TS78M00A Series
3-Terminal 500mA Positive Voltage Regulator
TO-220 TO-252 (DPAK)
Pin Definition: 1. Input 2. Ground (tab) 3. Output
General Description
The TS78M00A Series positive voltage regulators are identical to the popular TS7800A Series devices, exc ept that they are specified for only half the output current. Like the TS7800A devices, the TS78M00A Series 3- Terminal regulators are intended for local, on-card voltage regulation. Inter nal current limiting, ther mal shutdow n circuitry and safe-area compensation for the internal pass tr ansistor combine to make these devices remarkably rugged under most operating conditions. Maximum output curr ent with adequate heats ink is 500mA This series is offered in 3-pin TO-220 & TO-252 package.
Features
● ● ● ● ● ● ● Output Voltage Range 5 to 24V Output current up to 500mA No external components required Inter nal ther mal overload protec tion Inter nal short-circuit current limiting Output trans istor safe-area compensation Output voltage offered in 2% tolerance
Standard Application Circuit
Ordering Information
Part No.
TS78MxxACZ C0 TS78MxxACP RO
Package
TO-220 TO-252
Packi ng
50pc s / T ube 2.5Kpcs / 13” Reel
Note: W here xx denote voltage option
A common g round is required between the input and the output voltages. The input voltage must remain typically 2.0V above the output voltage even during the low point on the Input ripple voltage. XX = these two digits of the type number indicate voltage. * = Cin is required if regula tor is located an appreciable distance from powe r supply filte r. ** = Co is no t needed for stability; however, it does improv e transient response.
Absolute Maximum Rating (Ta = 25oC unless otherwise noted)
Parameter
Input Voltage Input Voltage Power Dissipation Operating Junction Temperature Storage Temperature Range Note: * TS78M05A to TS78M18A ** TS78M24A *** Follow the derating curve 1/10
Symbol
VIN* VIN** PD TJ TSTG
Limit
35 40 Inter nal Limited 0 ~+1 2 5 - 6 5 ~+1 5 0
Unit
V V W
o o
C C
Version: A07
TS78M00A Series
3-Terminal 500mA Positive Voltage Regulator
TS78M05A Electrical Characteristics
(Vin=10V, Iout=350mA, 0 C≤Tj≤125 C , C in=0.33uF, C out=0.1uF; unless otherwise specified.)
o o
Parameter
Output voltage Line R egulation Load R egulation Quiescent Current Quiescent Current Change Output Noise Voltage Ripple Rejec tion Ratio Voltage Drop Output Resistance Output Short Circuit C urrent Peak Output Current Temperatur e Coefficient of Output Voltage
o
Symbol
o
Test Conditi on
Tj=25 C 7.5V≤Vin≤20V, 5mA≤Iout≤350mA 7.5V≤Vin≤25V o Tj=25 C 8V≤ Vin≤12V 5mA≤Iout≤500mA o Tj=25 C 5mA≤Iout≤200mA o Iout=0, Tj=25 C 7.5V≤Vin≤25V 5mA≤Iout≤350mA o 10Hz≤f≤100KHz, Tj=25 C f=120Hz , 8V≤ Vin≤18V o Iout=500mA, Tj=25 C f=1KHz o Tj=25 C o Tj=25 C Iout= 5mA, 0 C≤Tj≤125 C
o o
Mi n
4.90 4.80 --------62 ------
Ty p
5 5 3 1 15 5 3 --40 78 2 17 50 0.7 -0.2
Max
5.10 5.20 100 50 100 50 6 0.8 0.5 --------
Unit
V
Vout REGline REGload Iq ΔIq Vn RR V dr op R ou t Ios Io peak ΔVout/ ΔTj
mV
mA µV dB V mΩ mA A mV/ C
o
TS78M06A Electrical Characteristics
(Vin=11V, Iout=350mA, 0 C≤Tj≤125 C , C in=0.33uF, C out=0.1uF; unless otherwise specified.)
