VLA553-02R

VLA553-01R / -02R Powerex, Inc., 173 Pavilion Lane, Youngwood, Pennsylvania 15697 (724) 925-7272 www.pwrx.com REGULATOR VD DC-AC CONVERTER IGBT Gate Driver + DC/DC Converter + + GND C1 DETECT LATCH IN1+ 120 COLLECTOR CLAMP 1k G1 AMP 120 TIMER IN1– FO1 E1 SHUTDOWN F.O. Description: VLA553-01R / -02R is a hybrid integrated circuit designed for driving IGBT modules in the new Mega Power Dual package. GND REGULATOR DC-AC CONVERTER + + C2 DETECT LATCH IN2+ 120 1k G2 AMP IN2– FO2 GND Circuit Diagram 120 COLLECTOR CLAMP TIMER SHUTDOWN F.O. E2 Features: £ Directly Mountable on the New MPD £ Built in Isolated DC-DC Converter for Gate Drive £ Output Peak Current is ±24A (max) £ Built in Short Circuit Protection with Soft Shutdown £ Built in Collector Clamp Circuit £ Electrical Isolation Voltage 4000 Vrms (for 1 Minute) £ CMOS Compatible Input Interface Applications: £ Gate Driver for 1200V and 1700V New Mega Power Dual IGBT Modules Recommended IGBT Modules: CM2500DY-24S – VLA553-01R CM1800DY-34S – VLA553-02R 04/14 Rev. 0 1 Powerex, Inc., 173 Pavilion Lane, Youngwood, Pennsylvania 15697 (724) 925-7272 www.pwrx.com VLA553-01R / -02R IGBT Gate Driver + DC/DC Converter Absolute Maximum Ratings, Ta = 25°C unless otherwise specified Characteristics Symbol Rating Units Supply Voltage (DC) Input Signal Voltage (Applied Between IN+ and IN-, 50% Duty Cycle, Pulse Width 1ms) Output Peak Current (Pulse Width 3μs) VD -1 ~ 16.5 Volts VI -7 ~ +7 Volts IOHP -24 Amperes IOLP 24 Amperes Isolation Voltage (Sine Wave Voltage 60Hz, for 1 min.) Viso 4000 Vrms Operating Temperature (No Condensation Allowable) Topr -25 ~ 70 °C Storage Temperature (No Condensation Allowable) Tstg -40 ~ 85 °C Gate Drive Current, Gate Average Current (Per One Circuit) Idrive 210 mA Main Circuit Voltage (Voltage Between P and N) VDC_Link 840 (-01R) Volts VDC_Link 1200 (-02R) Volts Electrical Characteristics, Ta = 25°C, VD = 15V, f = 3kHz unless otherwise specified Characteristics Symbol Test Conditions Min. Typ. Max. Units Supply Voltage VD Recommended Range 14.2 15 15.8 Volts Pull-up Voltage on Input Side VIN Recommended Range (For Input Signal) 4.75 5 5.25 Volts "H" Input Signal Current IIH Recommended Range 10 12 16 mA f Recommended Range — — 5 kHz Gate Resistance RG Recommended Range Plus Bias Output Voltage VOH Switching Frequency 