1530-1-W

Features ■ ■ ■ ■ ■ ■ ■ ■ Applications GDT-TBU® High-Speed Protector technology Low impulse voltage let-through Low impulse current let-through High surge current rating 10/100/1000 Mbps data compatibility Transparent to Mode A or Mode B Compatible with Class 4 power levels UL Listed per E153537 Vol 2 Sec 2 ■ Data communications ■ Highly exposed Ethernet ■ Telecommunication and indoor industrial installations ■ Surveillance cameras ■ Remote power and communication 1530-1 Series PoE Ethernet Surge Protector The Bourns® Model 1530-1 Series Commercial PoE Ethernet Surge Protectors incorporate state-of-the-art gas discharge tube and surge limiting technologies to provide the highest protection level offered by Bourns. The Model 1530-1 Series is designed to meet applicable Telcordia GR-1089 Level 1 and Level 2 Surge and AC Power Fault specifications on the data signal line while allowing operations up to 35 watts (employing both Mode A and B combination) at 57 volts. The Model 1530-1 Series enclosure is flame retardant and manufactured with a high impact resistant plastic. Characteristics Test methods per UL 497B, GR-1089, CSA C22.2, IEC 61000-4-5, and IEEE 802.3at. Parameter DC Breakdown on Data Lines DC Breakdown - Power Lines Power Rating Line Series Resistance (Loop) Line Series Balance Capacitance Line to Line @ 1 MHz BER Performance Testing 10/100/1000 Mbps Surge Response Time Surge Limiting Performance Let-Through Voltage Let-Through Current First Level Surge 1 kV – 10/1000 μs, 100 A 2.5 kV – 2/10 μs, 500 A 800 V – 1.2/50 μs, 8/20 μs Combo Wave Second Level Surge 2.5 kV – 2/10 μs, 500 A, Inductive Kick 1 6 kV / 3 kA – 1.2/50 μs, 8/20 μs 1 Combo – 10/1000 μs, 100 A First Level Power Fault 220 mA Below Protection Threshold 600 V / 1 A / 1 Second 1000 V / 1 A / 1 Second 425 V / 0.5 A / 4 Seconds Second Level Power Fault 120 V / 25 A 1 425 V / 40 A / 1.5 Second 1 425 V / 7 A / 5 Seconds 1 425 V / 2.2 A 1 Storage and Effective Temperature UL Flame Rating Commercial Model 1530-1 150 V Typical Input / 7 V Typical Output < 200 V Typ. 35 W ~ 6 Ω Typ. 0.5 Ω Typ. / 1.0 Ω Max 10 pF Typ. > 100 meters < 1 μs < 60 V < 1A > 10 operations > 10 operations > 10 operations 1 operation 1 operation > 10 operations 15 minutes > 60 operations > 60 operations > 1 operation 15 minutes 1 operation 1 operation 15 minutes -40 to +65 °C 94 V0 Ingress Protection Ratings 20 Notes: UL Listed component, UL File E153537 1) Fuse may fail open and disconnect from circuit. WARNING Cancer and Reproductive Harm www.P65Warnings.ca.gov Specifications are subject to change without notice. Users should verify actual device performance in their specific applications. The products described herein and this document are subject to specific legal disclaimers as set forth on the last page of this document, and at www.bourns.com/docs/legal/disclaimer.pdf. 1530-1 Series PoE Ethernet Surge Protector Performance Graphs WITHOUT Bourns® Active Surge Limiting Technology * A. B. WITH Bourns® Active Surge Limiting Technology With impulse input @ 10/1000 μs, 1.5 kV, 100 A. Applied to inputs Tip (A) or Ring (B) in reference to Ground (Earth) and measured at outputs Tip (A) or Ring (B) in reference to Ground (Earth) with 50 ohms load. Applied between inputs Tip (A) or Ring (B) and measured between outputs Tip (A) or Ring (B) with 50 ohms load. Wiring / Pin-Out Information (Default T568B Wiring Scheme Silkscreened on PCB.) Pin No. Pin 1 Pin 2 Pin 3 Pin 6 Pin 4 Pin 5 Pin 7 Pin 8 T568A Wire Color White / Green Stripe Green Solid White / Orange Stripe Orange Solid Blue Solid White / Blue Stripe White / Brown Stripe Brown Sollid T568B Wire Color White / Orange Stripe Orange Solid White / Green Stripe Green Solid Blue Solid White / Blue Stripe White / Brown Stripe Brown Sollid Data Line Information TxRx A+ TxRx ATxRx B+ TxRx BTxRx C+ TxRx CTxRx D+ TxRx D- Power Line Information DC + DC + DC DC DC + DC + DC DC - How to Order Model Number 1530-1D ................................................................................................................................................................DIN Rail Mount, No Ground Wire 1530-1D-W..........................................................................................................................................................DIN Rail Mount, with Ground Wire 1530-1-W ...................................................................................................................................................................Wall Mount, with Ground Wire Specifications are subject to change without notice. Users should verify actual device performance in their specific applications. The products described herein and this document are subject to specific disclaimers as set forth on the last page of this document, and at www.bourns.com/legal/disclaimer.pdf. 1530-1 Series PoE Ethernet Surge Protector Product Dimensions 65.10 (2.56) 25.12 (0.99) WITHOUT DIN RAIL 15.75 (0.62) LINE SIDE 46.48 (1.83) 107.0 (4.21) PROTECTED 40.64 (1.60) DIMENSIONS: MM (INCHES) Asia-Pacific: Tel: +886-2 2562-4117 • Email: asiacus@bourns.com EMEA: Tel: +36 88 885 877 • Email: eurocus@bourns.com The Americas: Tel: +1-951 781-5500 • Email: americus@bourns.com www.bourns.com REV. B 10/19 “Bourns” is a registered trademark of Bourns, Inc. in the United States and other countries. “TBU” is a registered trademark of Bourns, Inc. in the U.S. and other countries, except Japan. All references to TBU® in this document for use in Japan shall be deemed to be replaced with Bourns® TBU™. Specifications are subject to change without notice. Users should verify actual device performance in their specific applications. The products described herein and this document are subject to specific disclaimers as set forth on the last page of this document, and at www.bourns.com/legal/disclaimer.pdf. Legal Disclaimer Notice This legal disclaimer applies to purchasers and users of Bourns® products manufactured by or on behalf of Bourns, Inc. and P[ZHɉSPH[LZJVSSLJ[P]LS`¸)V\YUZ¹ Unless otherwise expressly indicated in writing, Bourns® products and data sheets relating thereto are subject to change ^P[OV\[UV[PJL