o
Parameter
Output Voltage Line R egulation Load R egulation Quiescent Current Quiescent Current Change
Symbol
o
Test Conditi on
Tj=25 C 8.5V≤Vin≤21V, 5mA≤Iout≤350mA 8.5V≤Vin≤25V o Tj=25 C 9V≤ Vin≤13V 5mA≤Iout≤500mA o Tj=25 C 5mA≤Iout≤200mA o Iout=0, Tj=25 C 8.5V≤Vin≤25V 5mA≤Iout≤350mA o 10Hz≤f≤100KHz, Tj=25 C F=120Hz , 9V≤ Vin≤19V o Iout=500mA, Tj=25 C F=1KHz o Tj=25 C o Tj=25 C
Mi n
5.88 5.76 --------59 -----
Ty p
6 6 5 1.5 14 4 3 --45 80 2 19 50 0.7
Max
6.12 6.24 120 60 120 60 6 0.8 0.5 -------
Unit
V
Vout REGline REGload Iq ΔIq
mV
mA
Output Noise Voltage Vn uV Ripple Rejec tion Ratio RR dB Voltage Drop V dr op V Output Resistance R ou t mΩ Output Short Circuit C urrent Ios mA Peak Output Current Io peak A Temperatur e Coefficient of o o o ΔVout/ ΔTj Iout= 5mA, 0 C≤Tj≤125 C --0.2 -mV/ C Output Voltage Pulse testing techniques are used to maintain the junc tion temperature as close to the ambient temperature as possible, and ther mal effects must be taken into account separately. This spec ification applies only for DC power dissipation per mitted by absolute max imum ratings. 2/10 Version: A07
TS78M00A Series
3-Terminal 500mA Positive Voltage Regulator
TS78M08A Electrical Characteristics
Vin=14V, Iout=350mA, 0 C≤Tj≤125 C , C in=0.33uF, Cout=0.1uF; unless otherwise specified.)
o o
Parameter
Output voltage Line R egulation Load R egulation Quiescent Current Quiescent Current Change Output Noise Voltage Ripple Rejec tion Ratio Voltage Drop Output Resistance Output Short Circuit C urrent Peak Output Current Temperatur e Coefficient of Output Voltage
o
Symbol
o
Test Conditi on
Tj=25 C 10.5V≤ Vin≤23V, 5mA≤Iout≤350mA 10.5V≤ Vin≤25V o Tj=25 C 11V≤ Vin≤17V 5mA≤Iout≤500mA o Tj=25 C 5mA≤Iout≤200mA o Iout=0, Tj=25 C 10.5V≤ Vin≤25V 5mA≤Iout≤350mA o 10Hz≤f≤100KHz, Tj=25 C f=120Hz , 11V≤Vin≤21V o Iout=500mA, Tj=25 C f=1KHz o Tj=25 C o Tj=25 C Iout= 5mA, 0 C≤Tj≤125 C
o o
Mi n
7.84 7.68 --------56 ------
Ty p
8 8 6 2 12 4 3 --52 80 2 16 50 0.7 -0.2
Max
8.16 8.32 160 80 160 80 6 0.8 0.5 --------
Unit
V
Vout REGline REGload Iq ΔIq Vn RR V dr op R ou t Ios Io peak ΔVout/ ΔTj
mV
mA µV dB V mΩ mA A mV/ C
o
TS78M09A Electrical Characteristics
(Vin=15V, Iout=350mA, 0 C≤Tj≤125 C , C in=0.33uF, C out=0.1uF; unless otherwise specified.)
