RVQ103YN Series
TOCOS
PA N E L C O N T R O L S
®
Long Life 10mm Diameter, Single-Turn, Carbon Panel Controls
RVQ103YP
RVQ103YN
Features
Long life 10mm diameter, single-turn industrial panel controls Carbon film element 200,000 cycle rotational life Single unit, single shaft Linear taper Molded plastic construction for housing and bushing Lightweight 3 mm diameter metal shafts in slot, flat or round end styles Standard 10mm or 15mm shaft length Panel mount style Rear exit vertical lug terminals PCB mounting style available as special order
Specifications
Electrical
Standard Resistance Range . . . . . . . . . . . . 5k Ω and 10k Ω Resistance Tolerance . . . . . . . . . . . . . . . . . 20% standard End Resistance . . . . . . . . . . . . . . . . . . . . . . . Not applicable Resistance Taper . . . . . . . . . . . . . . . . . . . . . . . . . . B = linear Independent Linearity . . . . . . . . . . . . . . . . . . . . Power Rating . . . . . . . 0.125 watt at 3% max. 85 C Peak Noise (C.R.V.) . . . . . . . 1% or 2 Ω, whichever is greater 40 C, 0 watt at Maximum Input Voltage . . . . . . . . . 35VDC or power rating, whichever is smaller Insulation Resistance . . . . . . . 100M Ω minimum at 500VDC Dielectric Strength . . . . . . . . . . . . . . . . . . 500VAC, 1 minute Adjustment Travel . . . . . . . . . . . . . . . . . . . . . . 320 nominal
Environmental
Temperature Range . . . . . . . . . . . . . . . . . . Temperature Characteristics . . . . . . . . . . . 10 C to 85 C 85 C, 5 hours ∆T/R ) 10%
Temperature Cycle . . . . . . . . . . . . . . . . . . . . 10 C , 85 C, 30 minutes each, 5 cycles ∆T/R ) 10% Load Life . . . . . . . . . . . . . . . . 40 C, 0.125 watt, 1,000 hours ∆T/R ) 10%
Moisture and Load Life . . . . . . . . . . . . 40 C, 90-95%RH, 0.125 watt, 500 hours ∆T/R ) 10% Vibration . . . . . . . . . 10-55Hz, 1.5mm amplitude, 3 directions ∆T/R ) 5% Soldering Heat Resistance . . . . . . . 350 C 5 C, 3 seconds ∆T/R ) 2% Rotational Life . . . . . . . . . . . . . 200,000 cycles without load ∆T/R ) 5%
∆T/R = Total Resistance Change
Mechanical
Mechanical Travel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 360 Shaft Torque . . . . . . . . . . . . . . . 15 gf • cm (0.208 oz • in) max. Stop Strength . . . . . . . . . . . . . . . . . . . . Continuous, no stop Shaft Strength (push) . . . . . . . . . . . . . . . 29.4 N (3 kgf ) min. Shaft Strength (tensile) . . . . . . . . . . . . . 29.4 N (3 kgf ) min. Shaft End Play . . . . . . . . . 0.3 ( shaft length/15) mm max. Mounting Nut Torque . . . . . . 3.5 kgf • cm (48.52 oz • in) min. Marking . . . . . Model type, taper, resistance code, date code
Note: A long life panel control should only be used in a circuit as a potentiometer (3-terminal voltage divider ).
86
1177 East Tower Road, Schaumburg, IL 60173
TOCOS AMERICA, INC.
Tel: 847-884-6664 Fax: 847-884-6665 E-mail: sales@tocos.com www.tocos.com
RVQ103YN Series
RVQ103YN
Dimensions
Unit: mm
Panel Mount, Single Unit, Single Shaft Rear Exit Vertical Lug Terminals, 3-Lug Triangular Pattern
Recommended Panel Mounting Hole
Part Numbering System
RV Q 103 Y N 15 S B 103 M
NOTE: FMS = From Mounting Surface
Resistance Tolerance: M =
20% (standard).
Resistance Code: Expressed in ohms. A three digit code where the first two digits are significant figures, and the third digit indicates the number of zeros that follow these figures (i.e., 100 = 10 Ω ; 101 = 100 Ω ; 102 = 1,000 Ω ; 103 = 10,000 Ω ). See table for standard resistance values. Resistance Taper: B = Linear. Shaft End Style: S = Slotted. F = Flatted. R = Round. Standard Shaft Length: 10 = 10mm FMS. 15 = 15mm FMS. Up to 30mm shaft length available (special order ). Style: N = Panel Mount, Single Unit, Single Shaft, Rear Exit Vertical Lug Terminals, 3-Lug Triangular Pattern (standard). P = PCB Mount, Single Unit, Single Shaft, Rear Exit Vertical Mount Pin Terminals, 3-Pin Triangular Pattern (special order ). Operating Temperature Range: Y = 10 C to 85 C.
Size and Style: 10 = 10mm Diameter; 3 = Style of 10mm Size. Rotational Life: Q = Long Life, 200,000 cycles. TOCOS Series Name: RV = Carbon Film Element.
Standard Resistance Values and Part Numbering Codes
Standard Nominal Total Resistance Values and Part Numbering Codes
Resistance ( Ω ) 5,000 Code 502 Resistance ( Ω ) 10,000 Code 103
Refer to Shaft End Styles Specifications and Hardware Specifications for details and availability. For additional information, refer to Guidelines and Precautions for Using Panel Controls.
TOCOS AMERICA, INC.
1177 East Tower Road, Schaumburg, IL 60173 Tel: 847-884-6664 Fax: 847-884-6665 E-mail: sales@tocos.com www.tocos.com
87