0 — — Ω 14 15.3 16.5 Volts -5.5 -7 -11 Volts 0.3 — 1 μs Minus Bias Output Voltage VOL "L-H" Propagation Time tPLH "H-L" Propagation Time tPHL IIH = 12mA 0.3 — 1 μs Clamp Zener Voltage VZ*1 Total Zener Voltage in Collector 901 950 (-01R) 999 Volts 1284 1350 (-02R) 1419 Volts SC Detect Voltage VSC IIH = 12mA Clamp Circuit at IZ = 1mA, Tj = 25 °C 15 — — Volts *1 It depends on the condition of use, however actual clamp voltage of collector rises by 300V from 200V to VZ. 2 04/14 Rev. 0 Powerex, Inc., 173 Pavilion Lane, Youngwood, Pennsylvania 15697 (724) 925-7272 www.pwrx.com VLA553-01R / -02R IGBT Gate Driver + DC/DC Converter Application Example 1 HIC1 D1 30 26 2 COLLECTOR CLAMP CIRCUIT 23 RG 24 VIN 5V INPUT SIGNAL 2 INPUT SIGNAL 1 HC04 ETC. 5V 4.7k FAULT OUTPUT 2 1 VD 2 GND 3 IN2+ 4 IN1+ 5 IN2- 6 IN1- 3 4 6 20 7 FO2 22 8 FO1 29 9 GND 10 GND + C2 DZ1 C7 PC1 R1 4.7k 2 PC1 D3 28 1 RC FILTER ~10μs + C1 21 7 RC FILTER ~10μs FAULT OUTPUT 1 DZ3 25 PC2 HIC2 R2 D2 30 26 COLLECTOR CLAMP CIRCUIT 23 RG 24 3 DZ4 4 25 6 20 + C3 D4 + C4 21 7 CM2500DY-24S VD 15V DZ2 22 29 C8 PC2 VLA533 04/14 Rev. 0 28 R3 R4 3 Powerex, Inc., 173 Pavilion Lane, Youngwood, Pennsylvania 15697 (724) 925-7272 www.pwrx.com VLA553-01R / -02R IGBT Gate Driver + DC/DC Converter VCC, | VEE | -Ta CHARACTERISTICS (TYPICAL) VCC, | VEE | -IO CHARACTERISTICS (TYPICAL) 24 18 16 14 12 16 14 12 10 8 8 6 1.6 PROPAGATION DELAY TIME “L-H”, tPLH, (μs) PROPAGATION DELAY TIME “H-L”, tPHL, (μs) 18 10 6 -20 1.4 1.2 1.0 0 20 40 60 0 0.05 0.10 0.15 0.20 AMBIENT TEMPERATURE, Ta, (°C) LOAD CURRENT, IO, (AMPERES) (PIN: 19-21, 22) tPLH, tPHL-Ta CHARACTERISTICS (TYPICAL) tPLH, tPHL-VI CHARACTERISTICS (TYPICAL) 1.6 VD = 15V VIN = 5V RG = 1Ω Ta = 25°C LOAD C = 1.6μF 0.6 0.4 0.2 4 80 0.8 0 -20 tPLH tPHL 0 20 40 60 AMBIENT TEMPERATURE, Ta, (°C) 4 20 PROPAGATION DELAY TIME “L-H”, tPLH, (μs) PROPAGATION DELAY TIME “H-L”, tPHL, (μs) VCC, | VEE |, (VOLTS) 20 Ta = 25°C, DC LOAD VD = 15.8V VD = 15V VD = 14.2V 22 VCC, | VEE |, (VOLTS) 22 24 VCC | VEE | VD = 15V RG = 1Ω f = 3kHz D.F. = 50% 80 1.4 1.2 0.25 VD = 15V RG = 1Ω Ta = 25°C LOAD C = 1.6μF 1.0 0.8 0.6 0.4 0.2 0 3.5 tPLH tPHL 4.0 4.5 5.0 5.5 6.0 INPUT SIGNAL VOLTAGE, VI, (VOLTS) 04/14 Rev. 0 Powerex, Inc., 173 Pavilion Lane, Youngwood, Pennsylvania 15697 (724) 925-7272 www.pwrx.com VLA553-01R / -02R IGBT Gate