recognize and prevent danger. The relevant symbol on the packaging indicates that only personnel familiar with electrical engineering are allowed to install and operate the product. • The products are suitable for applications in plant, controller, and electrical device engineering. • When operating the connectors in outdoor applications, they must be separately protected against environmental influences. • Assembled products may not be manipulated or improperly opened. • Only use mating connectors that are specified in the technical data of the standards listed (e.g. the ones listed in the product accessories online at phoenixcontact.com/products). • When using the product in direct connection with third-party manufacturers, the user is responsible. • For operating voltages > 50 V AC, conductive connector housings must be grounded • Ensure that the protective or functional ground has been properly connected. • VDE 0100/1.97 § 411.1.3.2 and DIN EN 60 204/11.98 § 14.1.3 are applicable when combining several circuits in a cable and/or connector • Observe the corresponding technical data. You will find information: o On the product o On the packing label o In the supplied documentation o Online at phoenixcontact.com/products under the product • Only use tools recommended by Phoenix Contact • The installation notes/Design In documents online on the download page at phoenixcontact.com/products must be observed for this product. • Use a protective cap to protect connectors that are not in use. The suitable accessories are available online in the accessory section of the product at phoenixcontact.com/products • Operate the connector only when it is fully plugged in. • Ensure that when laying the cable, the tensile load on the connectors does not exceed the upper limit specified in the Dec 9, 2022, 3:22 PM Page 2 (8) Cable gland - VC-M-KV-PG16 1X5/1X9 1885486 https://www.phoenixcontact.com/us/products/1885486 standards. • Observe the minimum bending radius of the cable. Lay the cable without twisting it. • The connector warms up in normal operation. Depending on the ambient conditions, the surface of the connector can continue to warm up. In this case, the user is responsible for posting warnings (e.g. DIN EN ISO 13732-1:2008-12). Product properties Product type Multiple screw connection No. of conductors 2 Shielded no Dimensions Dimensional drawing Width 26.7 mm Height 26.7 mm Length 23.1 mm Wrench size, union nut 24 mm Thread type on seal side Pg16 Material specifications Material PVC (Seal) Brass (Screw connection) Sealing material TPE Cable seal material PVC Cable / line External cable diameter 4.5 mm ... 5 mm (Cable 1) Tightening torque, union nut 7.50 Nm Environmental and real-life conditions Ambient conditions Degree of protection IP65 Degree of protection IP65 Ambient temperature (operation) -40 °C ... 125 °C Dec 9, 2022, 3:22 PM Page 3 (8) Cable gland - VC-M-KV-PG16 1X5/1X9 1885486 https://www.phoenixcontact.com/us/products/1885486 Drawings Dimensional drawing M25x1,5 PG16 28 24 Dec 9, 2022, 3:22 PM Page 4 (8) Cable gland - VC-M-KV-PG16 1X5/1X9 1885486 https://www.phoenixcontact.com/us/products/1885486 Approvals  EAC Approval ID: B.01687 Dec 9, 2022, 3:22 PM Page 5 (8) Cable gland - VC-M-KV-PG16 1X5/1X9 1885486 https://www.phoenixcontact.com/us/products/1885486 Classifications ECLASS ECLASS-9.0 27144432 ECLASS-10.0.1 27144432 ECLASS-11.0 27144432 ETIM ETIM 8.0 EC000441 UNSPSC UNSPSC 21.0 39121300 Dec 9, 2022, 3:22 PM Page 6 (8) Cable gland - VC-M-KV-PG16 1X5/1X9 1885486 https://www.phoenixcontact.com/us/products/1885486 Environmental Product Compliance China RoHS Environmentally Friendly Use Period = 50 years For information on hazardous substances, refer to the manufacturer’s declaration available under “Downloads” Dec 9, 2022, 3:22 PM Page 7 (8) Cable gland - VC-M-KV-PG16 1X5/1X9 1885486 https://www.phoenixcontact.com/us/products/1885486 Accessories Half screw connection Half screw connection - VC-M-KV-PG21- 0 - 1854983 https://www.phoenixcontact.com/us/products/1854983 Half screw connection made of metal with rubber seal without hole for sealing or for individual holes Phoenix Contact 2022 © - all rights reserved https://www.phoenixcontact.com Phoenix Contact USA 586 Fulling Mill Road Middletown, PA 17057, United States (+717) 944-1300 info@phoenixcon.com Dec 9, 2022, 3:22 PM Page 8 (8)