2INCH-G-MV-MINI

MiniatureLowPressureSensors Low Pressure (1” H2O to 30 “ H2O) Sensors Features • 0 to 1” H2O to 0 to 30” H2O Pressure Ranges • Matched pressure port volumes • Temperature Compensated • Calibrated Zero and Span all sensors Applications • Medical Instrumentation • Environmental Controls • HVAC stability to warm-up, stability to long time period, and position sensitivity are all significantly reduced when compared to conventional compensation methods. In addition the sensor utilizes a silicon, micromachined, stress concentration enhanced structure to provide a very linear output to measured pressure. These calibrated and temperature compensated sensors give an accurate and stable output over a wide temperature range. This series is intended for use with non-corrosive, non-ionic working fluids such as air, dry gases and the like. The output of the device is ratiometric to the supply voltage and operation from any D.C. supply voltage up to +16 V is acceptable. Equivalent Circuit +Vsupply 3 Input Resittance 4.5 k ohm Output Resistance 1.5 k ohm -Voutput 4 + Voutput 2 -Vsupply 1 All Sensors DS-0108 Rev A f 408 225 2079 model provides a calibrated millivolt output with superior output offset characteristics. Output offset errors due to change in temperature, a 16035 Vineyard Blvd. Morgan Hill, CA 95037 p 408 225 4314 The Millivolt Output pressure sensors is based upon a proprietary technology to reduce all output offset or common mode errors. This e www.allsensors.com General Description Pressure Sensor Characteristics Maximum Ratings Environmental Specifications Supply Voltage, Vs 16 Vdc Temperature Ranges Common-mode pressure 10 psig Compensated 250°C Lead Temperature (soldering 2-4 sec.) 0 to 50(70)° C Operating Standard Pressure Ranges -25 to 85° C Storage -40 to 125° C Humidity Limits 0 to 95% RH (non condensing) Single in Line Packages-SIP One Port Part Number Operating Pressure Two Ports Same Side Two Ports Opposite Side Part Number Part Number 0 - 1 “H2O 1 INCH-D2-MV-MINI 2 INCH-G-MV-MINI 0 - 2 “H2O 2 INCH-D1-MV-MINI 2 INCH-D2-MV-MINI 5 INCH-G-MV-MINI 0 - 5 “H2O 5 INCH-D1-MV-MINI 5 INCH-D2-MV-MINI 10 INCH-G-MV-MINI 0 - 10 “H2O 10 INCH-D1-MV-MINI 10 INCH-D2-MV-MINI 20 INCH-G-MV-MINI 0 - 20 “H2O 20 INCH-D1-MV-MINI 20 INCH-D2-MV-MINI 30 INCH-G-MV-MINI 0 - 30 “H2O 30 INCH-D1-MV-MINI 30 INCH-D2-MV-MINI Dual in Line Packages Two Ports Same Side Two Ports Opposite Side Operating Pressure Part Number Part Number 2 INCH-GDIP-MV-MINI 0 - 2 “H2O 2 INCH-D1DIP-MV-MINI 2 INCH-D2DIP-MV-MINI 5 INCH-GDIP-MV-MINI 0 - 5 “H2O 5 INCH-D1DIP-MV-MINI 5 INCH-D2DIP-MV-MINI 10 INCH-GDIP-MV-MINI 0 - 10 “H2O 10 INCH-D1DIP-MV-MINI 10 INCH-D2DIP-MV-MINI 20 INCH-GDIP-MV-MINI 0 - 20 “H2O 20 INCH-D1DIP-MV-MINI 20 INCH-D2DIP-MV-MINI 30 INCH-GDIP-MV-MINI 0 - 30 “H2O 30 INCH-D1DIP-MV-MINI 30 INCH-D2DIP-MV-MINI One Port Part Number Performance Characteristics for 1 INCH-D2-MV-MINI Parameter, note 1 Minimum Operating Range, differential pressure Output Span, @ 1 “H2O, note 5 Nominal Maximum 1.0 8.0 10 Units “H2O 12.0 mV Offset Voltage @ zero differential pressure ±500 mV Offset Temperature Shift (0°C-50°C), note 2 ±250 uV Offset Warm-up Shift, note 3 ±100 uV Offset Position Sensitivity (1g) ±50 uV ±200 uV 0.25 %fs ±300 uV Offset Long Term Drift (one year) Linearity, hysteresis error, note 4 Span Shift (0°C-50°C), @ 1 “H2O, note 2 0.05 MiniatureLowPressureSensors Performance Characteristics for 2 INCH-Dx-MV-MINI 2.0 9.0 Operating Range, differential pressure Output Span, @ 4 “H2O, note 5 10.0 “H2O 11.0 4.0 18.0 20.0 Units mV mV 22.0 mV Offset Voltage @ zero differential pressure ±500 uV Offset Temperature Shift (0°C-50°C), note 2 ±250 uV Offset Warm-up Shift, note 3 ±100 uV Offset Position Sensitivity (1g) ±50 uV ±200 uV 0.25 %fs ±200 uV Maximum