EVL150W-HVSL

EVL150W-HVSL Data brief 150 V - 150 W LED driver using the STCMB1transition mode PFC and HBR resonant tank combo controller Features • • • • • • • • • • • • • • • Universal input mains range: 90 to 264 Vac -frequency 45 to 65 Hz Half-bridge topology: LCC Max. output voltage and current: 150 V at 1 A continuous operation No-load mains consumption: < 0.5 W THD < 10% at 230 Vac from 30 to 100% of the full load No need of auxiliary SMPS (Viper or equivalent) Efficiency: >91% at full load No electrolytic capacitors for long term reliability Conducted EMC: within EN55022-Class-C limits Safety: meets EN60950 Dimming: analog, resistive, PWM (open collector) Feedback loops: constant current and constant voltage Protections: LED short-circuit, LED string open, regulation loop failure Dimensions: 69x157 mm, 28 mm components maximum height PCB: double side, 70 μm, FR-4, mixed PTH/SMT Description The EVL150W-HVSL is an evaluation board of a150 W / 1 A LED driver with wide input mainsrange. The electrical specification is tailored on a typical high-power street lighting application. Product status link EVL150W-HVSL It is based on a two-stage architecture, consisting of a front-end PFC pre-regulator and a downstream half-bridge resonant tank converter. The pre-regulator is a transition mode PFC based on constant ON time control, while the resonant converter is an LCC tank that is more suitable than LLC tank to build a current source. Both stages are based on the new STCMB1 combo controller that integrates, in the same device, a transition mode PFC controller and a half-bridge resonant controller. Thanks to the STCMB1, the main features of this design are high efficiency, no-load input power consumption is very low, reduced harmonics compliant with the EN61000-3-2 Class-C, and EMI within the relevant EN55022 limits. Another noticeable feature of this LED driver is the extremely wide dimming capability, actually the board can regulate the current from maximum level down to less than 10% with analog dimming and to 1% in PWM dimming. The PWM dimming is perfectly flicker free, because even in the case of very low current, it is kept continuous (DC) in the LED and thus independent of the frequency of the PWM dimming signal. The board also has protection features in case of overload, short-circuit, open loop by each section. For this particular application, all protections in case of intervention have an auto-restart functionality. DB3398 - Rev 3 - February 2020 For further information contact your local STMicroelectronics sales office. www.st.com EVL150W-HVSL Electrical diagram 1 Electrical diagram Figure 1. Electrical diagram D3 STTH5L06 D8 1N4148WS 1 R6 3R3 C9 100uF-450V A2 R31 0R15 1 R7 22R R5 0R0 R8 100K C10 2N2-Y1 400 Vdc 0.375 A C11 2N2-Y1 Q1 JPX1 OPEN C12 470pF - 1KV D2 1N4148WS R52 N.M. R2 5R6 2 R11 56R R10-JPX2 SHORTED 2 1 R29 