1N5358B

1N5333B THRU 1N5388B 5 W SILICON ZENER DIODES FEATURES * * * * Low cost Low leakage Low forward voltage drop High current capability DO-15 MECHANICAL DATA * * * * Case: Molded plastic Epoxy: Device has UL flammability classification 94V-O Lead: MIL-STD-202E method 208C guaranteed Mounting position: Any .035 (0.88) .027 (0.68) 1.0 (25.4) DIA. MIN. .300 (7.6) .230 (5.8) .140 (3.6) .104 (2.6) DIA. 1.0 (25.4) MAXIMUM RATINGS AND ELECTRICAL CHARACTERISTICS MIN. o Ratings at 25 C ambient temperature unless otherwise specified. Single phase, half wave, 60 Hz, resistive or inductive load. For capacitive load, derate current by 20%. Dimensions in inches and (millimeters) Absolute Maximum Ratings (Rating at 25OC ambient temperature unless otherwise specified) Parameter DC Power Dissipation @ TL = 75 OC Symbol 1) Junction and Storage Temperature Range 1) Value PD 5 Tj, Tstg - 65 to + 200 Unit W C O TL = Lead temperature at 3/8" (9.5 mm) from body Characteristics at Ta = 25 OC Parameter Forward Voltage at IF = 1 A Symbol VF Max. Unit 1.2 V 2021-06/25 REV:B Electrical Characteristics (Rating at 25 OC ambient temperature unless otherwise specified) Zener Voltage 1) Type 1N5333B 1N5334B 1N5335B 1N5336B 1N5337B 1N5338B 1N5339B 1N5340B 1N5341B 1N5342B 1N5343B 1N5344B 1N5345B 1N5346B 1N5347B 1N5348B 1N5349B 1N5350B 1N5351B 1N5352B 1N5353B 1N5354B 1N5355B 1N5356B 1N5357B 1N5358B 1N5359B 1N5360B 1N5361B 1N5362B 1N5363B 1N5364B 1N5365B 1N5366B 1N5367B 1N5368B 1N5369B 1N5370B 1N5371B 1N5372B 1N5373B 1N5374B 1N5375B 1N5376B 1N5377B 1N5378B 1N5379B 1N5380B 1N5381B 1N5382B 1N5383B 1N5384B 1N5385B 1N5386B 1N5387B 1N5388B 1) VZnom (V) VZT Min.(V) Max.(V) Zener Impedance at IZT (mA) Leakage Current ZZT Max.(Ω) at IZT (mA) ZZK Max.(Ω) at IZK (mA) 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 3.3 3.14 3.47 380 3.0 380 400 3.6 3.9 4.3 4.7 5.1 5.6 6 6.2 6.8 7.5 8.2 8.7 9.1 10 11 12 13 14 15 16 17 18 19 20 22 24 25 27 28 30 33 36 39 43 47 51 56 60 62 68 75 82 87 91 100 110 120 130 140 150 160 170 180 190 200 3.42 3.71 4.09 4.47 4.85 5.32 5.7 5.89 6.46 7.13 7.79 8.27 8.65 9.5 10.45 11.4 12.35 13.3 14.25 15.2 16.15 17.1 18.05 19 20.9 22.8 23.75 25.65 26.6 28.5 31.35 34.2 37.05 40.85 44.65 48.45 53.2 57 58.9 64.6 71.25 77.9 82.65 86.45 95 104.5 114 123.5 133 142.5 152 161.5 171 180.5 190 3.78 4.10 4.52 4.94 5.35 5.88 6.3 6.51 7.14 7.87 8.61 9.13 9.55 10.5 11.55 12.6 13.65 14.7 15.75 16.8 17.85 18.9 19.95 21 23.1 25.2 26.25 28.35 29.4 31.5 34.65 37.8 40.95 45.15 49.35 53.55 58.8 63 65.1 71.4 78.75 86.1 91.35 95.55 105 115.5 126 136.5 147 157.5 168 178.5 189 199.5 210 350 320 290 260 240 220 200 200 175 175 150 150 150 125 125 100 100 100 75 75 70 65 65 65 50 50 50 50 50 40 40 30 30 30 25 25 20 20 20 20 20 15 15 15 12 12 10 10 8 8 8 8 5 5 5 2.5 2.0 2.0 2.0 1.5 1 1 1 1 1.5 1.5 2 2 2 2.5 2.5 2.5 2.5 2.5 2.5 2.5 2.5 3 3 3.5 3.5 4 5 6 8 10 