RVQ12YN15FB101K

RVQ12YN Series TOCOS PA N E L C O N T R O L S ® Long Life 12mm Diameter, Single-Turn, Carbon Panel Controls RVQ12YN Features Long life 12mm diameter, single-turn industrial panel controls Carbon film element 200,000 cycle rotational life Single unit, single shaft Continuous rotation, no stop Lightweight plastic housing Metal shaft and bushing 3.2mm diameter metal shafts in slot, flat or round end styles Standard 10mm or 15mm shaft length Linear taper Panel mount style Rear exit vertical lug terminals PCB mounting style available as special order Specifications Electrical Standard Resistance Range . . . . . . . . . . . . . 1k Ω to 100k Ω Resistance Tolerance . . . . . . . . . . . . . . . . . 10% standard End Resistance . . . . . . . . . . . . . . . . . . . . . . . Not applicable Resistance Taper . . . . . . . . . . . . . . . . . . . . . . . . . . B = linear Independent Linearity . . . . . . . . . . . . . . . . . . . . Power Rating . . . . . . . 0.125 watt at 3% max. 80 C Peak Noise (C.R.V.) . . . . . . . . . . . . . . . . . . . . . . . . 2% max. 40 C, 0 watt at Maximum Input Voltage . . . . . . . . 110VDC or power rating, whichever is smaller Insulation Resistance . . . . . . . 100M Ω minimum at 500VDC Dielectric Strength . . . . . . . . . . . . . . . . . . 500VAC, 1 minute Adjustment Travel . . . . . . . . . . . . . . . . . . . . . . 320 nominal Environmental Temperature Range . . . . . . . . . . . . . . . . . Temperature Characteristics . . . . . . . . . . . 30 C to 80 C 85 C, 5 hours ∆T/R ) 5% Temperature Cycle . . . . . . . . . . . . . . . . . . . . 30 C , 80 C, 30 minutes each, 5 cycles ∆T/R ) 10% Load Life . . . . . . . . . . . . . . . . 40 C, 0.125 watt, 1,000 hours ∆T/R ) 10% Moisture and Load Life . . . . . . . . . . . . 40 C, 90-95%RH, 0.125 watt, 500 hours ∆T/R ) 10% Vibration . . . . . . . . 10-55Hz, 1.5mm amplitude, 3 directions ∆T/R ) 5% Soldering Heat Resistance . . . . . . . 350 C 5 C, 3 seconds ∆T/R ) 2% Rotational Life . . . . . . . . . . . . . 200,000 cycles without load ∆T/R ) 5% ∆T/R = Total Resistance Change Mechanical Mechanical Travel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 360 Shaft Torque . . . . . . . . . . . . . . . 15 gf • cm (0.208 oz • in) max. Stop Strength . . . . . . . . . . . . . . . . . . . . Continuous, no stop Shaft Strength (push) . . . . . . . . . . . . . . . 29.4 N (3 kgf ) min. Shaft Strength (tensile) . . . . . . . . . . . . . . 9.8 N (1 kgf ) min. Shaft End Play . . . . . . . . 0.15 ( shaft length/15) mm max. Mounting Nut Torque . . . . . . . . 3 kgf • cm (41.59 oz • in) min. Marking . . . . . Model type, taper, resistance code, date code Note: A long life panel control should only be used in a circuit as a potentiometer (3-terminal voltage divider ). 88 1177 East Tower Road, Schaumburg, IL 60173 TOCOS AMERICA, INC. Tel: 847-884-6664 Fax: 847-884-6665 E-mail: sales@tocos.com www.tocos.com RVQ12YN Series RVQ12YN Dimensions Unit: mm Panel Mount, Single Unit, Single Shaft Rear Exit Vertical Lug Terminals, 3-Lug Triangular Pattern Recommended Panel Mounting Hole Part Numbering System RV Q 12 Y N 15 S B 103 K NOTE: FMS = From Mounting Surface Resistance Tolerance: K = 10% (standard). Resistance Code: Expressed in ohms. A three digit code where the first two digits are significant figures, and the third digit indicates the number of zeros that follow these figures (i.e., 100 = 10 Ω ; 101 = 100 Ω ; 102 = 1,000 Ω ; 103 = 10,000 Ω ; 104 = 100,000 Ω ). See table for standard resistance values. Resistance Taper: B = Linear. Shaft End Style: S = Slotted. F = Flatted. R = Round. Standard Shaft Length: 10 = 10mm FMS. 15 = 15mm FMS. Up to 30mm shaft length available (special order ). Style: N = Panel Mount, Single Unit, Single Shaft, Rear Exit Vertical Lug Terminals, 3-Lug Triangular Pattern (standard). P = PCB Mount, Single Unit, Single Shaft, Rear Exit Vertical Mount Pin Terminals, 3-Pin Triangular Pattern (special order ). Operating Temperature Range: Y = Size: 12 = 12mm Diameter. Rotational Life: Q = Long Life, 200,000 cycles. TOCOS Series Name: RV = Carbon Film Element. 30 C to 80 C. Standard Resistance Values and Part Numbering Codes Standard Nominal Total Resistance Values and Part Numbering Codes Resistance ( Ω ) 1,000 2,000 5,000 Code 102 202 502 Resistance ( Ω ) 10,000 20,000 50,000 Code 103 203 503 Resistance ( Ω ) 100,000 Code 104 Refer to Shaft End Styles Specifications and Hardware Specifications for details and availability. For additional information, refer to Guidelines and Precautions for Using Panel Controls. TOCOS AMERICA, INC. 1177 East Tower Road, Schaumburg, IL 60173 Tel: 847-884-6664 Fax: 847-884-6665 E-mail: sales@tocos.com www.tocos.com 89