Driver + DC/DC Converter ttrip-Ta CHARACTERISTICS (TYPICAL) 6.0 CONTROLLED TIME DETECT SHORT CIRCUIT, ttrip, (μs) 5.0 4.5 4.0 3.5 3.0 2.5 2.0 ttrip1 (Ctrip1 = 0pF) ttrip2 (Ctrip2 = 10pF) 1.5 1.0 -20 0.6 0 20 40 60 4 3 2 0 25 50 75 100 CONNECTIVE CAPACITANCE, Ctrip, (pF) (PIN: 29-21) ID-IO CHARACTERISTICS (TYPICAL) VOH, | VOL | -Ta CHARACTERISTICS (TYPICAL) 22 0.2 0.1 0.05 0.10 0.15 0.20 LOAD CURRENT, IO, (AMPERES (PIN: 19-21, 22) 04/14 Rev. 0 5 AMBIENT TEMPERATURE, Ta, (°C) 0.3 0 6 0 80 0.4 0 7 1 VD = 15V Ta = 25°C 0.5 VD = 15V Ta = 25°C 8 “H” OUTPUT VOLTAGE, VOH, (VOLTS) “L” OUTPUT VOLTAGE, | VOL |, (VOLTS) CONTROLLED TIME DETECT SHORT CIRCUIT, ttrip1, ttrip2, (μs) 9 VD = 15V Rg = 1Ω Load: C = 1.6μF 5.5 INPUT CURRENT, ID, (AMPERES) ttrip-Ctrip CHARACTERISTICS (TYPICAL) 0.25 20 18 16 125 VD = 15V RG = 1Ω LOAD: C = 1.6μF VOH | VOL | 14 12 10 8 6 4 -20 0 20 40 60 80 AMBIENT TEMPERATURE, Ta, (°C) 5 Powerex, Inc., 173 Pavilion Lane, Youngwood, Pennsylvania 15697 (724) 925-7272 www.pwrx.com VLA553-01R / -02R IGBT Gate Driver + DC/DC Converter η-Idrive CHARACTERISTICS (TYPICAL) 80 20 VD = 15V Ta = 25°C 70 18 16 VCC, | VEE |, (VOLTS) EFFICIENCY, η, (%) 60 50 40 30 20 0 0.05 0.10 0.16 0.20 8 6 0 0.25 IO = 0.1A Ta = 25°C VCC | VEE | 13 16 17 η-VD CHARACTERISTICS (TYPICAL) 0.15 0.10 RG = 1Ω LOAD: = C = 1.6μF 15V 16.5V 20 40 18 IO = 0.1A Ta = 25°C 70 0.20 0 15 Idrive-Ta CHARACTERISTICS (TYPICAL) 75 0.05 14 SUPPLY VOLTAGE, VD, (VOLTS) EFFICIENCY, η, (%) GATE DRIVE CURRENT, Idrive, (AMPERES) 10 GATE DRIVE CURRENT, Idrive, (AMPERES) 65 60 55 50 45 60 80 AMBIENT TEMPERATURE, Ta, (°C) 6 12 2 0.25 0 14 4 10 0 VCC, | VEE | -VD CHARACTERISTICS (TYPICAL) 100 40 13 14 15 16 17 18 SUPPLY VOLTAGE, VD, (VOLTS) 04/14 Rev. 0 Powerex, Inc., 173 Pavilion Lane, Youngwood, Pennsylvania 15697 (724) 925-7272 www.pwrx.com VLA553-01R / -02R IGBT Gate Driver + DC/DC Converter TOTAL ZENER VOLTAGE CHARACTERISTICS 0F VLA533-01R (TYPICAL) TOTAL ZENER VOLTAGE CHARACTERISTICS 0F VLA533-02R (TYPICAL) 1300 1100 1000 900 800 700 600 1600 MAXIMUM TYPICAL MINIMUM 1500 1400 1300 1200 1100 1000 500 -30 -10 10 30 50 70 90 110 130 150 JUNCTION TEMPERATURE, Tj, (°C) 04/14 Rev. 0 1700 ZENER VOLTAGE, VZ, (VOLTS) ZENER VOLTAGE, VZ, (VOLTS) 1200 1800 MAXIMUM TYPICAL MINIMUM 900 -30 -10 10 30 50 70 90 110 130 150 JUNCTION TEMPERATURE, Tj, (°C) 7