MUS-1212

DC-DC Converter UNIT MU Series ( 1 W UNREGULATED DC-DC CONVERTER ) FEATURES 1000VDC ISOLATION EFFICIENCY UP TO 82% INTERNAL SMD TECHNOLOGY LOW COST NO HEATSINK REQUIRED UP TO 1W UNREGULATED OUTPUT POWER SINGLE IN LINE PACKAGE 100% BURNED IN MTBF > 2,000,000 HOURS OUTPUT SPECIFICATIONS Voltage Setpoint Accuracy Temperature Coefficient Ripple & Noise (20MHz BW) Line Regulation1 Load Regulation 2 INPUT SPECIFICATIONS +/-2% max +/-0.03%/ OC Input Voltage Range Input Filter +/-10% max Capacitor Type 100mVp-p max +/-1.2% max +/-8% max Momentary GENERAL SPECIFICATIONS Efficiency Isolation Voltage3 70%-82% 1000 VDC min 9 10 ohms min 100 KHz min 80pF max 2,000,000 Hours 1.3g Typ Non-Conductive Plastic 11.6mm*6.1mm*10.2mm 11.6mm*7.6mm*10.2mm Short Circuit Protection ENVIRONMENTAL SPECIFICATIONS Operating Temperature Storage Temperature Cooling -25 OC to +71 OC -55 OC to +125 OC Free-Air Convection Isolation Resistance Switching Frequency Isolation Capacitance MTBF Weight ALL SPECIFICATIONS TYPICAL AT NOMINAL LINE, FULL LOAD , AND 25 O Case Material Case Size C UNLESS OTHERWISE NOTED. 1 2 3 Line Regulation is for a 1.0% change in input Voltage. Load Regulation is for output load current change from 20% to 100%. For 60 seconds www.Power-Systems.de Page: 1 / 5 Version: 4-Oct-02 DC-DC Converter UNIT MU Series ( 1 W UNREGULATED DC-DC CONVERTER ) SELECTION GUIDE 1W OUTPUT MODEL NUMBER INPUT (VDC) 5 5 5 5 12 12 12 12 12 24 24 24 24 24 OUTPUT (VDC) 5 9 12 15 3.3 5 9 12 15 3.3 5 9 12 15 OUTPUT (mA) 200 110 84 67 300 200 110 84 67 300 200 110 84 67 INPUT CURRENT(mA) EFF FULL LOAD NO LOAD 26 27 26 28 11 11 11 11 12 8 8 8 8 7 73 77 79 79 74 74 79 82 82 73 73 77 77 80 1000 1000 1000 1000 1000 1000 1000 1000 1000 1000 1000 1000 1000 1000 A A A A B A A A A B B B B B VOLTAGE VOLTAGE CURRENT ISOLATION (VDC) (%) PACKAGE MUS-0505 MUS-0509 MUS-0512 MUS-0515 MUS-1203.3 MUS-1205 MUS-1209 MUS-1212 MUS-1215 MUS-2403.3 MUS-2405 MUS-2409 MUS-2412 MUS-2415 274 260 253 253 112 112 105 102 102 57 57 54 54 52 Note: Other input to output voltages may be available. Please contact factory. www.Power-Systems.de Page: 2 / 5 Version: 4-Oct-02 DC-DC Converter UNIT MU Series ( 1 W UNREGULATED DC-DC CONVERTER ) MECHANICAL DIMENSIONS PACKAGE ”A” PIN 1 2 3 4 SINGLE -Vin +Vin -Vout +Vout PACKAGE ”B” PIN 1 2 3 4 SINGLE -Vin +Vin -Vout +Vout www.Power-Systems.de Page: 3 / 5 Version: 4-Oct-02 DC-DC Converter UNIT MU Series ( 1 W UNREGULATED DC-DC CONVERTER ) RECOMMENDED FOOTPRINT DETAILS PACKAGE "A" PACKAGE "B" SIMPLIFIED SCHEMATIC +Vin OSCILLATOR DRIVER TYPICAL APPLICATIONS INPUT OUTPUT +Vin +Vout +Vout -Vin -Vout DC-DC CONVERTER -Vin -Vout LOAD TYPICAL PERFORMANCE CUREVES Specifications typical at ta=25 OC , nominal input voltage , rated output current unless otherwise specified. EFFICIENCY VS LOAD OUTPUT POWER(W) EFFICIENCY(%) 80.0 60.0 40.0 20.0 0.0 0 20 40 60 80 100 1.2 0.9 0.6 0.3 0.0 DERATING CURVE SAFE OPERATING AREA -25 0 25 50 70 100 % OF RATED LOAD(%) TA(degree C) www.Power-Systems.de Page: 4 / 5 Version: 4-Oct-02 DC-DC Converter UNIT MU Series ( 1 W UNREGULATED DC-DC CONVERTER ) MU SERIES APPLICATION NOTES: EXTERNAL CAPACITANCE REQUIREMENTS: Output filtering is required for operation. A minimum of 10uF is needed. Output capacitance may be increased for additional filtering, not to exceed 220uF. To meet the reflected ripple requirements of the converter, an input impedance of less than 0.5 ohm from DC to 250KHz is required. Negative Outputs: A negative output voltage may be obtained by connecting the +OUT to circuit ground and connecting –OUT as the negative output. FOR MORE INFORMATION CALL: Power Systems – The Power Solution Ilsfeld-Auenstein ( Germany ) Dörnet 8 E-mail: Info@Power-Systems.de Tel: + 49 / 70 62 / 67 59 – 6 Fax: + 49 / 70 62 / 67 59 -80 Home Page: www.Power-Systems.de www.Power-Systems.de Page: 5 / 5 Version: 4-Oct-02