ELM452(TA)-V

5 PIN SOP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER ELM45X series Schematic ELM45X series Features • High speed 1Mbit/s • High isolation voltage between input and output (Viso=3750 Vrms ) • High CMR 15KV/us at VCM=1500V (ELM453) • Guaranteed performance from 0°C to 70°C • Wide operating temperature range of -40°C to 85°C • Pb free and RoHS and Halogen free compliant • cUL approved (No. E214129) • VDE approved (No. 40028116) • SEMKO approved • NEMKO approved • DEMKO approved • FIMKO approved Pin Configuration 1. Anode 3. Cathode 4. Gnd 5. Vout 6. VCC Description The ELM452 and ELM453 devices each consist of an infrared emitting diode, optically coupled to a high speed photo detector transistor. A separate connection for the photodiode bias and output-transistor collector increase the speed by several orders of magnitude over conventional phototransistor couplers by reducing the base-collector capacitance of the input transistor.The devices are packaged in industry standard 5pin SOP packages and are suitable for surface mounting. Applications • Line receivers • Field bus communication and control. • Power transistor isolation in motor drives • Replacement for low speed phototransistor photo couplers • High speed logic ground isolation • Analog signal ground isolation 1 Copyright © 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No: DPC-0000113 Rev.3 www.everlight.com DATASHEET 5 PIN SOP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER ELM45X series Absolute Maximum Ratings (Ta=25°C unless otherwise noted) Parameter Symbol Rating Unit IF 25 mA IFP 50 mA IFtrans 1 A Reverse voltage VR 5 V Power dissipation PIN 45 mW Power dissipation PO 100 mW Average Output current IO(AVG) 8 mA Peak Output current IO(PK) 16 mA Output voltage VO -0.5 to 20 V Supply voltage VCC -0.5 to 30 V VISO 3750 V rms Operating temperature TOPR -40 ~ +85 °C Storage temperature TSTG -55 ~ +125 °C TSOL 260 °C Forward current Input Output Peak forward current (50% duty, 1ms P.W) Peak transient current (≤1μs P.W,300pps) Isolation voltage *1 Soldering temperature *2 Notes: *1 AC for 1 minute, R.H.= 40 ~ 60% R.H. In this test, pins 1 & 3 are shorted together, and pins 4, 5 & 6 are shorted together. *2 For 10 seconds. 2 Copyright © 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000113 Rev.3 www.everlight.com DATASHEET 5 PIN SOP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER ELM45X series Electrical Characteristics (TA=0 to 70°C unless specified otherwise) Input Symbol Min. Typ. Max. Unit Condition Forward Voltage VF - 1.45 1.8 V IF = 16mA Reverse Voltage VR 5.0 - - V IR = 10μA VF/TA - -1.6 - mV/°C IF =16mA Symbol Min Typ. Max. Unit Condition - 0.001 0.5 µA - 0.001 1 - - 50 IF=0mA, VO=VCC=5.5V, TA=25°C IF=0mA, VO=VCC=15V, TA=25°C IF=0mA, VO=VCC=15V - 100 200 µA IF=16mA, VO=Open, VCC=15V - 0.05 1 µA - - 2 IF=0mA, VO=Open, VCC=15V, TA=25°C IF=0mA, VO=Open, VCC=15V Min Typ. Max. Unit Condition 20 - 50 15 - - - - 0.4 - - 0.5 Parameter Temperature coefficient of forward voltage Output Parameter Logic High Output Current Logic Low Supply Current Logic High Supply Current IOH ICCL ICCH Transfer Characteristics Parameter Current Transfer Ratio Logic Low Output Voltage 3 Symbol CTR % V VOL IF = 16mA ,VO = 0.4V, VCC=4.5V, TA=25°C IF = 16mA ,VO = 0.5V, VCC=4.5V IF = 16mA ,IO = 3mA, VCC=4.5V, TA=25°C IF = 16mA ,IO = 2.4mA, VCC=4.5V Copyright © 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000113 Rev.3 www.everlight.com DATASHEET 5 PIN SOP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER ELM45X series Switching Characteristics (TA=0 to 70°C unless specified otherwise, Vcc=5V) Parameter Symbol Propagation Delay Time (*3) to Logic Low (Fig.8) Propagation Delay Time to Logic High (*3) (Fig.8) Common Mode Transient Immunity at Logic (*4) High (Fig.9) Common Mode Transient Immunity at Logic Low (Fig.9)*3 Min Typ. Max. - 0.4 0.8 - - 1.0 IF=16mA, RL=1.9KΩ - 0.35 0.8 IF=16mA, RL=1.9KΩ, TA=25°C - - 1.0 IF=16mA, RL=1.9KΩ 5,000 - - IF = 0mA , VCM=10Vp-p, RL=1.9KΩ, TA =25°C TPHL Condition µs IF=16mA, RL=1.9KΩ, TA=25°C µs TPLH ELM452 Unit V/µs CMH ELM453 15,000 - - IF = 0mA , VCM=1500Vp-p, RL=1.9KΩ, TA =25°C ELM452 5,000 - - IF = 16mA , VCM=10Vp-p, RL=1.9KΩ, TA =25°C V/µs CML ELM453 15,000 - - IF = 16mA , VCM=1500Vp-p, RL=1.9KΩ, TA=25°C * Typical values at TA = 25°C 4 Copyright © 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000113 Rev.3 www.everlight.com