112LU10D-PCB

110L...-PCB / 430L...-PCB Series Signal conditioned precision pressure transducers FEATURES · 1 to 50 mbar, 1 to 30 "H2O gage or differential pressure (custom calibrations available) · 1...6 V or 4...20 mA output · Internal supply regulation · Precision temperature compensated and calibrated · Special calibrations for small volumes on request SERVICE Non-corrosive, non-ionic working fluids such as dry air and dry gases. Scale: 1 cm 1 inch SPECIFICATIONS Maximum ratings ELECTRICAL CONNECTION 1...6 V output version Supply voltage 110L...-PCB 430L...-PCB1 Maximum load current (110L...-PCB only) source sink Temperature limits Storage Operating Compensated Lead temperature(4 sec soldering) Humidity limits (pressure inlets only) 12...24 V 12...36 V 20 mA 10 mA -25 to 85°C -10 to 70°C 0 to 50°C 300°C 0 - 80 %RH 430L...-PCB +Vs 12 to 24 V Vout V -Vs 110L...-PCB 4...20 mA output version +Vs 12 to 36 V -Vs V RL GND January 2007 / 006 1/6 www.sensortechnics.com 110L...-PCB / 430L...-PCB Series Signal conditioned precision pressure transducers PERFORMANCE CHARACTERISTICS 1...6 V output version (unless otherwise noted VS = 15 V, RL > 100 kΩ, tamb = 25°C) Characteristics Operating pressure3 differential devices 112LP02D-PCB 112LP05D-PCB 112LP10D-PCB 112LP25D-PCB 112LP50D-PCB 113LP01D-PCB 113LP02D-PCB 113LP05D-PCB 113LP10D-PCB 113LP25D-PCB 113LP50D-PCB 112LU01D-PCB 112LU02D-PCB 112LU05D-PCB 112LU10D-PCB 112LU20D-PCB 112LU30D-PCB 113LU01D-PCB 113LU02D-PCB 113LU05D-PCB 113LU10D-PCB 113LU20D-PCB 113LU30D-PCB 112L...-PCB 113L...-PCB 112L...-PCB 113L...-PCB Min. 0 0 0 0 0 -1 -2 -5 -10 -25 -50 0 0 0 0 0 -1 -2 -5 -10 -20 -30 0.95 3.4 4.9 2.4 Typ. Max. 2 5 10 25 50 1 2 5 10 25 50 1 2 5 10 20 30 1 2 5 10 20 30 1.05 3.6 5.1 2.6 Proof Common mode pressure2 pressure 200 200 200 300 300 200 200 200 200 300 300 80 120 120 240 240 240 80 120 120 240 240 240 300 300 300 600 600 300 300 300 300 600 600 160 240 240 360 360 360 160 240 240 360 360 360 Unit pressure/ vacuum devices3 mbar differential devices pressure/ vacuum devices3 "H2O Zero pressure offset4 Full scale span5 Full scale output Output at lowest specified pressure 113L...-PCB Thermal effects Offset 113LP01D-PCB (0 to 50°C)6 11...LP02D-PCB 11...LU01D-PCB all other devices Span 113LP01D-PCB 11...LP02D-PCB 11...LU01D-PCB all other devices Non-linearity and hysteresis (BSL)7 Long term stability8 Response time (10 to 90 %) Position sensitivity all 1 and 2 mbar devices all other devices Current consumption Power supply Offset rejection Span 1.0 3.5 5.0 2.5 6.0 1.0 ±0.08 ±0.04 ±0.04 ±0.02 ±0.08 ±0.04 ±0.04 ±0.02 ±0.1 ±0.5 1 0.5 0.1 4.2 0.05 0.05 V ±0.20 ±0.10 ±0.10 ±0.05 ±0.20 ±0.10 ±0.10 ±0.04 ±0.25 %FSO/°C %FSO ms %FSO/g mA %FSO/V 2/6 January 2007 / 006 www.sensortechnics.com 110L...