o
Parameter
Output Voltage Line R egulation Load R egulation Quiescent Current Quiescent Current Change
Symbol
o
Test Conditi on
Tj=25 C 11.5V≤ Vin≤23V, 5mA≤Iout≤350mA 11.5V≤ Vin≤26V o Tj=25 C 12V≤ Vin≤17V 5mA≤Iout≤500mA o Tj=25 C 5mA≤Iout≤200mA o Iout=0, Tj=25 C 11.5V≤ Vin≤26V 5mA≤Iout≤350mA o 10Hz≤f≤100KHz, Tj=25 C f=120Hz , 12V≤Vin≤22V o Iout=500mA, Tj=25 C f=1KHz o Tj=25 C o Tj=25 C
Mi n
8.82 8.64 --------55 -----
Ty p
9 9 6 2 12 4 3 --52 80 2 16 50 0.7
Max
9.18 9.36 180 90 180 90 6 0.8 0.5 -------
Unit
V
Vout REGline REGload Iq ΔIq
mV
mA
Output Noise Voltage Vn uV Ripple Rejec tion Ratio RR dB Voltage Drop V dr op V Output Resistance R ou t mΩ Output Short Circuit C urrent Ios mA Peak Output Current Io peak A Temperatur e Coefficient of o o o ΔVout/ ΔTj Iout= 5mA, 0 C≤Tj≤125 C --0.2 -mV/ C Output Voltage Pulse testing techniques are used to maintain the junc tion temperature as close to the ambient temperature as possible, and ther mal effects must be taken into account separately. This spec ification applies only for DC power dissipation per mitted by absolute max imum ratings. 3/10 Version: A07
TS78M00A Series
3-Terminal 500mA Positive Voltage Regulator
TS78M12A Electrical Characteristics
(Vin=19V, Iout=350mA, 0 C≤Tj≤125 C , C in=0.33uF, C out=0.1uF; unless otherwise specified.)
o o
Parameter
Output Voltage Line R egulation Load R egulation Quiescent Current Quiescent Current Change Output Noise Voltage Ripple Rejec tion Ratio Voltage Drop Output Resistance Output Short Circuit C urrent Peak Output Current Temperatur e Coefficient of Output Voltage
o
Symbol
o
Test Conditi on
Tj=25 C 14.5V≤ Vin≤27V, 5mA≤Iout≤350mA 14.5V≤ Vin≤30V o Tj=25 C 15V≤ Vin≤19V 5mA≤Iout≤500mA o Tj=25 C 5mA≤Iout≤200mA o Tj=25 C , Iout=0 14.5V≤ Vin≤30V 5mA≤Iout≤500mA o 10Hz≤f≤100KHz, Tj=25 C f=120Hz , 15V≤Vin≤25V o Iout=500mA, Tj=25 C f=1KHz o Tj=25 C o Tj=25 C Iout=5mA, 0 C≤Tj≤125 C
o o
Mi n
11.76 11.52 --------55 ------
Ty p
12 12 10 3 12 4 3 --75 80 2 18 50 0.7 -0.3
Max
12.24 12.48 240 120 240 120 6 0.8 0.5 --------
Unit
V
Vout REGline REGload Iq ΔIq Vn RR V dr op R ou t Ios Io peak ΔVout/ ΔTj
mV
mA uV dB V mΩ mA A mV/ C
o
TS78M15A Electrical Characteristics
(Vin=23V, Iout=350mA, 0 C≤Tj≤125 C , C in=0.33uF, C out=0.1uF; unless otherwise specified.)
o
Parameter
Output voltage Line R egulation Load R egulation Quiescent Current Quiescent Current Change
Symbol
o
Test Conditi on
Tj=25 C 17.5V≤ Vin≤30V, 5mA≤Iout≤350mA 17.5V≤ Vin≤30V o Tj=25 C 18V≤ Vin≤22V 5mA≤Iout≤500mA o Tj=25 C 5mA≤Iout≤200mA o Tj=25 C , Iout=0 17.5V≤ Vin≤30V 5mA≤Iout≤500mA o 10Hz≤f≤100KHz, Tj=25 C f=120Hz , 18V≤Vin≤28V o Iout=500mA, Tj=25 C f=1KHz o Tj=25 C o Tj=25 C
Mi n
14.70 14.40 --------54 -----
Ty p
15 15 12 3 12 4 3 --90 80 2 19 50 0.7
Max
15.30 15.60 300 150 300 150 6 0.8 0.5 -------
Unit
V
Vout REGline REGload Iq ΔIq
mV
mA
Output Noise Voltage Vn µV Ripple Rejec tion Ratio RR dB Voltage Drop V dr op V Output Resistance R ou t mΩ Output Short Circuit C urrent Ios mA Peak Output Current Io peak A Temperatur e Coefficient of o o o ΔVout/ ΔTj Iout=10mA, 0 C≤Tj≤125 C --0.3 -mV/ C Output Voltage Pulse testing techniques are used to maintain the junc tion temperature as close to the ambient temperature as possible, and ther mal effects must be taken into account separately. This spec ification applies only for DC power dissipation per mitted by absolute max imum ratings.
