TPDC200P-48B

36-72VDC INPUT RANGE DC-DC CONVERTER HOT-SWAP CompactPCI QUAD OUTPUT 200 WATTS CURRENT SHARING SWITCHING POWER SUPPLIES TPDC200P-48B SERIES FEATURES: 200W IN 3U X 8HP EUROCARD PACKAGE CompactPCI DC-DC CONVERTER INTERNAL OR-ING DIODES FOR N+1 REDUNDANCY DROOP CURRENT SHARING HOT-SWAPPABLE EMI MEET EN55022/FCC CLASS B CE MARKING COMPLIANCE FULLY COMPLIANT WITH PICMG TOTAL POWER INT'L SPECIFICATION INPUT SPECIFICATION Input Voltage: Typ. 36-72Vdc nominal 48Vdc. Input Connector: Positronic 47-pin PCIH47M400A1. Inrush Current: Cold start 8A @ 72 Vdc. (Active) Input Current: 4.5A @ nominal 48Vdc. Dielectric Withstand: Meet IEC950 regulation. EMI: Meet CISPR EN55022 & FCC Class B. Remote ON/OFF: Available at [INH#] & [EN#] pins. Power Fail Signal: Available at [FAL#] pin. Status LED: means valid input voltage. means a critical fault. Thermal Protection: Installed NTC for thermal sensor at [DEG#] pin. Overload Protection (OLP): Fully protected against output oveload or short circuit. Typ. set at 150% max. load. Consult the factory for special OLP setting. OUTPUT SPECIFICATION Output Voltage: See Ratings Chart. Output Current: See Ratings Chart. Output Wattage: Typ. 200W continuous. Output Connector: Positronic 47-pin PCIH47M400A1. Line Regulation: Typ. 0.5% over DC input range. Load Regulation: Typ. ±1.0-2.0%. Noise & Ripple: Typ. 1% peak to peak or 50mV, which is greater. OVP: Built-in at VO1 & VO2. Adjustability: Available at VO1 & VO2. VO3 factory set. Remote Sensing: Available at VO1,VO2 & VO3. Hot-Swap: Available. N+1 Redundancy: Installed with internal OR-ing diodes at all outputs for N+1 redundancy operation. Current Sharing: Droop current sharing method for all outputs. Operating Temperature: 0 to +50°C at full load with specified air flow. Derates linearly to 50% at +70°C. Storage Temperature: -40 to +85°C. Temperature Coefficient: Typ. ±0.02% /°C. Cooling: At least 20 cfm (600 lfm) moving air is required to achieve full rating power. Power Density: 3.7 Watts / Cubic Inch. GENERAL SPECIFICATION Efficiency: Typ. 79%. Switching Frequency: 130 KHz. Circuit Topology: Forward circuit. Transient Response: Peak transient less than 200mV and recovers within 3mS after 25% load-change. Safety Standard: IEC950/ UL1950. Construction: Eurocard 3U x 8HP x 160mm CompactPCI format. Front Panel with either Ordinary handle or Extractor handle. Note: All measurements are at nominal input, full load, and +25°C unless otherwise specifications. TOTAL POWER, INT. Tel: 877-646-0900 Fax: 978-453-7395 Email: sales@total-power.com http://www.total-power.com -1- OUTPUT VOLTAGE / CURRENT RATINGS CHART QUAD OUTPUT MAIN +VO1 @ #=⊙ MODEL NO. Min. Typ. Volt. Max. +5V +5V 35A 35A AUX. +VO2 @▲ #=⊙ Typ. 10A 10A Volt. +3.3V +3.3V Max. 20A 20A AUX. +VO3 ▲=⊙#(@) Typ. Volt. Max. Peak AUX. -VO4 ●=⊙■ Typ. Volt Max. Peak TPDC200P-48B-490(E) 2.0A 25A TPDC200P-48B-490(O) 2.0A 25A 3.0A +12V 5.0A 6.0A 0.5A -12V 1.0A 1.0A 3.0A +12V 5.0A 6.0A 0.5A -12V 1.0A 1.0A Symbol: "★" OVP built-in. "@" Adjustable. "(@)" Adjustable factory set. "#" Remote sensing. "=" Droop Current Sharing. "⊙" Installed with Or-ing diode. "▲" Magnetic Amplifier. "●" Installed with Post Regulator. "■" Common Choke. Remark: Peak load less than 60sec. with duty cycle