DATASHEET 5 PIN SOP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER ELM45X series Typical Electro-Optical Characteristics Curves 5 Copyright © 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000113 Rev.3 www.everlight.com DATASHEET 5 PIN SOP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER ELM45X series Figure 9 Switching Time Test Circuit & Waveform Figure 10 Transient Immunity Test Circuit & Waveform Note: *3 Common mode transient immunity in logic high level is the maximum tolerable (positive) dVcm/dt on the leading edge of the common mode pulse signal VCM, to assure that the output will remain in a logic high state (i.e., VO > 2.0V). Common mode transient immunity in logic low level is the maximum tolerable (negative) dVcm/dt on the trailing edge of the common mode pulse signal, VCM, to assure that the output will remain in a logic low state (i.e., VO < 0.8V). 6 Copyright © 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000113 Rev.3 www.everlight.com DATASHEET 5 PIN SOP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER ELM45X series Order Information Part Number ELM45X(Z)-V Note X Z V = Part No. (2 or 3) = Tape and reel option (TA, TB or none) = VDE (optional) Option 7 Description Packing quantity None Standard 100 units per tube -V Standard + VDE 100 units per tube (TA) TA tape & reel option 3000 units per reel (TB) TB tape & reel option 3000 units per reel (TA)-V TA tape & reel option + VDE 3000 units per reel (TB)-V TB tape & reel option + VDE 3000 units per reel Copyright © 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000113 Rev.3 www.everlight.com DATASHEET 5 PIN SOP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER ELM45X series Package Dimension (Dimensions in mm) Recommended pad layout for surface mount leadform 8 Copyright © 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000113 Rev.3 www.everlight.com DATASHEET 5 PIN SOP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER ELM45X series Device Marking EL M453 YWWV Notes EL M453 Y WW V 9 denotes EVERLIGHT denotes Device Number denotes 1 digit Year code denotes 2 digit Week code denotes VDE (optional) Copyright © 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000113 Rev.3 www.everlight.com DATASHEET 5 PIN SOP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER ELM45X series Tape & Reel Packing Specifications Option TA Option TB Direction of feed from reel Direction of feed from reel Tape dimensions 10 Dimension No. A0 A1 B0 D0 D1 E F Dimension(mm) 6.2±0.1 4.1±0.1 5.28±0.1 1.5±0.1 1.5±0.3 1.75±0.1 5.5±0.1 Dimension No. Po P1 P2 t W K0 K1 Dimension(mm) 4.0±0.1 8.0±0.1 2.0±0.1 0.4±0.1 3.7±0.1 0.3±0.1 12.0+0.3/ -0.1 Copyright © 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000113 Rev.3 www.everlight.com DATASHEET 5 PIN SOP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER ELM45X series Precautions for Use 1. Soldering Condition 1.1 (A) Maximum Body Case Temperature Profile for evaluation of Reflow Profile Note: Reference: IPC/JEDEC J-STD-020D Preheat Temperature min (Tsmin) 150 °C Temperature max (Tsmax) 200°C Time (Tsmin to Tsmax) (ts) Average ramp-up rate (Tsmax to Tp) 60-120 seconds 3 °C/second max Other Liquidus Temperature (TL) 217 °C Time above Liquidus Temperature (t L) 60-100 sec Peak Temperature (TP) 260°C Time within 5 °C of Actual Peak Temperature: T P - 5°C 30 s Ramp- Down Rate from Peak Temperature 6°C /second max. Time 25°C to peak temperature Reflow times 8 minutes max. 3 times 11 Copyright © 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000113 Rev.3 www.everlight.com DATASHEET 5 PIN SOP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER ELM45X series DISCLAIMER 1. Above specification may be changed without notice. EVERLIGHT will reserve authority on material change for above specification. 2. When using this product, please observe the absolute maximum ratings and the instructions for using outlined in these specification sheets. EVERLIGHT assumes no responsibility for any damage resulting from use of the product which does not comply with the absolute maximum ratings and the instructions included in these specification sheets. 3. These specification sheets include materials protected under copyright of EVERLIGHT corporation. Please don’t reproduce or cause anyone to reproduce them without EVERLIGHT’s consent. 12 Copyright © 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000113 Rev.3 www.everlight.com