4/10
Version: A07
TS78M00A Series
3-Terminal 500mA Positive Voltage Regulator
TS78M18A Electrical Characteristics
(Vin=24V, Iout=350mA, 0 C≤Tj≤125 C , C in=0.33uF, C out=0.1uF; unless otherwise specified.)
o o
Parameter
Output Voltage Line R egulation Load R egulation Quiescent Current Quiescent Current Change Output Noise Voltage Ripple Rejec tion Ratio Voltage Drop Output Resistance Output Short Circuit C urrent Peak Output Current Temperatur e Coefficient of Output Voltage
o
Symbol
o
Test Conditi on
Tj=25 C 21V≤ Vin≤33V, 5mA≤Iout≤350mA 21V≤ Vin≤33V o Tj=25 C 22V≤ Vin≤26V 5mA≤Iout≤500mA o Tj=25 C 5mA≤Iout≤200mA o Tj=25 C , Iout=0 21V≤ Vin≤33V 5mA≤Iout≤500mA o 10Hz≤f≤100KHz, Tj=25 C f=120Hz , 21V≤Vin≤31V o Iout=500mA, Tj=25 C f=1KHz o Tj=25 C o Tj=25 C Iout= 5mA, 0 C≤Tj≤125 C
o o
Mi n
17.64 17.28 --------54 ------
Ty p
18 18 15 5 12 4 3 --110 80 2 22 50 0.7 -0.5
Max
18.36 18.72 360 180 360 180 6 0.8 0.5 --------
Unit
V
Vout REGline REGload Iq ΔIq Vn RR V dr op R ou t Ios Io peak ΔVout/ ΔTj
mV
mA uV dB V mΩ mA A mV/ C
o
TS78M24A Electrical Characteristics
Vin=33V, Iout=350mA, 0 C≤Tj≤125 C , C in=0.33uF, Cout=0.1uF; unless otherwise specified.)
o
Parameter
Output voltage Line R egulation Load R egulation Quiescent Current Quiescent Current Change
Symbol
o
Test Conditi on
Tj=25 C 27V≤ Vin≤38V, 5mA≤Iout≤350mA 27V≤ Vin≤38V o Tj=25 C 28V≤ Vin≤32V 5mA≤Iout≤500mA o Tj=25 C 5mA≤Iout≤200mA o Iout=0, Tj=25 C 27V≤ Vin≤38V 5mA≤Iout≤500mA o 10Hz≤f≤100KHz, Tj=25 C f=120Hz , 27V≤Vin≤37V o Iout=500mA, Tj=25 C f=1KHz o Tj=25 C o Tj=25 C
Mi n
23.52 23.07 --------54 -----
Ty p
24 24 18 6 12 4 3 --170 80 2 28 50 0.7
Max
24.48 25.96 480 240 480 240 6 0.8 0.5 -------
Unit
V
Vout REGline REGload Iq ΔIq
mV
mA
Output Noise Voltage Vn µV Ripple Rejec tion Ratio RR dB Voltage Drop V dr op V Output Resistance R ou t mΩ Output Short Circuit C urrent Ios mA Peak Output Current Io peak A Temperatur e Coefficient of o o o ΔVout/ ΔTj Iout= 5mA, 0 C≤Tj≤125 C --0.5 -mV/ C Output Voltage Pulse testing techniques are used to maintain the junc tion temperature as close to the ambient temperature as possible, and ther mal effects must be taken into account separately. This spec ification applies only for DC power dissipation per mitted by absolute max imum ratings.