N.M. Q2 STF13N60M2 R12 100K C6 4N7 500V T1 1860.0152 2 1 14 4 R14 100K 9 R15 100R 5 150V @1A 2 ANODE 1 CATHODE J2 MKDS 1/2-5.0 2 2512 2 R18 1R0 Q4 BSS169 D14 BAV21W-V 12V 1 R24 R25 62K 2R2 C23 4.7uF 63V C20 1uF R19 7K5 C19 N.M. R21 10R C24 4.7uF 63V R20 13K C21 2N2 SECONDARY SIDE DIMMING R22 1K5 1 U1 TLVH431AIL3T 3 R16 N.M. JPX101 C18 470N R17 1R0 2512 6 C13 220pF-630V R101 2M2 10 C14 47nF 1KV 3 1 2 3 4 5 6 7 8 9 10 1 2 3 4 5 6 7 8 9 10 1 R13 56R R30 N.M. D12 STTH3R02Q A2 JP101A MALE HEADER 20P 90° C17 470N 2 12 Q3 STF13N60M2 2 VOUT_PFC N.C N.C. LVG ISEN_PFC GD_PFC ZCD GND GND ISEN_HB D5 R3 1N4148WS 5R6 C16 470N C15 470N D11 STTH3R02Q 1 JP1A FEMALE HEADER 20 L3 10uH 1 D10 STTH3R02Q 1 A2 R9 N.M. D9 STTH3R02Q 2 3 2 1 R1 NTC 2R5-S237 2 11 R4-JPX1 0R18 HS1 D7 S1M D6 S1M D4 5 3 _ ~ C5 470N - 630V 1 1N4005 9 2 3 FGND: OPT for VDR 4 3 2 1 C3 2N2-Y1 90-264Vac HEAT-SINK C1 470N-X2 C4 470N-X2 3 RV1 300Vac 4 3 2 1 L2 1975.0004 D1 GBU8J 2 ~ PH EARTH N L1 2019.0002 C2 2N2-Y1 + F1 FUSE T4A J1 MKDS 1,5/ 3-5,08 STF24N60M2 2 2 1 D13 STPS1H100A C104 1N2 6 7 R113 25K C112 2u2 8 C111 4u7F R116 3K0 9 10 R120 1K2 R121 3K6 LVG VCC CF GD_PFC GND CSS RFMIN ISEN_HB STBY ISEN_PFC R114 10R 15 14 C105 1uF 3 Q102 BC847C 13 R117 270R 12 11 C113 470pF D104 R118 68R R115 4K7 C114 22P CC LOOP 1 7 6 5 4 3 2 1 C107 10uF 2220 11 12 13 14 15 16 17 18 19 20 11 12 13 14 15 16 17 18 19 20 R208 180K 3 1 2 C108 100N 1 R32 110K R45 100K C27 100N U6 TLVH431AIL3T 1 R112 10K OP1- OUT2 OP1+ OP2- GND OP2+ U202 LM258AD R42 2K7 U3 SFH617A-2 3 2 R111 1K0 VCC R206 N.M. 8 7 R205 27K 1 6 Q201 BC857C R213 0R0 2 3 R33 39K R46 330K C26 47N-500V 4 OUT1 VCC OP1- OUT2 OP1+ OP2- GND OP2+ R215 12K 8 R51 2K2 C204 100N R212 620K C203 100N 7 6 5 R216 12K 1 R50 5K6 R207 27K 5 R211 N.M. R40 N.M. 2 D103 MMSZ39T1 R210 4 20K R209 18K OUT1 C25 N.M. R39 4K7 4 CC_LOOP 1 3 VCC GND-U3 CV LOOP CC LOOP GND-U2 N.C. HVG OUT N.C. VAC R203 10K U201 LM258AD 2 R44 100K JPX102 1N4148 C202 470N R204 100R C115 1N5 CV_LOOP C201 100N R201 1K0 JPX103 Q101 BC847C R202 22R D102 1N4148 3 R124 47R CV LOOP JP201 MALE HEADER 7P 90° MALE STRIP DIRECTLY SOLDERED ON BOTH SIDES (MB & CC-CB) 1 2 C106 10uF JP2 N.M. R28 N.M. U2 SFH617A-2 D101 STPS140Z 2 16 R122 56K R123 N.M. 4 OUT R27 N.M. 2 NC2 TON ZCD 18 17 3 COMP HVG 2 C109 330N C110 220pF OUT C22 N.M. R26 3K9 19 GND DIMMING J3 MOLEX2P 2 5 R110 N.M. FB C8 10uF 2220 1 R109 56K R107 1K0 HVG D18 BAV99 R23 1R0 2 R108 160K 4 NC1 20 JP1B FEMALE HEADER 20 3 C103 10N VBOOT 1 C102 2 1N0 HV C7 10uF 2220 D105 1N4148 1 1 C101 100N MALE HEADER 20P 90° JP101B U101 STCMB1 MMSZ13T1 R106 3K9 2 3 R119 R104 56K R103 2M2 300R 1 9 8 7 6 5 4 3 2 1 VAC R325 180K R105 3K9 R102 2M2 R214 0R0 R218 1K0 R217 200K C206 N.M. C205 100N CC CONTROL BOARD STCMB1 DAUGHTER BOARD DB3398 - Rev 3 page 2/14 EVL150W-HVSL Bill of material 2 Bill of material Table 1. EVL150W-HVSL Evaluation board: bill of material (Rev. 