2952198

EMG ...-DIO ... Diode modules Data sheet 101170_en_02 co © PHOENIX CONTACT - 09/2009 po ne Diode circuits perform various tasks in electrical, but especially electronic control systems, such as: – Electrical decoupling of messages in fault signaling systems or – As spark-suppression diodes for limiting surge voltages of inductive loads, such as solenoid valves, DC relays or similar s. Description nt 1 m INTERFACE on lin e co m In order to meet these requirements, diode modules are available as "diode gates" with common negative and positive polarity or as individual diodes. NOTE: Please note that there is no isolation between the individual diode paths within a module. Make sure you always use the latest documentation. It can be downloaded at www.phoenixcontact.net/download. This data sheet is valid for all products listed on the following page: EMG ...-DIO ... 2 Ordering data Diode module, can be individually wired Description Housing width Type Order No. Pcs./Pkt. 4 diodes, type 1 N 4007 22.5 mm EMG 22-DIO 4E 2950048 10 4 diodes, type 1 N 5408 22.5 mm EMG 22-DIO 4E-1N5408 2952790 10 45 mm EMG 45-DIO 8E 2950103 5 45 mm EMG 45-DIO 8E-1N5408 2949389 5 17 diodes, type 1 N 4007 90 mm EMG 90-DIO 17E 2954895 5 Diode module, positive polarity (common cathode) Description Housing width Type Order No. Pcs./Pkt. 4 diodes, type 1 N 5408 22.5 mm EMG 22-DIO 4P-1N5408 7 diodes, type 1 N 4007 22.5 mm EMG 22-DIO 7P m 8 diodes, type 1 N 4007 8 diodes, type 1 N 5408 10 10 co 2952198 2950064 45 mm EMG 45-DIO 8P-1N5408 2954879 5 45 mm EMG 45-DIO14P 2950116 5 32 diodes, type 1 N 4007 90 mm EMG 90-DIO 32P 2954918 5 Order No. Pcs./Pkt. nt s. 8 diodes, type 1 N 5408 14 diodes, type 1 N 4007 Type 4 diodes, type 1 N 5408 22.5 mm EMG 22-DIO 4M-1N5408 2952211 10 7 diodes, type 1 N 4007 22.5 mm EMG 22-DIO 7M 2950077 10 po 8 diodes, type 1 N 5408 14 diodes, type 1 N 4007 45 mm EMG 45-DIO 8M-1N5408 2954882 5 45 mm EMG 45-DIO14M 2950129 5 90 mm EMG 90-DIO 32M 2954934 5 Type Order No. Pcs./Pkt. EMG-GKS 12 2947035 50 m 32 diodes, type 1 N 4007 co Accessories Description lin e Device marking label 3 ne Diode module, negative polarity (common anode) Description Housing width Technical data General data on Ambient temperature range Rated insulation voltage according to EN 50178 -20°C … +50°C 300 V Pollution degree according to EN 50178 2 Surge voltage category according to EN 50178 3, basic insulation Mounting position Any Installation Can be aligned without spacing Height 55 mm Length 75 mm Connection data Conductor cross-section, solid 0.2 mm² … 4 mm² Conductor cross-section, stranded 0.2 mm² … 2.5 mm² Conductor cross-section, AWG 24 - 12 Stripping length 8 mm Connection method Screw connection 101170_en_02 PHOENIX CONTACT 2 EMG ...-DIO ... Diode data for diode type 1 N 4007 EMG 22-DIO 4E, EMG 45-DIO 8E, EMG 90-DIO 17E, EMG 22-DIO 7P, EMG 22-DIO 7M EMG 45-DIO14P, EMG 45-DIO14M, EMG 90-DIO 32P, EMG 90-DIO 32M 250 V AC 250 V AC 1300 V 1300 V Maximum operating voltage Umax Peak reverse voltage per diode Reverse current per diode Conducting-state voltage per diode 5 µA 5 µA 0.8 V, approximately 0.8 V, approximately 0.7 A 0.5 A 0.7 A 0.2 A Conducting-state current per diode With single load With simultaneous load EMG 45-DIO 8E-1N5408, EMG 45-DIO 8P-1N5408, EMG 45-DIO 8M-1N5408 m EMG 22-DIO 4E-1N5408, EMG 22-DIO 4P-1N5408, EMG 22-DIO 4M-1N5408 Diode data for diode type 1 N 5408 1000 V Reverse current per diode 10 µA Conducting-state voltage per diode co 250 V AC Maximum operating voltage Umax Peak reverse voltage per diode 0.8 V, approximately 1000 V 10 µA 0.8 V, approximately s. Conducting-state current per diode 250 V AC 1.5 A 1A 1.5 A 0.3 A nt With single load With simultaneous load Conformance/approvals CE-compliant ne Conformance Conformance with Low Voltage Directive (LVD) 2006/95/EC EN 50178 po Electronic equipment according to Circuit diagram 4.1 Diode module, can be individually wired 3 5 7 Diode module, negative polarity 1 2 3 4 6 7 M 2 Figure 1 4.2 on lin e 1 4.3 co m 4 4 6 5 8 E.g., EMG 22-DIO 4E Figure 3 E.g., EMG 22-DIO 7M Diode module, positive polarity 1 2 3 4 5 6 7 P Figure 2 101170_en_02 E.g., EMG 22-DIO 7P PHOENIX CONTACT GmbH & Co. KG • 32823 Blomberg • Germany • Phone: +49 - 52 35 - 30 0 PHOENIX CONTACT • P.O.Box 4100 • Harrisburg • PA 17111-0100 • USA • Phone: +717-944-1300 www.phoenixcontact.com 3