11 14 20 25 27 35 40 42 44 45 65 75 75 90 125 170 190 230 330 350 380 430 450 480 350 320 290 260 240 220 200 200 175 175 150 150 150 125 125 100 100 100 75 75 70 65 65 65 50 50 50 50 50 40 40 30 30 30 25 25 20 20 20 20 20 15 15 15 12 12 10 10 8 8 8 8 5 5 5 500 500 500 450 400 400 300 200 200 200 200 200 150 125 125 125 100 75 75 75 75 75 75 75 75 100 110 120 130 140 150 160 170 190 210 230 280 350 400 500 620 720 760 760 800 1000 1150 1250 1500 1500 1650 1750 1750 1850 1850 IR Max.(μA) 300 150 50 10 5.0 1 1 1 1 10 10 10 10 7.5 5 5 2 1 1 1 1 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 at VR (V) Maximum DC Zener Current IZM (mA) 1.0 1440 1.0 1.0 1.0 1.0 1 2 3 3 5.2 5.7 6.2 6.6 6.9 7.6 8.4 9.1 9.9 10.6 11.5 12.2 12.9 13.7 14.4 15.2 16.7 18.2 19 20.6 21.2 22.8 25.1 27.4 29.7 32.7 35.8 38.8 42.6 45.5 47.1 51.7 56 62.2 66 69.2 76 83.6 91.2 98.8 106 114 122 129 137 144 152 1320 1220 1100 1010 930 856 790 765 700 630 580 545 520 475 430 395 365 340 315 295 280 265 250 237 216 198 190 176 170 158 144 132 122 110 100 93 86 79 76 70 63 58 54.5 52.5 47.5 43 39.5 36.6 34 31.6 29.4 28 26.4 25 23.6 Suffix "A" indicates ± 10% tolerance, Suffix "B" indicates ± 5% tolerance " " " "" " " 40 40 I r , PEAK SURGE CURRENT (AMPS) θ JL, JUNCTION-TO-LEAD THERMAL RESISTANCE (°C/W) RATING AND CHARACTERISTICS CURVES (1N5333B THRU 1N5388B) 30 20 L 10 0 L PRIMARY PATH OF CONDUCTION IS THROUGH THE CATHODE LEAD 0 0.2 0.4 0.6 0.8 L, LEAD LENGTH TO HEATSINK (INCH) 20 PW=8.3ms* 4 2 1 0.4 *SQUARE WAVE PW=1000ms* 3 4 6 8 10 20 30 40 60 80 100 200 NOMINAL VZ (V) Figure 2.Maximum Non-Repetitive Surge Current versus Nominal Zener Voltage Figure 1. Typical Thermal Resistance 300 200 10 θVZ , TEMPERATURE COEFFICIENT (mV/°C) @ I ZT θVZ , TEMPERATURE COEFFICIENT (mV/°C) @ I ZT PW=100ms* 0.2 0.1 1 PW=1ms* 10 8 100 6 4 2 RANGE 0 −2 3 4 7 5 6 8 VZ, ZENER VOLTAGE @ IZT (VOLTS) 9 RANGE 50 30 20 10 5 10 0 20 θ JL (t, D), TRANSIENT THERMAL RESISTANCE JUNCTION-TO-LEAD ( °C/W) Figure 3. Temperature Coefficient-Range for Units 3 to 10 Volts 40 60 80 100 120 140 160 180 VZ, ZENER VOLTAGE @ IZT (VOLTS) 200 220 Figure 4. Temperature Coefficient-Range for Units 10 to 220 Volts 20 10 D = 0.5 5 D = 0.2 2 1 0.5 PPK t1 D = 0.1 t2 D = 0.05 D = 0.01 D=0 0.2 0.00 1 DUTY CYCLE, D = t1/t2 SINGLE PULSE D TJL = qJL(t)PPK REPETITIVE PULSES D TJL = qJL(t, D)PPK NOTE: BELOW 0.1 SECOND, THERMAL NOTE: RESPONSE CURVE IS APPLICABLE NOTE: TO ANY LEAD LENGTH (L). 