2.3) Ref. C1 470 nF - X2 C2 2.2 nF - Y1 C3 2.2 nF - Y1 C4 470 nF - X2 Case 9.0 x 18.0 Description Supplier X2 - FILM CAP - B32922C3474K Epcos p. 10 mm Y1 SAFETY CAP. DE1E3KX222M Murata p. 10 mm Y1 SAFETY CAP. DE1E3KX222M Murata X2 - FILM CAP - B32922C3474K Epcos 630 V - FILM CAP - B32673Z6474K Epcos p. 15 mm 9.0 × 18.0 p. 15 mm 470 nF 8.5 x 26.5 630 V p. 22.5 mm C6 4.7 nF 5.0 x 13.0 p. 10 mm 450 Vac - FILM CAP - B32651A7472K Epcos C7 10 μF 2220 CERCAP - 50 V - X7R - 20 % TDK C8 10 μF 2220 CERCAP - 50 V - X7R - 20 % TDK 100 μF diam. 450 V 18 x 35.5 mm Aluminium ELCAP - CY series - 105 °C Nichicon C10 2.2 nF - Y1 p. 10 mm Y1 SAFETY CAP. DE1E3KX222M Murata C11 2.2 nF - Y1 p. 10 mm Y1 SAFETY CAP. DE1E3KX222M Murata C12 470 pF - 1 KV 1206 1 KV CERCAP - X7R - 10 % Murata C13 220 pF 1206 630 V CERCAP -GRM31A7U2J220JW31 Murata C14 47 nF - 1 KV 1 KV - FILM CAP - B32652A0473K Epcos C15 470 nF MKT FILM CAP - B32521C3474M -250 V - 20 % Epcos C16 470 nF MKT FILM CAP - B32521C3474M -250 V - 20 % Epcos C17 470 nF MKT FILM CAP - B32521C3474M -250 V - 20 % Epcos C18 470 nF MKT FILM CAP - B32521C3474M -250 V - 20 % Epcos C19 N.M. 1210 CERCAP - 50 V - X7R - 20 % TDK C20 1 μF 1206 CERCAP - 50 V - X7R - 20 % TDK C21 2.2 nF 0805 50 V CERCAP - C0G - 10 % AVX C22 N.M. 0805 Not mounted C23 4.7 μF C24 4.7 μF C25 N.M. 0805 Not mounted C26 47 nF - 500 V 1206 CERCAP - 500 V - X7R - 10 % C5 C9 DB3398 - Rev 3 Value 7.0 x 18.0 p. 15 mm 6.0 x 13 p. 10 mm 6.0 x 13 p. 10 mm 6.0 x 13 p. 10 mm 6.0 x 13 p. 10 mm 8.5 x 7.2 p. 5 mm 8.5 x 7.2 p. 5 mm MKS2 FILM CAP - MKS2C044701M00 - 63 V - 5 % Wima MKS2 FILM CAP - MKS2C044701M00 - 63 V - 5 % Wima Kemet page 3/14 EVL150W-HVSL Bill of material Ref. DB3398 - Rev 3 Value Case Description Supplier C27 100 nF 0805 CERCAP - 50 V - X7R - 10 % Kemet C101 100 nF 1206 50 V CERCAP - general purpose - X7R- 10 % TDK C102 1.0 nF 1206 2 KV CERCAP - X7R - 10 % Epcos C103 10 nF 0805 50 V CERCAP - general purpose - X7R - 10 % TDK C104 1.2 nF 0805 50 V CERCAP - general purpose - X7R - 10 % Epcos C105 1 μF 1206 50 V CERCAP - general purpose - X7R - 10 % TDK C106 10 μF 1206 CERCAP - 25 V - X7R - 20 % TDK C107 10 μF 2220 CERCAP - 50 V - X7R - 20 % TDK C108 100 nF 0805 CERCAP - 50 V - X7R - 10 % TDK C109 330 nF 0805 50 V CERCAP - general purpose - X7R- 10 % TDK C110 220 pF 0805 50 V CERCAP - general purpose - COG- 5 % Epcos C111 4.7 μF 1206 16 V CERCAP - general purpose - X7R- 10 % TDK C112 2.2 μF 1206 16 V CERCAP - general purpose - X7R- 10 % TDK C113 470 pF 0805 50 V CERCAP - general purpose - COG- 5 % Epcos C114 22 pF 0805 50 V CERCAP - general purpose - COG- 5 % Epcos C115 1.5 nF 0805 50 V CERCAP - general purpose - COG- 5 % Epcos C201 100 nF 0805 CERCAP - 50 V - X7R - 10 % Kemet C202 470 nF 0805 CERCAP - 25 V - C0G - 10 % AVX C203 100 nF 0805 CERCAP - 50 V - X7R - 10 % Kemet C204 100 nF 0805 CERCAP - 50 V - X7R - 10 % Kemet C205 100 nF 