-PCB / 430L...-PCB Series Signal conditioned precision pressure transducers PERFORMANCE CHARACTERISTICS 4...20 mA output version (unless otherwise noted VS = 15 V, RL = 100 Ω, tamb = 25°C) Characteristics Operating pressure3 differential devices 432LP01D-PCB 432LP02D-PCB 432LP05D-PCB 432LP10D-PCB 432LP25D-PCB 432LP50D-PCB 433LP01D-PCB 433LP02D-PCB 433LP05D-PCB 433LP10D-PCB 433LP25D-PCB 433LP50D-PCB 432LU01D-PCB 432LU02D-PCB 432LU05D-PCB 432LU10D-PCB 432LU20D-PCB 432LU30D-PCB 433LU01D-PCB 433LU02D-PCB 433LU05D-PCB 433LU10D-PCB 433LU20D-PCB 433LU30D-PCB 432L...-PCB 433L...-PCB 432L...-PCB 433L...-PCB Min. 0 0 0 0 0 0 -1 -2 -5 -10 -25 -50 0 0 0 0 0 -1 -2 -5 -10 -20 -30 3.9 11.9 15.8 7.9 Typ. Max. 1 2 5 10 25 50 1 2 5 10 25 50 1 2 5 10 20 30 1 2 5 10 20 30 4.1 12.1 16.2 8.1 Proof Common mode pressure2 pressure 200 200 200 200 300 300 200 200 200 200 300 300 80 120 120 240 240 240 80 120 120 240 240 240 300 300 300 300 600 600 300 300 300 300 600 600 160 240 240 360 360 360 160 240 240 360 360 360 Unit pressure/ vacuum devices3 mbar differential devices pressure/ vacuum devices3 "H2O Zero pressure offset4 Full scale span5 Full scale output Output at lowest specified pressure 433L...-PCB Thermal effects Offset (0 to 50°C)6 43...LP01D-PCB 43...LP02D-PCB 43...LU01D-PCB all other devices Span 43...LP01D-PCB 43...LP02D-PCB 43...LU01D-PCB all other devices Non-linearity and hysteresis (BSL)7 Long term stability8 Response time (10 to 90 %) Position sensitivity all 1 and 2 mbar devices all 1 "H2O devices all other devices Current consumption (IL = 20 mA) Power supply Offset rejection Span 4.0 12.0 16.0 8.0 20.0 4.0 ±0.08 ±0.04 ±0.04 ±0.02 ±0.08 ±0.04 ±0.04 ±0.02 0.1 ±0.2 1 0.5 0.5 0.1 4.2 0.05 0.05 mA ±0.20 ±0.10 ±0.10 ±0.05 ±0.20 ±0.10 ±0.10 ±0.04 0.25 %FSO/°C %FSO ms %FSO/g mA %FSO/V January 2007 / 006 3/6 www.sensortechnics.com 110L...-PCB / 430L...-PCB Series Signal conditioned precision pressure transducers Specification notes: 1. 2. 3. 4. 5. 6. 7. 8. The minimum supply voltage is directly proportional to the load resistance seen by the transmitter. For more details see the load limitation diagram. Proof pressure is the maximum pressure which may be applied without causing damage to the sensing element. The output signal is proportional to the pressure applied to port B, relative to port A, e.g. the output signal increases when vacuum is applied to port A relative to port B. Calibrated after minimum 3 minutes warm-up time. Full scale span is the algebraic difference between the positive full scale output and the zero pressure offset. Thermal effects tested and guaranteed from 0 - 50°C relative to 25°C. All specifications shown are relative to 25°C. Non-linearity refers to the Best Straight Line fit measured for offset pressure, full scale pressure and 1/2 full-scale pressure. Change in output after one year or 1 million pressure cycles. OUTPUT CHARACTERISTICS 1...6 V output versions Differential devices 112L...