0.00 5 0.01 0.05 0.1 0.5 1 5 10 20 t, TIME (SECONDS) Figure 5. Typical Thermal Response L, Lead Length = 3/8 Inch " " " "" " " 50 100 RATING AND CHARACTERISTICS CURVES (1N5333B THRU 1N5388B) 20 I r , PEAK SURGE CURRENT (AMPS) I r , PEAK SURGE CURRENT (AMPS) 40 PW=1ms* 10 PW=8.3ms* 4 2 1 0.4 *SQUARE WAVE PW=100ms* 0.2 0.1 PW=1000ms* 3 4 6 8 10 20 30 40 60 80 100 30 20 10 5 2 1 0.5 VZ=200V PLOTTED FROM INFORMATION GIVEN IN FIGURE 5 0.2 0.1 200 VZ=3.3V 1 10 NOMINAL VZ (V) Figure 6. Maximum Non-Repetitive Surge Current versus Nominal Zener Voltage 100 PW, PULSE WIDTH (ms) 1000 Figure 7. Peak Surge Current versus Pulse Width 1000 T=25°C T=25°C TC=25°C I Z , ZENER CURRENT (mA) I Z , ZENER CURRENT (mA) 1000 100 10 1 1 2 3 4 5 6 7 8 VZ, ZENER VOLTAGE (VOLTS) 9 10 1 0.1 10 Figure 8. Zener Voltage versus Zener Current VZ = 3.3 thru 10 Volts I Z , ZENER CURRENT (mA) 0.1 100 10 20 30 40 50 60 VZ, ZENER VOLTAGE (VOLTS) Figure 9. Zener Voltage versus Zener Current VZ = 11 thru 75 Volts 100 10 1 0.1 80 100 120 70 140 160 180 VZ, ZENER VOLTAGE (VOLTS) 200 220 Figure10. Zener Voltage versus Zener Current VZ = 82 thru 200 Volts " " " "" " " 80 RECTRON Attachment information about 1N53XXB 1. Internal Circuit Anode Cathode 2. Marking on the body Plant - code Rectron Logo Part No. V X X 1 N 5 3XXB Cathode Band Year - code (Y: Last digit of year & A:2010, B:2011…..) Month - code (M: 0~9, O, N, D) Voltage-code 33B----3.3V : : 88B----200V PACKAGING OF DIODE AND BRIDGE RECTIFIERS BULK PACK PACKAGE PACKING CODE DO-15 -B EA PER BOX INNER BOX SIZE (mm) 500 194*84*21 CARTON SIZE EA PER CARTON (mm) 415*220*255 GROSS WEIGHT(Kg) 12.74 25,000 REEL PACK PACKAGE DO-15 PACKING EA PER EA PER COMPONENT TAPE SPACE REEL DIA CARTON SIZE EA PER GROSS SPACE INNER REEL CARTON WEIGHT(Kg) CODE (mm) (mm) (mm) (mm) BOX -T 4,000 4,000 5.0 52 330 355*350*335 16,000 10.05 AMMO PACK PACKAGE PACKING CODE REEL ( EA ) DO-15 -F 1,500 COMPONENT TAPE SPACE SPACE(mm) (mm) 5.0 52 BOX SIZE (mm) CARTON SIZE(mm) 255*73*100 400*268*225 CARTON ( EA ) 15,000 GROSS WEIGHT (Kg) 8.8 DISCLAIMER NOTICE Rectron Inc reserves the right to make changes without notice to any product specification herein, to make corrections, modifications, enhancements or other changes. Rectron Inc or anyone on its behalf assumes no responsibility or liability for any errors or inaccuracies. Data sheet specifications and its information contained are intended to provide a product description only. "Typical" parameters which may be included on RECTRON data sheets and/ or specifications can and do vary in different applications and actual performance may vary over time. Rectron Inc does not assume any liability arising out of the application or use of any product or circuit. Rectron products are not designed, intended or authorized for use in medical, life-saving implant or other applications intended for life-sustaining or other related applications where a failure or malfunction of component or circuitry may directly or indirectly cause injury or threaten a life without expressed written approval of Rectron Inc. Customers using or selling Rectron components for use in such applications do so at their own risk and shall agree to fully indemnify Rectron Inc and its subsidiaries harmless against all claims, damages and expenditures.