0805 CERCAP - 50 V - X7R - 10 % Kemet C206 N.M. 0805 Not mounted D1 GBU8J STYLE GBU Single phase bridge rectifier Vishay D2 1N4148WS SOD-323 High speed signal diode Vishay D3 1N4005 DO-41 General purpose rectifier Vishay D4 STTH5L06 DO-201 Ultrafast high voltage rectifier STMicroelectronics D5 1N4148WS SOD-323 High speed signal diode Vishay D6 S1M DO214AC General purpose rectifier, SMT Fairchild D7 S1M DO214AC General purpose rectifier, SMT Fairchild D8 1N4148WS SOD-323 High speed signal diode Vishay D9 STTH3R02Q DO-15 Ultra fast rectifier STMicroelectronics D10 STTH3R02Q DO-15 Ultra fast rectifier STMicroelectronics D11 STTH3R02Q DO-15 Ultra fast rectifier STMicroelectronics D12 STTH3R02Q DO-15 Ultra fast rectifier STMicroelectronics D13 STPS1H100A SMA Power SCHOTTKY diode STMicroelectronics D14 BAV21W-V SOD-123 Small signal diode high voltage Vishay D18 BAV99 SOT-23 Dual small signal diode Vishay D101 STPS140Z SOD-123 Power SCHOTTKY diode STMicroelectronics D102 1N4148 DO-35 Fast switching diode Vishay D103 MMSZ39T1 SOD-123 39 V Zener diode ON Semi page 4/14 EVL150W-HVSL Bill of material Ref. Value Case Description Supplier D104 MMSZ13T1 SOD-123 13 V Zener diode ON Semi D105 1N4148 DO-35 Fast switching diode Vishay F1 FUSE T4A FUSE 4 A - TIME LAG - 3921400 Littlefuse HS1 HEATSINK DWG J1 MKDS 1,5/3-5,08 DWG J2 MKDS 1/2-5.0 DWG J3 MOLEX2P HEADER 2.54 Male header 2.54 mm - 2P JP1A Female header 20 DWG Female header p. 2.54 mm PRECI-DIP JP1B Female header 20 DWG Female header p. 2.54 mm PRECI-DIP JP2 Female header 9 DWG Female header p. 2.54 mm PRECI-DIP JP101A Male header 20P 90° DWG Male header p. 2.54 mm 90° JP101B Male header 20P 90° DWG Male header p. 2.54 mm 90° JP201 Male header 7P 90° DWG Male header p. 2.54 mm 90° JPX101 WIRE JUMPER SHORTED JUMPER JPX102 1N4148 DO-35 Fast switching diode JPX103 WIRE JUMPER SHORTED JUMPER L1 2019.0002 DWG Input EMI filter Magnetica L2 1975.0004 DWG PFC inductor - 0.31 mH - PQ26/25 Magnetica L3 10 μH Drum coil RFB0807-100 Coilcraft Q1 STF24N60M2 TO-220FP N-Channel Power MOSFET STMicroelectronics Q2 STF13N60M2 TO-220FP N-Channel Power MOSFET STMicroelectronics Q3 STF13N60M2 TO-220FP N-Channel Power MOSFET STMicroelectronics Q4 BSS169 SOT-23 N-CH depletion MOSFET Infineon Q101 BC847C SOT-23 Small signal NPN BJT Vishay Q102 BC847C SOT-23 Small signal NPN BJT Vishay Q201 BC857C SOT-23 Small signal PNP BJT Vishay R1 NTC 2.5 Ω - S237 DWG NTC resistor P/N B57237S0259M000 Epcos R2 5.6 Ω 0805 R3 5.6 Ω 0805 R4-JPX1 0.18 Ω PTH 8.5 x 4 mm p. 5.08 mm diam 8.8 mm p. 5 mm Heatsink for D1, Q1, Q2, Q3 PCB TERM. BLOCK, SCREW CONN., PITCH 5 mm - 3 W. PCB TERM. BLOCK, SCREW CONN., PITCH 5 mm - 2 W. SMD standard film RES - 1/8 W - 5 % 250 ppm/°C Phoenix Contact Phoenix Contact Molex Vishay Vishay SMD standard film RES - 1/8 W - 5 % 250 ppm/°C Vishay RSMF1TB - METAL FILM RES - 1 W DB3398 - Rev 3 2 % - 200 ppm/°C