-PCB 6 Vout 5 V 4 3 2 1 0 20 40 60 80 100 % full scale pressure 1...6 V output versions Pressure/vacuum devices 113L...-PCB 6 Vout 5 V 4 3 2 1 0 -100 -50 0 50 100 % full scale pressure 3.5 V 4...20 mA output versions Differential devices 432L...-PCB 20 Iout 16 mA 12 8 4 0 20 40 60 80 100 % full scale pressure 4...20 mA output versions Pressure/vacuum devices 433L...-PCB 20 Iout 16 mA 12 8 4 0 -100 -50 0 50 100 % full scale pressure 4/6 January 2007 / 006 www.sensortechnics.com 110L...-PCB / 430L...-PCB Series Signal conditioned precision pressure transducers LOAD LIMITATION 4...20 mA output versions 1200 Ohm 1000 800 600 400 200 operating range 0 10 20 30 V Vsupply OUTLINE DRAWING 30.0 18.3 30.5 port A 14.0 9.1 10.7 3 terminals 0.56 diam. 2 x 5.08 typ. 22.7 1 2 3 12.6 59.8 52.4 port B (high pressure port) 3.5 diam. 2 x mounting holes NOM 6.0 3 mass: 20 g PIN CONNECTION: Pin 1 2 3 Connection 1 - 6 V version 4 - 20 mA version +Vs -Vs Vout NC -Vs +Vs 4.8 diam. dimensions in mm January 2007 / 006 5/6 www.sensortechnics.com 110L...-PCB / 430L...-PCB Series Signal conditioned precision pressure transducers ORDERING INFORMATION Operating pressure 0 - 1 mbar 0 - 2 mbar Differential/gage devices 0 - 5 mbar 0 - 10 mbar 0 - 25 mbar 0 - 50 mbar 0 ±1 mbar 0 ±2 mbar Pressure/vacuum devices 0 ±5 mbar 0 ±10 mbar 0 ±25 mbar 0 ±50 mbar 0 - 1"H2O 0 - 2"H2O Differential/gage devices 0 - 5"H2O 0 - 10"H2O 0 - 20"H2O 0 - 30"H2O 0 ± 1"H2O 0 ± 2"H2O Pressure/vacuum devices 0 ± 5"H2O 0 ± 10"H2O 0 ± 20"H2O 0 ± 30"H2O Part number 1...6 V output --112LP02D-PCB 112LP05D-PCB 112LP10D-PCB 112LP25D-PCB 112LP50D-PCB 113LP01D-PCB 113LP02D-PCB 113LP05D-PCB 113LP10D-PCB 113LP25D-PCB 113LP50D-PCB 112LU01D-PCB 112LU02D-PCB 112LU05D-PCB 112LU10D-PCB 112LU20D-PCB 112LU30D-PCB 113LU01D-PCB 113LU02D-PCB 113LU05D-PCB 113LU10D-PCB 113LU20D-PCB 113LU30D-PCB 4...20 mA output 432LP01D-PCB 432LP02D-PCB 432LP05D-PCB 432LP10D-PCB 432LP25D-PCB 432LP50D-PCB 433LP01D-PCB 433LP02D-PCB 433LP05D-PCB 433LP10D-PCB 433LP25D-PCB 433LP50D-PCB 432LU01D-PCB 432LU02D-PCB 432LU05D-PCB 432LU10D-PCB 432LU20D-PCB 432LU30D-PCB 433LU01D-PCB 433LU02D-PCB 433LU05D-PCB 433LU10D-PCB 433LU20D-PCB 433LU30D-PCB Custom calibrations available Sensortechnics reserves the right to make changes to any products herein. Sensortechnics does not assume any liability arising out of the application or use of any product or circuit described herein, neither does it convey any license under its patent rights nor the rights of others. 6/6 January 2007 / 006 www.sensortechnics.com