PV-C1M-C-HSG

https://www.phoenixcontact.com/ie/products/1050770 Photovoltaic connector - PV-C1M-C-HSG - 1050770 Please be informed that the data shown in this PDF Document is generated from our Online Catalog. Please find the complete data in the user's documentation. Our General Terms of Use for Downloads are valid (http://phoenixcontact.com/download) Photovoltaic connector, Range of articles: PV-CF-C, Photovoltaic connector, housing material: PPE, color: black, number of positions: 1, min. conductor cross section: 2.5 mm², max. conductor cross section: 6 mm², nom. voltage: 1500 V, rated current: 27 A, Connection method: Crimp, Type of contact: Pin, min. cable diameter: 5.00 mm, max. cable diameter: 8.00 mm Key Commercial Data Packing unit 50 pc Minimum order quantity 50 pc GTIN GTIN 4055626670218 Weight per Piece (excluding packing) 13.270 g Technical data Dimensions External cable diameter 5 mm ... 8 mm Ambient conditions Ambient temperature (operation) -40 °C ... 85 °C Ambient temperature (assembly) -25 °C ... 50 °C General Design Pin Insertion force 45 N ±10 N Disconnect force 250 N ±50 N (when locked) Pull-out force of cable >= disconnect force > 80 N (IEC 62852:2014) Insertion/withdrawal cycles 100 Degree of pollution 2 Number of positions 1 Current 40 A Rated surge voltage (III/3) 16 kV 03/05/2021   Page 1 / 4 https://www.phoenixcontact.com/ie/products/1050770 Photovoltaic connector - PV-C1M-C-HSG - 1050770 Technical data General pluggable Yes Degree of protection IP66 / IP68 (2 m / 24 h) Connection cross-section AWG (min.) 14 Connection cross-section AWG (max.) 10 Rated current (2.5 mm²) 27 A Rated current (4.0 mm²) 34 A Rated current (6.0 mm²) 40 A Protection class II Material Color black Insulating material mPPE Contact material Cu Contact surface material Ag Connection data Connection method Crimp Connection capacity 2.5 mm² ... 6 mm² Contact resistance with connected conductor ≤ 0.45 mΩ Stripping length 8 mm Cable type H1Z2Z2-K lines Type of contact Pin Standards and Regulations Flammability rating according to UL 94 V0 Safety note • WARNING: Commission properly functioning products only. The products must be regularly inspected for damage. Decommission defective products immediately. Replace damaged products. Repairs are not possible. • WARNING: Only electrically qualified personnel may install and operate the product. They must observe the following safety notes. The qualified personnel must be familiar with the basics of electrical engineering. They must be able to recognize and prevent danger. The relevant symbol on the packaging indicates that only personnel familiar with electrical engineering are allowed to install and operate the product. WARNING: The connectors may not be plugged in or disconnected under load. Ignoring the warning or improper use may damage persons and/or property. • The products are suitable for applications in plant, controller, and electrical device engineering. • Assembled products may not be manipulated or improperly opened. • Only use mating connectors that are specified in the technical data of the standards listed (e.g. the ones listed in the product accessories online at phoenixcontact.com/products). • When using the product in direct connection with third-party manufacturers, the user is responsible. 03/05/2021   Page 2 / 4 https://www.phoenixcontact.com/ie/products/1050770 Photovoltaic connector - PV-C1M-C-HSG - 1050770 Technical data Standards and Regulations • For operating voltages > 50 V AC, conductive connector housings must be grounded • Ensure that the protective or functional ground has been properly connected. • Observe the corresponding technical data. You will find information: o On the product o On the packing label o In the supplied documentation o Online at phoenixcontact.com/products under the product • The installation notes/Design In documents online on the download page at phoenixcontact.com/products must be observed for this product. • Use a protective cap to protect connectors that are not in use. The suitable accessories are available online in the accessory section of the product at phoenixcontact.com/products • The connector warms up in normal operation. Depending on the ambient conditions, the surface of the connector can continue to warm up. In this case, the user is responsible for posting warnings (e.g. DIN EN ISO 13732-1:2008-12). • Operate the connector only when it is fully plugged in and interlocked. • Ensure that when laying the cable, the tensile load on the connectors does not exceed the upper limit specified in the standards. • Observe the minimum bending radius of the cable. Lay the cable without twisting it. Classifications eCl@ss eCl@ss 10.0.1 27440107 eCl@ss 11.0 27440107 eCl@ss 9.0 27440107 Accessories Accessories Crimping tool Crimping pliers - CRIMPFOX-P SR 6 - 1212755 Crimping pliers, for SUNCLIX solar crimp connectors 2.5 ... 6 mm², unlockable pressure lock, precise parallel crimping, lateral entry, B crimp, incl. positioning tool     Photovoltaic connector 03/05/2021   Page 3 / 4 https://www.phoenixcontact.com/ie/products/1050770 Photovoltaic connector - PV-C1M-C-HSG - 1050770 Accessories Protective cap - PV-C PROTECTION CAP - 1785430 Photovoltaic connector, Range of articles: SUNCLIX, Protective cap, color: black. self-sealing, without interlock, set consisting of: 1 protective cap for connector side and 1 protective cap for coupling side     Crimp contact - PV-C3M-C-6-R3000 - 1050766 Photovoltaic connector, Range of articles: PV-CF-C, Crimp contact, color: black, number of positions: 1, min. conductor cross section: 6 mm², max. conductor cross section: 6 mm², Connection method: Crimp, Type of contact: Pin     Crimp contact - PV-C3M-C-2,5-4-R3000 - 1050768 Photovoltaic connector, Range of articles: PV-CF-C, Crimp contact, color: black, number of positions: 1, min. conductor cross section: 2.5 mm², max. conductor cross section: 4 mm², rated current: 27 A, Connection method: Crimp, Type of contact: Pin     Contact removal tool - PV-A-C-DC-TOOL - 1069522 Photovoltaic connector, Contact removal tool     Phoenix Contact 2021 © - all rights reserved http://www.phoenixcontact.com 03/05/2021   Page 4 / 4