Akanehom page 5/14 EVL150W-HVSL Bill of material Ref. DB3398 - Rev 3 Value Case Description SMD standard film RES - 1/8 W - 5 % Supplier R5 0.0 Ω 0805 R6 3.3 Ω 0805 R7 22 Ω 0805 R8 100 KΩ 0805 R9 N.M. PTH Not mounted R10-JPX2 SHORTED PTH Wire jumper R11 56 Ω 0805 R12 100 KΩ 0805 R13 56 Ω 0805 R14 100 KΩ 0805 R15 100 Ω 1206 R16 N.M. 0805 Not mounted R17 1.0 Ω 2512 SMD current sense resistor - 1 W - 1 % Panasonic R18 1.0 Ω 2512 SMD current sense resistor - 1 W - 1 % Panasonic R19 7.5 KΩ 0805 R20 13 KΩ 0805 R21 10 Ω 0805 R22 1.5 KΩ 0805 R23 1.0 Ω 1206 R24 2.2 Ω 0805 R25 62 KΩ 0805 R26 3.9 KΩ 0805 R27 N.M. 0805 Not mounted R28 N.M. 0805 Not mounted R29 N.M. 1206 Not mounted 200 ppm/°C SMD standard film RES - 1/8 W - 5 % 250 ppm/°C SMD standard film RES - 1/8 W - 5 % 250 ppm/°C SMD standard film RES - 1/8 W - 5 % 250 ppm/°C SMD standard film RES - 1/8 W - 5 % 250 ppm/°C SMD standard film RES - 1/8 W - 5 % 250 ppm/°C SMD standard film RES - 1/8 W - 5 % 250 ppm/°C SMD standard film RES - 1/8 W - 5 % 250 ppm/°C SMD standard film RES - 1/4 W - 1 % 100 ppm/°C SMD standard film RES - 1/8 W - 5 % 200 ppm/°C SMD standard film RES - 1/8 W - 1 % 100 ppm/°C SMD standard film RES - 1/8 W - 5 % 200 ppm/°C SMD standard film RES - 1/8 W - 1 % 100 ppm/°C SMD standard film RES - 1/4 W - 1 % 100 ppm/°C SMD standard film RES - 1/8 W - 5 % 250 ppm/°C SMD standard film RES - 1/8 W - 5 % 200 ppm/°C SMD standard film RES - 1/8 W - 5 % 250 ppm/°C Vishay Vishay Vishay Vishay Vishay Vishay Vishay Vishay Vishay Vishay Vishay Vishay Vishay Vishay Vishay Vishay Vishay page 6/14 EVL150W-HVSL Bill of material Ref. Value Case R30 N.M. 1206 R31 0.15 Ω PTH R32 110 KΩ 0805 R33 39 KΩ 0805 R39 4.7 KΩ 0805 R40 N.M. 0805 R42 2.7 KΩ 0805 R44 100 KΩ 0805 R45 100 KΩ 0805 R46 330 KΩ 0805 R50 5.6 KΩ 0805 R51 2.2 KΩ 0805 R52 N.M. 0805 R101 2.2 MΩ 1206 R102 2.2 MΩ 1206 R103 2.2 MΩ 1206 R104 56 KΩ 1/4 W R105 3.9 KΩ 1206 R106 3.9 KΩ 1206 R107 1.0 KΩ 0805 R108 160 KΩ 0805 R109 56 KΩ 0805 Description Supplier Not mounted RSMF1TB - metal film RES - 1 W - 2 % 200 ppm/°C SMD standard film RES - 1/8 W - 5 % 250 ppm/°C SMD standard film RES - 1/8 W - 5 % 250 ppm/°C SMD standard film RES - 1/8 W - 5 % 250 ppm/°C Vishay Vishay Vishay Not mounted SMD standard film RES - 1/8 W - 5 % 250 ppm/°C SMD standard film RES - 1/8 W - 1 % 100 ppm/°C SMD standard film RES - 1/8 W - 1 % 100 ppm/°C SMD standard film RES - 1/8 W - 5 % 250 ppm/°C SMD standard film RES - 1/8 W - 1 % 100 ppm/°C SMD standard film RES - 1/8 W - 1 % 100 ppm/°C Vishay Vishay Vishay Vishay Vishay Vishay Not mounted SMD standard film RES - 1/4 W - 1 % 100 ppm/°C SMD standard film RES - 1/4 W - 1 % 100 ppm/°C SMD standard film RES - 1/4 W - 1 % 100 ppm/°C PTH standard film res. - 1/4 W - 5% 250 ppm/°C SMD standard film RES - 1/4 W - 5 % 200 ppm/°C SMD standard film RES - 1/4 W - 5 % 200 ppm/°C SMD standard film RES - 1/8 W - 5 % 