5/10
Version: A07
TS78M00A Series
3-Terminal 500mA Positive Voltage Regulator
Electrical Characteristics Curve
Fi gure 1. Worst Case Power Dissipati on vs. Ambient Temperatur e (TO-220)
Fi gure 3. Ri pple Rejecti on vs. Frequency
Fi gure 3. Bias Current vs. I nput Voltage
Fi gure 4. Dr opout Voltage vs. Juncti on Temper ature
Fi gure 5. Bias Current vs. Output Current
6/10
Version: A07
TS78M00A Series
3-Terminal 500mA Positive Voltage Regulator
Application information
Figure 7. D PAK Thermal Resistance and Maximum Power Dissipat ion vs. P.C .B C opper Lengt h
7/10
Version: A07
TS78M00A Series
3-Terminal 500mA Positive Voltage Regulator
TO-220 Mechanical Drawing
DIM A B C D E F G H I J K L M N O P
TO-220 DIMEN SION MILLIMETER S INCH ES MIN MAX MIN MAX 10.000 10.500 0.394 0.413
3.740 3.910 0.147 0.154
2.440 0.381 2.345 4.690 12.700 8.382 14.224 3.556 0.508 27.700 2.032 0.255 5.842
2.940 6.350 1.106 2.715 5.430 14.732 9.017 16.510 4.826 1.397 29.620 2.921 0.610 6.858
0.096 0.015 0.092 0.092 0.500 0.330 0.560 0.140 0.020 1.060 0.080 0.010 0.230
0.116 0.250 0.040 0.058 0.107 0.581 0.355 0.650 0.190 0.055 1.230 0.115 0.024 0.270
Marking Diagram
XX Y M = Output Voltage (05=5V, 08=8V, 09=9V, 12=12V, 15=15V, 18=18V, 24=24V) = Year Code = Month C ode (A=Jan, B =Feb, C=Mar, D=Apl, E=May, F=Jun, G=Jul, H=Aug, I=Sep, J=Oc t, K=Nov , L=Dec) = Lo t C ode = Package Code for TO-220
L CZ
8/10
Version: A07
TS78M00A Series
3-Terminal 500mA Positive Voltage Regulator
TO-252 Mechanical Drawing
TO-252 DIMENS ION DIM A A1 B C D E F G G1 G2 H I J K L M MILLIMETERS MIN MA X 2.3BSC 4.6BSC 6.80 5.40 6.40 2.20 0.00 5.20 0.75 0.55 0.35 0.90 2.20 0.50 0.90 1.30 7.20 5.60 6.65 2.40 0.20 5.40 0.85 0.65 0.65 1.50 2.80 1.10 1.50 1.70 INCHES MIN MA X 0.09BSC 0.18BSC 0.268 0.213 0.252 0.087 0.000 0.205 0.030 0.022 0.014 0.035 0.087 0.020 0.035 0.051 0.283 0.220 0.262 0.094 0.008 0.213 0.033 0.026 0.026 0.059 0.110 0.043 0.059 0.67
Marking Diagram
XX Y M = Output Voltage (05=5V, 08=8V, 09=9V, 12=12V, 15=15V, 18=18V, 24=24V) = Year Code = Month C ode (A=Jan, B =Feb, C=Mar, D=Apl, E=May, F=Jun, G=Jul, H=Aug, I=Sep, J=Oc t, K=Nov , L=Dec) = Lo t C ode = Package Code for TO-252
L CP
9/10
Version: A07
TS78M00A Series
3-Terminal 500mA Positive Voltage Regulator
Notice
Specifications of the produc ts displayed herein are s ubject to change without notice. TSC or anyone on its behalf, assumes no responsibility or liability for any errors or inaccuracies. Infor mation contained herein is intended to pr ovide a product description only. N o license, express or implied, to any intellectual proper ty rights is granted by this document. Except as provided in TSC’s terms and conditions of sale for such products , TSC assumes no liability whatsoever, and disclaims any express or implied warranty, relating to sale and/or use of TSC products including liability or warranties relating to fitness for a par ticular purpose, merchantability, or infringement of any patent, copyright, or other intellectual proper ty right. The products shown herein are not designed for use in medical, life-saving, or life-sus taining applications . C ustomers using or selling these products for use in such applications do so at their own risk and agree to fully indemnify TSC for any damages resulting from such improper use or sale.
10/10
Version: A07