Units Offset Long Term Drift (one year) Linearity, hysteresis error, note 4 0.05 Span Shift (0°C-50°C), @ 2 “H2O, note 2 Performance Characteristics for 5 INCH-Dx-MV-MINI Parameter, note 1 Minimum Operating Range, differential pressure Output Span, note 5 Nominal 5.0 21.0 mV Offset Voltage @ zero differential pressure ±500 uV Offset Temperature Shift (0°C-50°C), note 2 ±150 uV Offset Warm-up Shift, note 3 ±50 uV Offset Position Sensitivity (1g) ±10 uV ±100 uV 0.25 %fs ±200 uV Maximum Units 19.0 20.0 “H2O Offset Long Term Drift (one year) Linearity, hysteresis error, note 4 0.05 Span Shift (0°C-50°C), note 2 Performance Characteristics for 10 INCH-Dx-MV-MINI Parameter, note 1 Minimum Operating Range, differential pressure Nominal 10.0 “H2O 21.0 mV Offset Voltage @ zero differential pressure ±500 uV Offset Temperature Shift (0°C-70°C), note 2 ±150 uV Offset Warm-up Shift, note 3 ±50 uV Offset Position Sensitivity (1g) ±5 uV ±100 uV 0.25 %fs ±200 uV Output Span, note 5 19.0 20.0 Offset Long Term Drift (one year) Linearity, hysteresis error, note 4 0.05 Span Shift (0°C-70°C), note 2 All Sensors DS-0108 Rev A all sensors Output Span, @ 2 “H2O, note 5 Maximum e www.allsensors.com Operating Range, differential pressure Nominal f 408 225 2079 Minimum a 16035 Vineyard Blvd. Morgan Hill, CA 95037 p 408 225 4314 Parameter, note 1 Performance Characteristics for 20 INCH-Dx-MV-MINI Parameter, note 1 Minimum Operating Range, differential pressure Nominal Maximum 5.0 Units “H2O 21.0 mV Offset Voltage @ zero differential pressure ±500 uV Offset Temperature Shift (0°C-70°C), note 2 ±150 uV Offset Warm-up Shift, note 3 ±50 uV Offset Position Sensitivity (1g) ±5 uV ±100 uV 0.25 %fs ±200 uV Maximum Units Output Span, note 5 19.0 20.0 Offset Long Term Drift (one year) Linearity, hysteresis error, note 4 0.05 Span Shift (0°C-70°C), note 2 Performance Characteristics for 30 INCH-Dx-MV-MINI Parameter, note 1 Minimum Operating Range, differential pressure Output Span, note 5 Nominal 30.0 “H2O 21.0 mV Offset Voltage @ zero differential pressure ±500 uV Offset Temperature Shift (0°C-70°C), note 2 ±150 uV Offset Warm-up Shift, note 3 ±50 uV Offset Position Sensitivity (1g) ±5 uV ±100 uV 0.25 %fs ±200 uV 19.0 20.0 Offset Long Term Drift (one year) Linearity, hysteresis error, note 4 0.05 Span Shift (0°C-70°C), note 2 Specification Notes NOTE 1: ALL PARAMETERS ARE MEASURED AT 12.0 VOLT EXCITATION, FOR THE NOMINAL FULL SCALE PRESSURE AND ROOM TEMPERATURE UNLESS PRESSURE MEASUREMENTS ARE WITH POSITIVE PRESSURE APPLIED TO THE B-PORT CONFIGURATION. SHIFT IS RELATIVE TO 25°C. SHIFT IS WITHIN THE FIRST HOUR OF EXCITATION APPLIED TO THE DEVICE. MEASURED AT ONE-HALF FULL SCALE RATED PRESSURE USING BEST STRAIGHT LINE CURVE FIT. THE VOLTAGE ADDED TO THE OFFSET VOLTAGE AT FULL SCALE PRESSURE. OTHERWISE SPECIFIED. 2: 3: NOTE 4: NOTE 5: NOTE NOTE MiniatureLowPressureSensors Physical Dimensions Dual in Line (SDXL)** Two Pressure Port Same Side all sensors pin pin pin pin 1: +Vout 2: gnd 3: -Vout 5: Vsupply 0.280 (7.1) 0.50 (12.7) 6 5 4 0.62 (15.7) 0.10 Typical (2.54) 0.080 O.D. (2.00) Dual in Line (DIP) **SDXL ORDERING INFORMATION Two Ports Same Side Two Ports Opposite Side Operating Pressure Part Number Part Number 2 INCH-GDIP-MV-SDXL 0 - 2 “H2O 2 INCH-D1DIP-MV-SDXL 2 INCH-D2DIP-MV-SDXL 5 INCH-GDIP-MV-SDXL 0 - 5 “H2O 5 INCH-D1DIP-MV-SDXL 5 INCH-D2DIP-MV-SDXL 10 INCH-GDIP-MV-SDXL 0 - 10 “H2O 10 INCH-D1DIP-MV-SDXL 10 INCH-D2DIP-MV-SDXL 20 INCH-GDIP-MV-SDXL 0 - 20 “H2O 20 INCH-D1DIP-MV-SDXL 20 INCH-D2DIP-MV-SDXL 30 INCH-GDIP-MV-SDXL 0 - 30 “H2O 30 INCH-D1DIP-MV-SDXL 30 INCH-D2DIP-MV-SDXL One Port Part Number All Sensors DS-0108 Rev A a 16035 Vineyard Blvd. Morgan Hill, CA 95037 p 408 225 4314 f 408 225 2079 Two Pressure Port Two Sides e www.allsensors.com Pin 1 2 3