200 ppm/°C Vishay Vishay Vishay Vishay Vishay Vishay Vishay SMD standard film RES - 1/8 W - 1 % DB3398 - Rev 3 100 ppm/°C SMD standard film RES - 1/8 W - 1 % 100 ppm/°C Vishay Vishay page 7/14 EVL150W-HVSL Bill of material Ref. Value Case R110 N.M. 0805 R111 1.0 KΩ 0805 R112 10 KΩ 0805 R113 25 KΩ 0805 R114 10 Ω 1206 R115 4.7 KΩ 0805 R116 3.0 KΩ 0805 R117 270 Ω 0805 R118 68 Ω 0805 R119 300 Ω 0805 R120 1.2 KΩ 0805 R121 3.6 KΩ 0805 R122 56 KΩ 0805 R123 N.M. 0805 R124 47 Ω 0805 R201 1.0 KΩ 0805 R202 22 Ω 0805 R203 10 KΩ 0805 R204 100 Ω 0805 R205 27 KΩ 0805 R206 N.M 0805 R207 27 KΩ 0805 Description Supplier Not mounted SMD standard film RES - 1/8 W - 5 % 200 ppm/°C SMD standard film RES - 1/8 W - 5 % 200 ppm/°C SMD standard film RES - 1/8 W - 1 % 100 ppm/°C SMD standard film RES - 1/4 W - 5 % 250 ppm/°C SMD standard film RES - 1/8 W - 5 % 200 ppm/°C SMD standard film RES - 1/8 W - 1 % 100 ppm/°C SMD standard film RES - 1/8 W - 5 % 250 ppm/°C SMD standard film RES - 1/8 W - 1 % 100 ppm/°C SMD standard film RES - 1/8 W - 5 % 250 ppm/°C SMD standard film RES - 1/8 W - 1 % 100 ppm/°C SMD standard film RES - 1/8 W - 1 % 100 ppm/°C SMD standard film RES - 1/8 W - 1 % 100 ppm/°C Vishay Vishay Vishay Vishay Vishay Vishay Vishay Vishay Vishay Vishay Vishay Vishay Not mounted SMD standard film RES - 1/8 W - 5 % 250 ppm/°C SMD standard film RES - 1/8 W - 1 % 100 ppm/°C SMD standard film RES - 1/8 W - 5 % 250 ppm/°C SMD standard film RES - 1/8 W - 1 % 100 ppm/°C SMD standard film RES - 1/8 W - 5 % 250 ppm/°C SMD standard film RES - 1/8 W - 5 % 250 ppm/°C Vishay Vishay Vishay Vishay Vishay Vishay Not mounted SMD standard film RES - 1/8 W - 1 % DB3398 - Rev 3 100 ppm/°C Vishay page 8/14 EVL150W-HVSL Bill of material Ref. Value Case Description Supplier SMD standard film RES - 1/8 W - 1 % R208 180 KΩ 0805 R209 18 KΩ 0805 R210 20 KΩ 0805 R211 N.M 0805 R212 620 KΩ 0805 R213 0.0 Ω 0805 R214 0.0 Ω 0805 R215 12 KΩ 0805 R216 12 KΩ 0805 R217 200 KΩ 0805 R218 1.0 KΩ 0805 R325 180 KΩ 1206 RV1 300 Vac T1 100 ppm/°C Vishay SMD standard film RES - 1/8 W - 1 % DB3398 - Rev 3 diam. 15 x 5 100 ppm/°C SMD standard film RES - 1/8 W - 1 % 100 ppm/°C Vishay Vishay Not mounted SMD standard film RES - 1/8 W - 1 % 100 ppm/°C SMD standard film RES - 1/8 W - 5 % 200 ppm/°C SMD standard film RES - 1/8 W - 5 % 200 ppm/°C SMD standard film RES - 1/8 W - 1 % 100 ppm/°C SMD standard film RES - 1/8 W - 1 % 100 ppm/°C SMD standard film RES - 1/8 W - 1 % 100 ppm/°C SMD standard film RES - 1/8 W - 1 % 100 ppm/°C SMD standard film RES - 1/8 W - 5 % 250 ppm/°C Vishay Vishay Vishay Vishay Vishay Vishay Vishay Vishay p. 7.5 mm 300V METAL OXIDE VARISTOR B72214S0301K101 Epcos 1860.0152 DWG Resonant transformer Magnetica U1 TLVH431AIL3T SOT23-3L 1.24 V programmable shunt voltage reference STMicroelectronics U2 SFH617A-2 DIP-4 - 10.16 mm Optocoupler Vishay U3 SFH617A-2 DIP-4 - 10.16 mm Optocoupler Vishay U6 TLVH431AIL3T SOT23-3L 1.24 V programmable shunt voltage reference STMicroelectronics U101 STCMB1 SO20W TM PFC & LLC resonant Combo controller STMicroelectronics U201 LM258AD SO-8 Low power dual OP AMP STMicroelectronics U202 LM258AD SO-8 Low power dual OP AMP STMicroelectronics Z1 PCB REV. 2.0 STCMB1 power board Z101 PCB REV. 1.0 STCMB1 daughterboard Z201 PCB REV. 1.0 CC control board page 9/14 EVL150W-HVSL Revision history Table 2. Document revision history DB3398 - Rev 3 Date Version Changes 04-Oct-2017 1 Initial release. 29-Mar-2019 2 Features and description update. 26-Feb-2020 3 Updated THD value in Section feature and description page 10/14 EVL150W-HVSL Contents Contents 1 Electrical diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 2 Bill of material . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3 Revision history . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10 Contents . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11 List of tables . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12 List of figures. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13 DB3398 - Rev 3 page 11/14 EVL150W-HVSL List of tables List of tables Table 1. Table 2. EVL150W-HVSL Evaluation board: bill of material (Rev. 2.3) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 Document revision history . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10 DB3398 - Rev 3 page 12/14 EVL150W-HVSL List of figures List of figures Figure 1. DB3398 - Rev 3 Electrical diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 page 13/14 EVL150W-HVSL IMPORTANT NOTICE – PLEASE READ CAREFULLY STMicroelectronics NV and its subsidiaries (“ST”) reserve the right to make changes, corrections, enhancements, modifications, and improvements to ST products and/or to this document at any time without notice. Purchasers should obtain the latest relevant information on ST products before placing orders. ST products are sold pursuant to ST’s terms and conditions of sale in place at the time of order acknowledgement. Purchasers are solely responsible for the choice, selection, and use of ST products and ST assumes no liability for application assistance or the design of Purchasers’ products. No license, express or implied, to any intellectual property right is granted by ST herein. Resale of ST products with provisions different from the information set forth herein shall void any warranty granted by ST for such product. ST and the ST logo are trademarks of ST. For additional information about ST trademarks, please refer to www.st.com/trademarks. All other product or service names are the property of their respective owners. Information in this document supersedes and replaces information previously supplied in any prior versions of this document. © 2020 STMicroelectronics – All rights reserved DB3398 - Rev 3 page 14/14